Test and analysis on frost heaven effects of cold region tunnel
Article Text (Baidu Translation)
-
摘要: 为研究寒区隧道冻胀力随时间和空间的分布规律, 基于温度场变化定义了测试冻胀力, 通过衬砌压力和钢架应力间接反映真实冻胀力的变化规律; 提出了冻胀力简化测试方法, 研发了温度场-冻胀力同步测试系统; 以四川省省道215线鸡丑山隧道为例, 布置5个测试断面开展大规模现场测试, 并选取典型断面K117+700 (简称700断面) 和K117+600 (简称600断面) 分析了隧道环境温度、围岩温度、衬砌压力与钢架应力; 以围岩冻结(12~次年2月) 和未冻(7~9月) 时对应的衬砌压力和钢架应力差值为测试冻胀力, 结合温度场分析了隧道周边各测点测试冻胀力; 采用现有冻胀模型计算理论冻胀力, 并与测试冻胀力进行了对比, 研究了寒区隧道冻胀规律。分析结果表明: 隧道环境温度随时间呈季节性正弦函数变化, 受环境温度影响, 围岩温度呈季节性正负温变化, 并出现季节性冻融现象; 当围岩为负温时处于冻结状态, 支护系统受到围岩压力和冻胀力的共同作用, 且温度越低冻胀效应越明显, 各断面测点应力峰值均出现在1月, 700断面衬砌和钢架最大应力分别为149kPa、31MPa; 当围岩为正温时处于未冻结状态, 支护系统仅受到围岩压力作用; 同一断面不同测点的测试冻胀力差值可达5.23MPa, 说明冻胀力除与围岩温度有关外, 还与富水条件和围岩级别有关; 最大冻胀力实测值比理论计算值小1.25MPa, 因此, 寒区隧道支护设计时建议考虑89.17%的冻胀力折减系数。Abstract: To investigate the distribution law of frost heaven force with time and space, the test frost heaven force was defined based on the temperature field. The change law of the frost heaven force was described by the lining pressure and steel arch stress. A new test method of frost heaven force was presented based on the temperature field, and a temperature field-frost heaven force synchronization test system was developed. Took Jichoushan Tunnel of Sichuan Provincial Highway 215 as an example, 5 test sections were set to conduct large-scale field tests, and the typical sections of K117+700 (section 700 for short) and K117+600 (section 600 for short) were selected to investigate the tunnel environment temperature, surrounding rock temperature, secondary lining pressure and steel arch stress. The differences in the stresses of the secondary lining and steel arch between the conditions of freezing (from December to February of next year) and unfreezing (from July to September) were defined as the test frost heaven force, and the testfrost heaven force was analyzed through the temperature field. Subsequently, the theoretical frost heaven force was computed by the existing frost heaven model and compared with the field test result, and the frost heaven law of the tunnel in the cold region was studied. Analysis result shows that the tunnel environment temperature changes with time as a seasonal sine functional variation. The surrounding rock temperature affected by the environment temperature changes as a seasonal positive and negative temperature variation, and a seasonal freezing-thawing phenomenon appears. Under the negative temperature, the surrounding rock is frozen, and the supporting system is affected by the pressure of the surrounding rock and frost heaven force. The lower the temperature, the more obvious is the effect of the frost heaven. The peak value of stress of each section appears in January. The maximum stresses of lining and steel arch of section 700 are 149 kPa and 31 MPa, respectively. Under a positive temperature, the surrounding rock is unfrozen, and the supporting system is only affected by the pressure of the surrounding rock. The maximum difference of frost heaven forces among different test points on the same section can reach 5.23 MPa. It is illustrated that the frost heaven force is not only related to the temperature field, but also to the rich water condition and surrounding rock grade. The test frost heaven force is 1.25 MPa less than the calculated one. Therefore, a frost heaven force reduction coefficient of 89.17% should be considered when designing the supporting.12 figs, 36 refs.
-
Key words:
- tunnel engineering /
- temperature field /
- frozen depth /
- frost heaven force /
- field test
-
图 2 温度场-冻胀力同步测试系统
Figure 2. Synchronization test system of temperature field-frost heaven force
图 4 温度与冻胀力测点布置
Figure 4. Layout of measuring points of temperature and frost heaven force
图 9 围岩冻结前后衬砌压力对比(单位: kPa)
Figure 9. Comparison of lining pressures before and after surrounding rock freezing (unit: kPa)
图 11 围岩冻结前后钢架应力对比(单位: MPa)
Figure 11. Comparison of steep frame stresses before and after surrounding rock freezing (unit: MPa)
-
[1] JUN K J, HWANG Y C, YUNE C Y. Field measurement of temperature inside tunnel in winter in Gangwon, Korea[J]. Cold Regions Science and Technology, 2017, 143: 32-42. doi: 10.1016/j.coldregions.2017.08.011 [2] 姚红志, 张晓旭, 董长松. 多年冻土区公路隧道融化圈计算方法[J]. 交通运输工程学报, 2016, 16 (4): 141-150. doi: 10.3969/j.issn.1671-1637.2016.04.015YAO Hong-zhi, ZHANG Xiao-xu, DONG Chang-song. Calculation method of thawing circle for highway tunnel in permafrost regions[J]. Journal of Traffic and Transportation Engineering, 2016, 16 (4): 141-150. (in Chinese). doi: 10.3969/j.issn.1671-1637.2016.04.015 [3] 覃爱民, 骆汉宾. 基于Mohr-Coulomb准则寒区隧道围岩应力弹塑性解析[J]. 地下空间与工程学报, 2018, 14 (2): 395-402. https://www.cnki.com.cn/Article/CJFDTOTAL-BASE201802015.htmQIN Ai-min, LUO Han-bin. Analytical elasto-plastic solution for stress of surrounding rock based on Mohr-Coulomb criterion[J]. Chinese Journal of Underground Space and Engineering, 2018, 14 (2): 395-402. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-BASE201802015.htm [4] 张德华, 王梦恕, 谭忠盛, 等. 风火山隧道围岩冻胀对支护结构体系的影响[J]. 岩土工程学报, 2003, 25 (5): 571-573. doi: 10.3321/j.issn:1000-4548.2003.05.011ZHANG De-hua, WANG Meng-shu, TAN Zhong-sheng, et al. Effect of frost heaven on tunnel supporting systems of Fenghuoshan Railway Tunnel[J]. Chinese Journal of Geotechnical Engineering, 2003, 25 (5): 571-573. (in Chinese). doi: 10.3321/j.issn:1000-4548.2003.05.011 [5] 伍毅敏, 李文博, 傅鹤林, 等. 季冻区隧道过渡段二衬短周期冻融数值模拟[J]. 岩土工程学报, 2017, 39 (10): 1930-1935. doi: 10.11779/CJGE201710023WU Yi-min, LI Wen-bo, FU He-lin, et al. Numerical simulation of freeze-thaw in short period of secondary lining at tunnel transition section in seasonal frozen area[J]. Chinese Journal of Geotechnical Engineering, 2017, 39 (10): 1930-1935. (in Chinese). doi: 10.11779/CJGE201710023 [6] WANG Tao, ZHOU Guo-qing, WANG Jian-zhou, et al. Stochastic analysis of uncertainty mechanical characteristics for surrounding rock and lining in cold region tunnels[J]. Cold Region Science and Technology, 2018, 145: 160-168. doi: 10.1016/j.coldregions.2017.10.016 [7] LI Shuang-yang, NIU Fu-jun, LAI Yuan-ming, et al. Optimal design of thermal insulation layer of a tunnel in permafrost regions based on coupled heat-water simulation[J]. Applied Thermal Engineering, 2017, 110: 1264-1273. doi: 10.1016/j.applthermaleng.2016.09.033 [8] ZHANG Ming-yi, PEI Wan-sheng, LAI Yuan-ming, et al. Numerical study of the thermal characteristics of a shallow tunnel section with a two-phase closed thermosyphon group in apermafrost region under climate warming[J]. International Journal of Heat and Mass Transfer, 2017, 104: 952-963. doi: 10.1016/j.ijheatmasstransfer.2016.09.010 [9] ZENG Yan-hua, LIU Ke-lin, ZHOU Xiao-han, et al. Tunnel temperature fields analysis under the couple effect of convection-conduction in cold regions[J]. Applied Thermal Engineering, 2017, 120: 378-392. doi: 10.1016/j.applthermaleng.2017.03.143 [10] CHEN Jian-xun, DENG Xiang-hui, LUO Yan-bin, et al. Investigation of microstructural damage in shotcrete under a freeze-thaw environment[J]. Construction and Building Materials, 2015, 83: 275-282. doi: 10.1016/j.conbuildmat.2015.02.042 [11] 王柱, 董长松, 韩常领, 等. 高寒冻融环境下隧道结构服役性能预测模型[J]. 交通运输工程学报, 2016, 16 (4): 133-140. doi: 10.3969/j.issn.1671-1637.2016.04.014WANG Zhu, DONG Chang-song, HAN Chang-ling, et al. Service performance prediction model of tunnel structure in alpine freezing-thawing environment[J]. Journal of Traffic and Transportation Engineering, 2016, 16 (4): 133-140. (in Chinese). doi: 10.3969/j.issn.1671-1637.2016.04.014 [12] LAI Jin-xing, WANG Xiu-ling, QIU Jun-ling, et al. A stateof-the-art review of sustainable energy based freeze proof technology for cold-region tunnels in China[J]. Renewable and Sustainable Energy Reviews, 2018, 82: 3554-3569. doi: 10.1016/j.rser.2017.10.104 [13] SHANG Yan-liang, DU Shou-ji, GAO Hong-hong, et al. Study on the relation between mineral compositions of rock and construction characteristics of tunnel in cold regions: a case[J]. Sains Malaysiana, 2017, 36 (11): 2241-2250. [14] ZHANG Guo-zhu, LIU Song-yu, ZHAO Xu. The coupling effect of ventilation and groundwater flow on the thermal performance of tunnel lining GHEs[J]. Applied Thermal Engineering, 2017, 112: 595-605. doi: 10.1016/j.applthermaleng.2016.10.120 [15] XING Rong-jun, JIANG Shu-ping, XU Pai. Long-term temperature monitoring of tunnel in high-cold and high-altitude area using distributed temperature monitoring system[J]. Measurement, 2017, 95: 456-464. doi: 10.1016/j.measurement.2016.10.032 [16] LAI Jin-xing, QIU Jun-ling, FAN Hao-bo, et al. Freeze-proof method and test verification of a cold region tunnel employing electric heat tracing[J]. Tunnelling and Underground Space Technology, 2016, 60: 56-65. doi: 10.1016/j.tust.2016.08.002 [17] 《中国公路学报》编辑部. 中国隧道工程学术研究综述·2015[J]. 中国公路学报, 2015, 28 (5): 1-65. doi: 10.3969/j.issn.1001-7372.2015.05.001Editorial Department of China Journal of Highway and Transport. Review on China's tunnel engineering research: 2015[J]. China Journal of Highway and Transport, 2015, 28 (5): 1-65. (in Chinese). doi: 10.3969/j.issn.1001-7372.2015.05.001 [18] 汪双杰, 王佐, 袁堃, 等. 青藏公路多年冻土地区公路工程地质研究回顾与展望[J]. 中国公路学报, 2015, 28 (12): 1-8. doi: 10.3969/j.issn.1001-7372.2015.12.001WANG Shuang-jie, WANG Zuo, YUAN Kun, et al. Qinghai-Tibet Highway engineering geology in permafrost regions: review and prospect[J]. China Journal of Highway and Transport, 2015, 28 (12): 1-8. (in Chinese). doi: 10.3969/j.issn.1001-7372.2015.12.001 [19] 韩常领, 姚红志, 董长松. 多年冻土区公路隧道围岩荷载计算方法[J]. 中国公路学报, 2015, 28 (12): 114-119. doi: 10.3969/j.issn.1001-7372.2015.12.016HAN Chang-ling, YAO Hong-zhi, DONG Chang-song. Calculation methods for supporting load of highway tunnels in permafrost regions[J]. China Journal of Highway and Transport, 2015, 28 (12): 114-119. (in Chinese). doi: 10.3969/j.issn.1001-7372.2015.12.016 [20] 夏才初, 范东方, 韩常领. 寒区隧道不同类型冻土段隔热(保温) 层铺设厚度计算方法[J]. 中国公路学报, 2013, 26 (5): 131-139. doi: 10.3969/j.issn.1001-7372.2013.05.018XIA Cai-chu, FAN Dong-fang, HAN Chang-ling. Piecewise calculation method for insulation layer thickness in cold region tunnel[J]. China Journal of Highway and Transport, 2013, 26 (5): 131-139. (in Chinese). doi: 10.3969/j.issn.1001-7372.2013.05.018 [21] 史保华, 梅平, 刘远飞, 等. 防止寒冷地区机场水泥混凝土道面冻胀问题的施工措施[J]. 筑路机械与施工机械化, 2014, 31 (10): 62-65. doi: 10.3969/j.issn.1000-033X.2014.10.023SHI Bao-hua, MEI Ping, LIU Yuan-fei, et al. Prevention of frost heave damage to airport pavement in cold region[J]. Road Machinery and Construction Mechanization, 2014, 31 (10): 62-65. (in Chinese). doi: 10.3969/j.issn.1000-033X.2014.10.023 [22] 乜风鸣. 寒冻地区铁路隧道气温状态[J]. 冰川冻土, 1988, 10 (4): 450-453. https://www.cnki.com.cn/Article/CJFDTOTAL-BCDT198804008.htmNIE Feng-ming. Dynamic state of air temperature in railway tunnels in cold regions[J]. Journal of Glaciology and Geocryology, 1988, 10 (4): 450-453. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-BCDT198804008.htm [23] 晏启祥, 何川, 曾东洋. 寒区隧道温度场及保温隔热层研究[J]. 四川大学学报: 工程科学版, 2005, 37 (3): 24-27. doi: 10.3969/j.issn.1009-3087.2005.03.006YAN Qi-xiang, HE Chuan, ZENG Dong-yang. Study of temperature field and heat preservation and insulation layer for tunnel in cold area[J]. Journal of Sichuan University: Engineering Science Edition, 2005, 37 (3): 24-27. (in Chinese). doi: 10.3969/j.issn.1009-3087.2005.03.006 [24] 陈建勋, 昝勇杰. 寒冷地区公路隧道防冻隔温层效果现场测试与分析[J]. 中国公路学报, 2001, 14 (4): 75-79. doi: 10.3321/j.issn:1001-7372.2001.04.018CHEN Jian-xun, ZAN Yong-jie. Field test and analysis of antifreezing thermal-protective layer effect of the highway tunnel in cold area[J]. China Journal of Highway and Transport, 2001, 14 (4): 75-79. (in Chinese). doi: 10.3321/j.issn:1001-7372.2001.04.018 [25] 陈建勋, 罗彦斌. 寒冷地区隧道防冻隔温层厚度计算方法[J]. 交通运输工程学报, 2007, 7 (2): 76-79. doi: 10.3321/j.issn:1671-1637.2007.02.016CHEN Jian-xun, LUO Yan-bin. Calculation method of antifreezing layer thickness in cold region tunnel[J]. Journal of Traffic and Transportation Engineering, 2007, 7 (2): 76-79. (in Chinese). doi: 10.3321/j.issn:1671-1637.2007.02.016 [26] 陈建勋. 公路隧道冻害防治技术[J]. 长安大学学报: 自然科学版, 2006, 26 (4): 68-70. https://www.cnki.com.cn/Article/CJFDTOTAL-XAGL200604015.htmCHEN Jian-xun. Technique of preventing frost damage in highway tunnel[J]. Journal of Chang'an University: Natural Science Edition, 2006, 26 (4): 68-70. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-XAGL200604015.htm [27] 周小涵, 曾艳华, 范磊, 等. 寒区隧道温度场的时空演化规律及温控措施研究[J]. 中国铁道科学, 2016, 37 (3): 46-52. doi: 10.3969/j.issn.1001-4632.2016.03.007ZHOU Xiao-han, ZENG Yan-hua, FAN Lei, et al. Temperature-spatial evolution laws of temperature field in cold region tunnel and temperature control measures[J]. China Railway Science, 2016, 37 (3): 46-52. (in Chinese). doi: 10.3969/j.issn.1001-4632.2016.03.007 [28] ZHOU Xiao-han, ZENG Yan-hua, FAN Lei. Temperature field analysis of a cold-region railway tunnel considering mechanical and train-induced ventilation effects[J]. Applied Thermal Engineering, 2016, 100: 114-124. doi: 10.1016/j.applthermaleng.2016.01.070 [29] 夏才初, 吕志涛, 黄继辉, 等. 寒区隧道围岩最大冻结深度计算的半解析方法[J]. 岩土力学, 2018, 39 (6): 1001-1010. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201806029.htmXIA Cai-chu, LU Zhi-tao, HUANG Ji-hui, et al. Semianalytical method of the maximum frozen depth calculation in cold region tunnel[J]. Rock and Soil Mechanics, 2018, 39 (6): 1001-1010. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201806029.htm [30] 张国柱, 夏才初, 殷卓. 寒区隧道轴向及径向温度分布理论解[J]. 同济大学学报: 自然科学版, 2010, 38 (8): 1117-1122, 1160. doi: 10.3969/j.issn.0253-374x.2010.08.003ZHANG Guo-zhu, XIA Cai-chu, YIN Zhuo. Analytical solution to axial and radial temperature of tunnel in cold region[J]. Journal of Tongji University: Natural Science, 2010, 38 (8): 1117-1122, 1160. (in Chinese). doi: 10.3969/j.issn.0253-374x.2010.08.003 [31] 赖远明, 吴紫汪, 朱元林, 等. 寒区隧道冻胀力的粘弹性解析解[J]. 铁道学报, 1999, 21 (6): 70-74. doi: 10.3321/j.issn:1001-8360.1999.06.017LAI Yuan-ming, WU Zi-wang, ZHU Yuan-lin, et al. Analytical viscoelastic solution for frost force of cold regional tunnels[J]. Journal of the China Railway Society, 1999, 21 (6): 70-74. (in Chinese). doi: 10.3321/j.issn:1001-8360.1999.06.017 [32] 王建宇, 胡元芳. 隧道衬砌冻胀压力问题初探[J]. 铁道工程学报, 2004 (1): 87-93. doi: 10.3969/j.issn.1006-2106.2004.01.020WANG Jian-yu, HU Yuan-fang. A discussion on frost heave force acting on tunnel lining[J]. Journal of Railway Engineering Society, 2004 (1): 87-93. (in Chinese). doi: 10.3969/j.issn.1006-2106.2004.01.020 [33] 张祉道, 王联. 高海拔及严寒地区隧道防冻设计探讨[J]. 现代隧道技术, 2004, 41 (3): 1-6. doi: 10.3969/j.issn.1009-6582.2004.03.001ZHANG Zhi-dao, WANG Lian. Discussion on the design of tunnels in high elevation and bitter cold region[J]. Modern Tunnelling Technology, 2004, 41 (3): 1-6. (in Chinese). doi: 10.3969/j.issn.1009-6582.2004.03.001 [34] 仇文革, 孙兵. 寒区破碎岩体隧道冻胀力室内对比试验研究[J]. 冰川冻土, 2010, 32 (3): 557-561. https://www.cnki.com.cn/Article/CJFDTOTAL-BCDT201003018.htmQIU Wen-ge, SUN Bing. Model test study of frost heaven pressures in tunnels excavated in fractured rock mass in cold regions[J]. Journal of Glaciology and Geocryology, 2010, 32 (3): 557-561. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-BCDT201003018.htm [35] 渠孟飞, 谢强, 胡熠, 等. 寒区隧道衬砌冻胀力室内模型试验研究[J]. 岩石力学与工程学报, 2015, 34 (9): 1894-1900. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201509020.htmQU Meng-fei, XIE Qiang, HU Yi, et al. Model test on frost heaven force of tunnel lining in cold region[J]. Chinese Journal of Rock Mechanics and Engineering, 2015, 34 (9): 1894-1900. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201509020.htm [36] 杨国柱. 青藏铁路昆仑山隧道防冻胀结构研究[J]. 隧道建设, 2008, 28 (3): 263-267. https://www.cnki.com.cn/Article/CJFDTOTAL-JSSD200803003.htmYANG Guo-zhu. Case study on anti-frost-heaven structure of Kunlunshan Tunnel on Qinghai-Tibet Railway[J]. Tunnel Construction, 2008, 28 (3): 263-267. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JSSD200803003.htm -
下载:
点击查看大图
图(12)
计量
- 文章访问数: 863
- HTML全文浏览量: 248
- PDF下载量: 499
- 被引次数: 0
