Flow field characteristics of catalytic muffler for medium-heavy duty truck
-
摘要: 运用Fluent软件计算了不同进气端结构和形状的中重型卡车催化消声器载体前端面进气均匀性和进出口总压差, 分析了其流场特性。计算结果表明: 催化消声器流场特性与发动机排气量有关, 载体前端面进气均匀性和进出口总压差对于分析流场特性至关重要; 添加挡板后载体前端面进气均匀性和进出口总压差均增大, 添加竖挡板的流场特性最佳; 进气管直径收缩40mm和排气管直径扩张40mm的流场特性较好; 当发动机转速分别为900、1 900r·min-1时, 催化消声器优化后载体前端面进气均匀性比优化前分别提高了1.2%、1.6%, 进出口总压差比优化前分别降低了57.5%、63.9%, 结构优化对降低进出口总压差效果明显; 与桶型催化消声器相比, 箱型催化消声器的载体前端面进气均匀性增加; 选择催化消声器还应考虑空间布置与利用效率。Abstract: Aiming at catalytic mufflers with different air inlet structures and shapes of mediumheavy duty truck, the air inlet uniformity of carrier front face and the total pressure difference between the inlet and outlet were calculated by Fluent software, and the flow field characteristics were analyzed.Calculation result indicates that the flow field characteristics of catalytic muffler are related to engine exhaust.The air inlet uniformity of carrier front face and the total pressure difference between the inlet and outlet are very important for analyzing the flow field characteristics.The air inlet uniformity and the total pressure difference increase after adding baffle, and the flow field characteristics are best after adding erect baffle.The flow field characteristics are good when inlet pipe diameter shrinks by 40 mm and outlet pipe diameter expands by 40 mm.After optimizing catalytic muffler, the air inlet uniformities of carrier front face respectively increase by 1.2%and 1.6%, and the total pressure differences between the inlet and outlet respectively decrease by 57.5%and 63.9%compared to the values before optimization when engine rotation speeds are 900r·min-1 and 1 900r·min-1 respectively, which shows that structure optimization significantly decreases the total pressure difference.Compared to barrel shape catalytic muffler, the air inlet uniformity of carrier front face for box shape catalytic muffler increases.Spatial arrangement and utilization efficiency should be considered as well forchoosing catalytic muffler.
-
表 1 发动机排气参数
Table 1. Parameters of engine exhaust
表 2 桶形催化消声器流场特性
Table 2. Flow field characteristics of barrel shape catalytic muffler
表 3 模型1~3的前端面进气均匀性
Table 3. Air inlet uniformities of front faces for models 1-3
表 4 模型1~3的进出口总压差
Table 4. Total pressure differences between inlets and outlets for models 1-3
表 5 模型1、4、5的前端面进气均匀性
Table 5. Air inlet uniformities of front faces for models 1, 4, 5
表 6 模型1、4、5的进出口总压差
Table 6. Total pressure differences between inlets and outlets for models 1, 4, 5
表 7 不同进气管直径的载体前端面进气均匀性
Table 7. Air inlet uniformities of carrier front faces for different inlet pipe diameters
表 8 不同进气管直径的进出口总压差
Table 8. Total pressure differences between inlets and outlets for different inlet pipe diameters
表 9 不同排气管直径的载体前端面进气均匀性
Table 9. Air inlet uniformities of carrier front faces for different outlet pipe diameters
表 10 不同排气管直径的进出口总压差
Table 10. Total pressure differences between inlets and outlets for different outlet pipe diameters
表 11 转速为900r·min-1时的流场特性比较
Table 11. Comparison of flow field characteristics with rotation speed of 900r·min-1
表 12 转速为1900r·min-1时的流场特性比较
Table 12. Comparison of flow field characteristics with rotation speed of 1 900r·min-1
表 13 两种催化消声器流场特性比较
Table 13. Comparison of flow field characteristics for two types of catalytic mufflers
-
[1] SABBAH R, KIZILEL R, SELMAN J R, et al. Active(air-cooled)vs. passive(phase change material)thermal management of high power lithium-ion packs: limitation of temperature rise and uniformity of temperature distribution[J]. Journal of Power Sources, 2008, 182(2): 630-638. doi: 10.1016/j.jpowsour.2008.03.082 [2] XU Xiao-ming, HE Ren. Review on the heat dissipation performance of battery pack with different structures and operation conditions[J]. Renewable and Sustainable Energy Reviews, 2014, 29: 301-315. doi: 10.1016/j.rser.2013.08.057 [3] 杨帆, 胡阳洋, 王建华. 重型卡车风阻优化[J]. 交通运输工程学报, 2013, 13(6): 54-60. doi: 10.3969/j.issn.1671-1637.2013.06.008YANG Fan, HU Yang-yang, WANG Jian-hua. Optimization of wind resistance for heavy truck[J]. Journal of Traffic and Transportation Engineering, 2013, 13(6): 54-60. (in Chinese) doi: 10.3969/j.issn.1671-1637.2013.06.008 [4] 尹和俭. 紧凑式SCR净化消声装置设计与仿真研究[D]. 哈尔滨: 哈尔滨工程大学, 2010.YIN He-jian. Study on design and simulation of compact SCR purified noise reduction devices[D]. Harbin: Harbin Engineering University, 2010. (in Chinese) [5] HOWITT J S, SEKELLA T C. Flow effects in monolithic honeycomb automotive catalytic converters[J]. SAE Technical Papers, 1974, 83: 1067-1075. [6] JEONG S J, KIM W S, KIM T. An application of CFD to improve warm-up performance of the 3-way auto-catalyst by high surface area and low thermal mass[J]. International Journal of Vehicle Design, 2002, 29(3): 243-268. doi: 10.1504/IJVD.2002.002012 [7] CHEN Ping-en, WANG Jun-min. Air-fraction modeling for simultaneous diesel engine NOX and PM emissions control during active DPF regenerations[J]. Applied Energy, 2014, 122: 310-320. doi: 10.1016/j.apenergy.2014.02.031 [8] HU Y, GALLAND M A, CHEN K. Acoustic transmission performance of double-wall active sound packages in a tube: numerical/experimental validations[J]. Applied Acoustics, 2012, 73(4): 323-337. doi: 10.1016/j.apacoust.2011.10.003 [9] LIU Lian-yun, HAO Zhi-yong, LIU Chi. CFD analysis of a transfer matrix of exhaust muffler with mean flow and prediction of exhaust noise[J]. Journal of Zhejiang University Science A: Applied Physics and Engineering, 2012, 13(9): 709-716. [10] LEE S J, JEONG S J, KIM W S. Numerical design of the diesel particulate filter for optimum thermal performances during regeneration[J]. Applied Energy, 2009, 86(7/8): 1124-1135. [11] PANIGRAHI S N, MUNJAL M L. Back pressure considerations in designing of cross flow perforated-element reactive silencers[J]. Noise Control Engineering Journal, 2007, 55(6): 504-515. doi: 10.3397/1.2817808 [12] KOJIMA N, NAKAMURA Y, FUKUDA M. A study on the correlation between fluctuating velocity in a muffler and air flow noise[J]. JSME International Journal, 1987, 30(265): 1113-1120. doi: 10.1299/jsme1987.30.1113 [13] 帅石金, 王建昕, 庄人隽, 等. 车用催化器流场数值模拟及其在结构优化设计中的应用[J]. 内燃机学报, 2002, 20(2): 211-216. https://www.cnki.com.cn/Article/CJFDTOTAL-NRJX200002024.htmSHUAI Shi-jin, WANG Jian-xin, ZHUANG Ren-jun, et al. Numerical simulation of flows in automotive catalytic converters and its application on optimum structure design[J]. Transactions of CSICE, 2002, 20(2): 211-216. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-NRJX200002024.htm [14] 刘军, 苏清祖. 排气催化转化器气流分布的数值模拟和试验[J]. 农业工程学报, 2003, 19(1): 95-98. https://www.cnki.com.cn/Article/CJFDTOTAL-NYGU200301025.htmLIU Jun, SU Qing-zu. Numerical simulation and testing research on flow distribution in catalytic converter[J]. Transactions of the CSAE, 2003, 19(1): 95-98. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-NYGU200301025.htm [15] 谷芳, 刘伯潭, 李洪亮, 等. 基于CFD数值模拟的汽车排气系统结构分析[J]. 内燃机学报, 2007, 25(4): 358-363. doi: 10.3321/j.issn:1000-0909.2007.04.012GU Fang, LIU Bo-tan, LI Hong-liang, et al. Structural analyses for the vehicle exhausts system based on CFD simulation[J]. Transactions of CSICE, 2007, 25(4): 358-363. (in Chinese) doi: 10.3321/j.issn:1000-0909.2007.04.012 [16] 袭著坤. 重载柴油机选择性催化消声器的设计研究[D]. 太原: 太原理工大学, 2009.XI Zhu-kun. Research and designing of selective reduction catalyst converter combined with silencer for heavy duty diesel engine[D]. Taiyuan: Taiyuan University of Technology, 2009. (in Chinese) [17] 白丹丹. Urea-SCR催化器系统的仿真与研究[D]. 大连: 大连理工大学, 2012.BAI Dan-dan. Modeling and research of Urea-SCR exhaust system[D]. Dalian: Dalian University of Technology, 2012. (in Chinese) [18] 葛继伟, 王志. 不同进/出口分布的消声器性能研究[J]. 机械制造与自动化, 2015, 44(2): 7-10. https://www.cnki.com.cn/Article/CJFDTOTAL-ZZHD201502003.htmGE Ji-wei, WANG Zhi. Analysis of expansion muffler performance with different inlet/outlet distribution[J]. Machine Building and Automation, 2015, 44(2): 7-10. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZZHD201502003.htm [19] 黎苏, 葛蕴珊, 黎志勤, 等. 抗性消声器的三维声学边界元模型及其应用[J]. 内燃机学报, 1992, 10(2): 147-154. https://www.cnki.com.cn/Article/CJFDTOTAL-NRJX199202008.htmLI Su, GE Yun-shan, LI Zhi-qin, et al. A three-dimensional acoustic boundary element model of the reactive mufflers and its application[J]. Transactions of CSICE, 1992, 10(2): 147-154. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-NRJX199202008.htm [20] 伏军, 龚金科, 袁文华, 等. 微粒捕集器再生背压阈值MAP图建立及其应用[J]. 农业工程学报, 2013, 29(12): 47-56. https://www.cnki.com.cn/Article/CJFDTOTAL-NYGU201312009.htmFU Jun, GONG Jin-ke, YUAN Wen-hua, et al. Establi-shment and application of MAP for regeneration back-pressure threshold value of diesel particulate filter[J]. Transactions of the Chinese Society of Agricultural Engineering, 2013, 29(12): 47-56. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-NYGU201312009.htm -