Flexural behaviors of composite continuous box-girder with corrugated steel webs, double concrete filled steel tubular chords and concrete slabs
Article Text (Baidu Translation)
-
摘要: 提出了新型波形钢腹板-双管弦杆-混凝土板组合梁, 混凝土顶板与双钢管混凝土下弦杆由波形钢腹板连接。为了分析新型组合梁在正、负弯矩作用下的受弯性能, 进行了组合连续梁的受弯试验, 研究了试验梁的破坏模式、变形特性、应变特性与混凝土顶板裂缝发展规律。根据试验结果, 提出了新型组合梁的变形和承载力计算方法, 并验证了方法的有效性。试验结果表明: 在正、负弯矩区段, 组合截面波形钢腹板各测点纵向应变很小, 跨中和支点处纵向应变峰值仅为下弦杆的3.7%和5.1%, 可忽略不计; 混凝土顶板和钢管混凝土下弦杆纵向应变沿截面高度方向基本呈线性变化, 满足平截面假定, 在外荷载作用下共同受力; 当组合试验梁达到开裂荷载140 kN时, 主梁跨中挠度理论计算值为5.8 mm, 试验值为5.5 mm, 误差约为5%, 当组合试验梁跨中截面达到极限抗弯承载力时, 荷载理论计算值为399 kN, 试验值为415 kN, 试验值略高于理论计算值, 但两者误差很小, 约为4%, 说明该组合梁的挠度和抗弯承载力理论计算方法简单、可靠。Abstract: A new composite structure composed of corrugated steel webs(CSW), double concrete filled steel tubular chords(CFST)and concrete slabs(CS)was presented.To understand the flexural behaviors under positive and negative bending moments, the experiments of new composite continuous box-girder were carried out, and the failure modes and deflection patterns of the girder, and the development rules of concrete plate cracks were studied.According to the test results, the calculation methods of deformation and bearing capacity of the new type of composite girder were put forward and verified.Experimental result shows the strain peak values of mid-span and intermediate support are only 3.7% and 5.1% of the value of bottom steel concrete pipe chord respectively, therefore the longitudinal strains of corrugated steel webs are small and negligible in the positive and negative bending moment areas.The longitudinal strains linearly change along the height of cross section, thus the plane cross-section assumption can beapplied in the composite girder.Moreover, the top concrete flange and the bottom steel concrete pipe chord bear load together.When the cracking load is 140 kN, the calculated and experimental deflection are 5.8 mm and 5.5 mm, respectively, and the relative error is about 5%.When the load of mid-span cross section of test beam reaches the ultimate flexural capacity, the theoretical and experimental load are 399 kN and 415 kN, respectively, the experimental value is slightly higher than the calculated value, but the error is very small and about 4%, so the theoretical calculation methods of deflection and flexural capacity of composite beam are simple and reliable.
-
图 8 挠度和应变测点布置(单位: mm)
Figure 8. Layout of measuring points of deflection and strain(units: mm)
图 10 负弯矩区段混凝土顶板裂缝分布
Figure 10. Cracks distribution of top flange in negative moment region
图 16 中支点主梁沿梁高应变分布
Figure 16. Strain distributions along height of girder at intermediate support
图 20 中支点主梁腹板剪应变沿腹板高度分布
Figure 20. Shear strain distributions of main beam's web along height of web at intermediate support
图 21 跨中主梁腹板剪应变沿腹板高度分布
Figure 21. Shear strain distributions of main beam's web along height of web at mid-span
-
[1] 陈宝春, 王远洋, 黄卿维. 波形钢腹板混凝土拱桥新桥型构思[J]. 世界桥梁, 2006(4): 10-14. doi: 10.3969/j.issn.1671-7767.2006.04.004CHEN Bao-chun, WANG Yuan-yang, HUANG Qing-wei. Conception of new type of concrete arch bridge with corrugated steel webs[J]. World Bridges, 2006(4): 10-14. (in Chinese). doi: 10.3969/j.issn.1671-7767.2006.04.004 [2] 聂建国, 陶慕轩, 吴丽丽, 等. 钢-混凝土组合结构桥梁研究新进展[J]. 土木工程学报, 2012, 45(6): 110-122. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201206016.htmNIE Jian-guo, TAO Mu-xuan, WU Li-li, et al. Advances of research on steel-concrete composite bridge[J]. China Civil Engineering Journal, 2012, 45(6): 110-122. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201206016.htm [3] 严国敏. 西欧结合梁桥的现有发展水平——介绍10座结合梁桥[J]. 国外桥梁, 1992(4): 1-7. https://www.cnki.com.cn/Article/CJFDTOTAL-GWQL199204001.htmYAN Guo-min. The development of existing combined girder bridges in Western Europe—introduce ten combined girder bridges[J]. Foreign Bridges, 1992(4): 1-7. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GWQL199204001.htm [4] 刘磊, 钱冬生. 波纹钢腹板预应力结合梁桥[J]. 国外公路, 1999, 19(1): 26-30. https://www.cnki.com.cn/Article/CJFDTOTAL-GWGL901.005.htmLIU Lei, QIAN Dong-sheng. Prestressed combined girder bridge with corrugated steel webs[J]. Journal of Foreign Highway, 1999, 19(1): 26-30. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GWGL901.005.htm [5] 董桔灿. 波形钢腹板-双管弦杆-混凝土板连续梁桥试设计研究[J]. 中外公路, 2013, 33(4): 138-142. doi: 10.3969/j.issn.1671-2579.2013.04.034DONG Ju-can. Design of continuous girder bridge with corrugated steel webs(CSW), double concrete filled steel tubular chords(CFST)and concrete slabs(CS)[J]. Journal of China and Foreign Highway, 2013, 33(4): 138-142. (in Chinese). doi: 10.3969/j.issn.1671-2579.2013.04.034 [6] CHAN C L, KHALID Y A, SAHARI B B, et al. Finite element analysis of corrugated web beams under bending[J]. Journal of Constructional Steel Research, 2002, 58(1): 1391-1406. [7] 陈宝春, 黄卿维. 波形钢腹板PC梁桥应用综述[J]. 公路, 2005(7): 45-53. https://www.cnki.com.cn/Article/CJFDTOTAL-GLGL200507010.htmCHEN Bao-chun, HUANG Qing-wei. A summary of application of PC box-girder bridges with corrugated steel webs[J]. Highway, 2005(7): 45-53. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GLGL200507010.htm [8] 宋建永, 张树仁, 王彤, 等. 波纹钢腹板体外预应力组合梁弯曲性能分析及试验研究[J]. 土木工程学报, 2004, 37(11): 50-55. doi: 10.3321/j.issn:1000-131X.2004.11.008SONG Jian-yong, ZHANG Shu-ren, WANG Tong, et al. A theoretical analysis and experimental study on the flexural behavior of externally prestressed composite beam with corrugated steel webs[J]. China Civil Engineering Journal, 2004, 37(11): 50-55. (in Chinese). doi: 10.3321/j.issn:1000-131X.2004.11.008 [9] SAYED-AHMED E Y. Behaviour of steel and(or)composite girders with corrugated steel webs[J]. Canadian Journal of Civil Engineering, 2001, 28(4): 656-672. doi: 10.1139/l01-027 [10] MO Y L, JENG C H, KRAWINKLER H. Experimental and analytical studies of innovative prestressed concrete boxgirder bridges[J]. Materials and Structures, 2003, 36(2): 99-107. doi: 10.1007/BF02479523 [11] 李立峰, 刘志才, 王芳. 波形钢腹板PC组合箱梁抗弯承载力的理论与试验研究[J]. 工程力学, 2009, 26(7): 89-96. https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200907019.htmLI Li-feng, LIU Zhi-cai, WANG Fang. Theoretical and experimental research on the flexural behavior of external prestressed composite beam with corrugated steel webs[J]. Engineering Mechanics, 2009, 26(7): 89-96. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200907019.htm [12] 李宏江, 叶见曙, 万水, 等. 波形钢腹板预应力混凝土箱梁的试验研究[J]. 中国公路学报, 2004, 17(4): 31-36. doi: 10.3321/j.issn:1001-7372.2004.04.007LI Hong-jiang, YE Jian-shu, WAN shui, et al. Experimental research on prestressed concrete box girder with corrugated steel webs[J]. China Journal of Highway and Transport, 2004, 17(4): 31-36. (in Chinese). doi: 10.3321/j.issn:1001-7372.2004.04.007 [13] 聂建国, 唐亮. 基于弹性扭转约束边界的波形钢板整体剪切屈曲分析[J]. 工程力学, 2008, 25(7): 1-7. https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200803004.htmNIE Jian-guo, TANG Liang. Global shear buckling of corrugated steel plates with edges elastically restrained against rotation[J]. Engineering Mechanics, 2008, 25(7): 1-7. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200803004.htm [14] 陈宜言, 陈宝春, 林松. 波形钢腹板PC组合箱梁抗扭性能试验和有限元分析[J]. 建筑科学与工程学报, 2011, 28(4): 106-115. https://www.cnki.com.cn/Article/CJFDTOTAL-XBJG201104019.htmCHEN Yi-yan, CHEN Bao-chun, LIN Song. Experiment of torsional performance and finite element analysis of PC composite box girder with corrugated steel webs[J]. Journal of Architecture and Civil Engineering, 2011, 28(4): 106-115. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-XBJG201104019.htm [15] MO Y L, JENG C H, CHANG Y S. Torsional behavior of prestressed concrete box-girder bridges with corrugated steel webs[J]. ACI Structural Journal, 2002, 97(6): 849-859. [16] 聂建国, 唐亮. 波形钢腹板PC组合箱梁纯扭性能的非线性分析[J]. 中国公路学报, 2007, 20(7): 71-77. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL200705014.htmNIE Jian-guo, TANG Liang. Nonlinear analysis of pure torsion property for prestressed concrete composite box girders with corrugated steel webs[J]. China Journal of Highway and Transport, 2007, 20(7): 71-77. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL200705014.htm [17] ELGAALY M, HAMILTON R W, SESHADRI A. Shear strength of beams with corrugated webs[J]. Journal of Structural Engineering, 1996, 122(4): 390-398. doi: 10.1061/(ASCE)0733-9445(1996)122:4(390) [18] ELGAALY M, SESHADRI A, HAMILTON R W. Bending strength of steel beams with corrugated webs[J]. Journal of Structural Engineering, 1997, 123(6): 772-782. doi: 10.1061/(ASCE)0733-9445(1997)123:6(772) [19] ELGAALY M, SESHADRI A. Girders with corrugated webs under partial compressive edge loading[J]. Journal of Structural Engineering, 1997, 123(6): 783-791. doi: 10.1061/(ASCE)0733-9445(1997)123:6(783) [20] ELGAALY M, SESHADRI A. Depicting the behavior of girders with corrugated webs up to failure using non-linear finite element analysis[J]. Advances in Engineering Software, 1998, 29(3-6): 195-208. [21] EL METWALLY A, LOOV R E. Corrugated steel webs for prestressed concrete girders[J]. Materials and Structures, 2003, 36(2): 127-134. [22] 吴文清, 叶见曙, 万水, 等. 波纹钢腹板-混凝土组合箱梁截面变形的拟平截面假定及其应用研究[J]. 工程力学, 2005, 22(5): 177-180, 198. https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200505031.htmWU Wen-qing, YE Jian-shu, WAN Shui, et al. Quasi plane assumption and its application in steel-concrete composite box girders with corrugated steel webs[J]. Engineering Mechanics, 2005, 22(5): 177-180, 198. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200505031.htm [23] 徐岳, 朱万勇, 杨岳. 波形钢腹板PC组合箱梁桥抗弯承载力计算[J]. 长安大学学报: 自然科学版, 2005, 25(2): 60-64. https://www.cnki.com.cn/Article/CJFDTOTAL-XAGL20050200D.htmXU Yue, ZHU Wan-yong, YANG Yue. Calculation of ultimate moment capacity of prestressed concrete box-girder bridge with corrugated steel webs[J]. Journal of Chang'an University: Natural Science Edition, 2005, 25(2): 60-64. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-XAGL20050200D.htm [24] 周绪红, 张茜, 贺拴海, 等. 预应力混凝土波形钢腹板组合箱梁受力性能的有限元分析[J]. 哈尔滨工业大学学报, 2005, 35(增): 575-580. https://cpfd.cnki.com.cn/Article/CPFDTOTAL-ZGJF200505002152.htmZHOU Xu-hong, ZHANG Qian, HE Shuan-hai, et al. The mechanical property of the prestressed concrete composite box girders with corrugated steel webs[J]. Journal of Harbin Institute of Technology, 2005, 35(S): 575-580. (in Chinese). https://cpfd.cnki.com.cn/Article/CPFDTOTAL-ZGJF200505002152.htm [25] 周武. 钢管混凝土弦杆-混凝土桥面板组合桁梁静力性能研究[D]. 福州: 福州大学, 2011.ZHOU Wu. Research on static behavior of composite truss girder structure with CFST chord and concrete slab[D]. Fuzhou: Fuzhou University, 2011. (in Chinese). -
下载:
点击查看大图
图(23) / 表(2)
计量
- 文章访问数: 921
- HTML全文浏览量: 243
- PDF下载量: 598
- 被引次数: 0
