Bearing mechanism of composite foundation with rigid-flexible piles in loess area
Article Text (Baidu Translation)
-
摘要: 为了揭示湿陷性黄土地区刚-柔性桩复合地基的荷载传递机理, 开展了现场原型试验, 分析了桩身和桩间土的应力在不同荷载与深度下的变化规律; 通过与刚性单桩的对比, 总结了刚-柔性桩复合地基的桩土相互作用特点; 结合已有文献, 分析了湿陷性黄土地区刚-柔性桩复合地基与软土地区刚-柔性桩复合地基在力学表现上的差异。分析结果表明: 湿陷性黄土地区刚-柔性桩复合地基中柔性桩的主要作用是挤密桩间土, 消除其湿陷性, 试验场地处理后湿陷系数基本小于0.015;由于柔性桩的挤密作用, 桩间土的承载力得以充分发挥, 刚性桩的荷载传递能力得以增强; 软土地区柔性桩的荷载分担率一般大于桩间土, 由于黄土的承载力较高及柔性桩与桩间土的模量比小, 湿陷性黄土地区桩间土的荷载分担率稳定在26%左右, 远大于柔性桩的7%;复合地基中的刚性桩属于端承摩擦桩, 随着荷载增加, 刚性桩的荷载传递能力逐渐强化, 荷载分担率逐渐增加, 最终稳定在67%左右; 刚性桩荷载传递能力的增强并不利于刚-柔性桩复合地基承载能力的充分发挥, 在设计时需要充分考虑对纯摩擦桩有效桩长的影响, 以及对端承摩擦桩桩端土体承载能力的影响。Abstract: In order to investigate the loading transfer mechanism of composite foundation with rigid-flexible piles in collapsible loess area, a field prototype test was conducted. The stress variation rules of piles and soil among piles with different loads and depths were analyzed. Taking the behaviors of rigid single pile as comparison, the characteristic of pile-soil interaction in composite foundation with rigid-flexible piles was summarized. Combined with existing literatures, the difference of mechanical performance between the composite foundation with rigid-flexible piles in collapsible loess area and soft soil area was analyzed. Analysis result indicates that the flexible pile of composite foundation with rigid-flexible piles in collapsible loess area is mainly used to compact the soil among piles and eliminate the collapsibility of soil, and the collapsibility coefficients are basically less than 0.015 after the treatment in the test site. As a result of the compaction of flexible pile, the bearing capacity of soil among piles can be fully developed and the loading transfer ability of rigid pile can be enhanced. The load-sharing ratio of flexible pile is always larger than that of soil among piles in soft soil area. As a result of the high bearing capacity of loess and small modulus ratio between the flexible pile and soil among piles, the load-sharing ratio of soil among piles in collapsible loess area is stable at about 26%, much higher than 7% of flexible piles. The rigid pile in composite foundation pertains to an end bearing friction pile. As the loading increases, the loading transfer ability of rigid pile improves gradually, and the load sharing ratio increases and finally settles at 67%. The improvement of the loading transfer ability of rigid piles is against the development of the bearing capacity of composite foundation with rigid-flexible piles, of which effects on the valid length of pure friction pile should be taken into account in the designing process, and its effects on the bearing capacity of soil at the bottom of the pile of end bearing friction pile should be also been considered.
-
图 3 承载板下土压力盒布置(单位: mm)
Figure 3. Layout of soil pressure cells under bearing plate (unit: mm)
图 4 A-A断面竖向测试元件分布(单位: mm)
Figure 4. Distribution of test components along vertical direction of A-A section (unit: mm)
图 7 复合地基中刚性桩轴力分布
Figure 7. Axial force distributions of rigid pile in composite foundation
图 9 复合地基中刚性桩桩侧摩阻力分布
Figure 9. Frictional resistance distributions of rigid pile in composite foundation
图 10 挤密前后地基土湿陷系数
Figure 10. Collapsibility coefficients of foundation soil before and after compaction
表 1 主要土层物理力学性质指标
Table 1. Physical and mechanical property indexes of main soil layers
地层编号 土质 平均厚度/m 指标统计值 含水率/% 密度/ (g·cm-3) 饱和度/% 孔隙比 压缩系数/MPa-1 压缩模量/MPa ②-1 黄土状粉土 11.5 平均值 10.4 1.52 28.6 0.973 0.31 8.66 标准值 11.5 1.50 31.7 1.002 0.36 7.53 ②-4 粉土 7.6 平均值 17.4 1.84 66.1 0.730 0.14 14.20 标准值 18.5 1.82 70.6 0.751 0.16 12.96 
下载: 导出CSV
表 2 试验概况
Table 2. Presentations of tests
试验对象 试验点 土体挤密情况 桩长/m 桩直径/mm 砂垫层 承载板直径/mm 强度等级 测量仪器 刚性桩单桩 G 均已挤密且试验位置大致对称 8 400 无 400 C15 振弦式混凝土应力计 刚-柔性桩复合地基 刚性桩 F 有 1 654 C15 振弦式混凝土应力计 柔性桩 土压力盒
下载: 导出CSV
表 3 桩间土应力与桩土应力比
Table 3. Stresses of soil among piles and pile-soil stress ratios
荷载/kN 111 204 297 391 485 578 672 桩间土应力均值/kPa 83 99 110 122 133 141 155 刚性桩-土应力比(SG/ST) 4.123 7.879 11.937 14.672 15.556 20.426 22.846 柔性桩-土应力比(SR/ST) 1.018 1.020 1.024 1.025 1.049 1.057 1.065 荷载/kN 765 859 952 1 045 1 138 1 231 1 324 桩间土应力均值/kPa 160 171 179 186 191 206 217 刚性桩-土应力比(SG/ST) 24.125 26.759 31.117 31.788 33.770 33.029 33.335 柔性桩-土应力比(SR/ST) 1.069 1.053 1.112 1.156 1.199 1.199 1.207
下载: 导出CSV
-
[1] 朱奎, 徐日庆, 郭印, 等. 刚-柔性桩复合地基变形特性有限元分析[J]. 岩土力学, 2008, 29 (4): 937-942. doi: 10.3969/j.issn.1000-7598.2008.04.016ZHU Kui, XU Ri-qing, GUO Yin, et al. Finite element analysis of deformation characteristics of composite foundation with rigid-flexible piles[J]. Rock and Soil Mechanics, 2008, 29 (4): 937-942. (in Chinese). doi: 10.3969/j.issn.1000-7598.2008.04.016 [2] 葛忻声, 龚晓南, 张先明. 长短桩复合地基有限元分析及设计计算方法探讨[J]. 建筑结构学报, 2003, 24 (4): 91-96. doi: 10.3321/j.issn:1000-6869.2003.04.014GE Xin-sheng, GONG Xiao-nan, ZHANG Xian-ming. FEM analysis and design of long-short-pile composite foundation[J]. Journal of Building Structures, 2003, 24 (4): 91-96. (in Chinese). doi: 10.3321/j.issn:1000-6869.2003.04.014 [3] 张世民, 魏新江, 魏纲, 等. 刚柔复合桩基性状的有限元分析[J]. 岩土力学, 2006, 27 (增): 826-831. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX2006S2014.htmZHANG Shi-min, WEI Xin-jiang, WEI Gang, et al. Finite element analysis of rigid-soft composite pile foundation[J]. Rock and Soil Mechanics, 2006, 27 (S): 826-831. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX2006S2014.htm [4] 张世民, 魏新江, 秦建堂. 长短桩在深厚软土中的应用研究[J]. 岩石力学与工程学报, 2005, 24 (增2): 5427-5432. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2005S2028.htmZHANG Shi-min, WEI Xin-jiang, QIN Jian-tang. Research on application of long-short piles to deep-thick soft soil area[J]. Chinese Journal of Rock Mechanics and Engineering, 2005, 24 (S2): 5427-5432. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2005S2028.htm [5] 刘海涛, 谢新宇, 程功, 等. 刚-柔性桩复合地基试验研究[J]. 岩土力学, 2005, 26 (2): 303-306. doi: 10.3969/j.issn.1000-7598.2005.02.028LIU Hai-tao, XIE Xin-yu, CHENG Gong, et al. Experimental study of the rigid-flexible piles composite foundation[J]. Rock and Soil Mechanics, 2005, 26 (2): 303-306. (in Chinese). doi: 10.3969/j.issn.1000-7598.2005.02.028 [6] 朱奎, 徐日庆. 有无褥垫层刚-柔性桩复合地基性状对比研究[J]. 岩土工程学报, 2006, 28 (10): 1230-1235. doi: 10.3321/j.issn:1000-4548.2006.10.010ZHU Kui, XU Ri-qing. Comparative study on behavior of composite foundation of rigid-flexible piles with or without cushion[J]. Chinese Journal of Geotechnical Engineering, 2006, 28 (10): 1230-1235. (in Chinese). doi: 10.3321/j.issn:1000-4548.2006.10.010 [7] 朱奎, 徐日庆. 置换率对刚-柔性桩复合地基的影响[J]. 哈尔滨工业大学学报, 2009, 41 (4): 148-152. doi: 10.3321/j.issn:0367-6234.2009.04.032ZHU Kui, XU Ri-qing. Influences of different replacement ratios on composite foundation with rigid-flexible piles[J]. Journal of Harbin Institute of Technology, 2009, 41 (4): 148-152. (in Chinese). doi: 10.3321/j.issn:0367-6234.2009.04.032 [8] 朱奎, 魏纲, 徐日庆. 刚-柔性桩复合地基中桩荷载传递规律试验研究[J]. 岩土力学, 2009, 30 (1): 201-205, 210. doi: 10.3969/j.issn.1000-7598.2009.01.035ZHU Kui, WEI Gang, XU Ri-qing. Research on in-situ tests of pile load transfer behaviors in composite foundation with rigid-flexible piles[J]. Rock and Soil Mechanics, 2009, 30 (1): 201-205, 210. (in Chinese). doi: 10.3969/j.issn.1000-7598.2009.01.035 [9] 谢新宇, 杨相如, 施尚伟, 等. 刚柔性长短桩复合地基性状分析[J]. 岩土力学, 2007, 28 (5): 877-882. doi: 10.3969/j.issn.1000-7598.2007.05.006XIE Xin-yu, YANG Xiang-ru, SHI Shang-wei, et al. Engineering characteristics of composite foundation with rigid-flexible and long-short piles[J]. Rock and Soil Mechanics, 2007, 28 (5): 877-882. (in Chinese). doi: 10.3969/j.issn.1000-7598.2007.05.006 [10] 王瑞芳, 傅旭东, 李勇泉, 等. 长短桩复合地基受荷性状的影响因素分析[J]. 武汉大学学报(工学版), 2010, 43 (5): 613-616, 622. https://www.cnki.com.cn/Article/CJFDTOTAL-WSDD201005019.htmWANG Rui-fang, FU Xu-dong, LI Yong-quan, et al. Influence factor analysis of load-bearing character of long-short piles for composite foundation[J]. Engineering Journal of Wuhan University, 2010, 43 (5): 613-616, 622. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-WSDD201005019.htm [11] 雷胜友, 李肖伦, 李洋, 等. 高速铁路路基下复合地基沉降计算方法[J]. 交通运输工程学报, 2015, 15 (3): 9-15. doi: 10.3969/j.issn.1671-1637.2015.03.003LEI Sheng-you, LI Xiao-lun, LI Yang, et al. Calculation method of composite foundation settlement under high-speed railway subgrade[J]. Journal of Traffic and Transportation Engineering, 2015, 15 (3): 9-15. (in Chinese). doi: 10.3969/j.issn.1671-1637.2015.03.003 [12] 左珅, 刘维正, 张瑞坤, 等. 路堤荷载下刚柔长短桩复合地基承载特性研究[J]. 西南交通大学学报, 2014, 49 (3): 379-385. doi: 10.3969/j.issn.0258-2724.2014.03.002ZUO Shen, LIU Wei-zheng, ZHANG Rui-kun, et al. Bearing behaviour of composite foundation with rigid-flexible and long-short piles under embankment load[J]. Journal of Southwest Jiaotong University, 2014, 49 (3): 379-385. (in Chinese). doi: 10.3969/j.issn.0258-2724.2014.03.002 [13] ZHENG Jun-jie, ABUSHARAR S W, WANG Xian-zhi. Three-dimensional nonlinear finite element modeling of composite foundation formed by CFG-lime piles[J]. Computers and Geotechnics, 2008, 35 (4): 637-643. doi: 10.1016/j.compgeo.2007.10.002 [14] 芮瑞, 孙义, 朱勇, 等. 刚性基础下复合地基褥垫层细观工作机制[J]. 岩土力学, 2019, 40 (2): 445-454. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201902005.htmRUI Rui, SUN Yi, ZHU Yong, et al. Mesoscopic working mechanism of cushion of composite foundation under rigid slab[J]. Rock and Soil Mechanics, 2019, 40 (2): 445-454. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201902005.htm [15] 朱小军, 孔伟阳, 费康, 等. 复合地基垫层刺入量模型试验与计算方法研究[J]. 地下空间与工程学报, 2018, 14 (2): 412-419. https://www.cnki.com.cn/Article/CJFDTOTAL-BASE201802017.htmZHU Xiao-jun, KONG Wei-yang, FEI Kang, et al. Experimental research and calculation methods of cushion penetration in composite foundation[J]. Chinese Journal of Underground Space and Engineering, 2018, 14 (2): 412-419. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-BASE201802017.htm [16] 刘开富, 许家培, 曹玲珑. 刚柔性桩加筋垫层复合地基承载性状数值分析[J]. 浙江理工大学学报(自然科学版), 2018, 39 (3): 372-377. doi: 10.3969/j.issn.1673-3851(n).2018.03.019LIU Kai-fu, XU Jia-pei, CAO Ling-long. Numerical analysis on bearing behavior of rigid-flexible pile composite foundation with reinforced cushion[J]. Journal of Zhejiang Sci-Tech University (Natural Sciences), 2018, 39 (3): 372-377. (in Chinese). doi: 10.3969/j.issn.1673-3851(n).2018.03.019 [17] YE Guan-bao, ZHANG Qing-wen, ZHANG Zhen, et al. Centrifugal modeling of a composite foundation combined with soil-cement columns and prefabricated vertical drains[J]. Soils and Foundations, 2015, 55 (5): 1259-1269. doi: 10.1016/j.sandf.2015.09.024 [18] LAI Jin-xing, LIU Hou-quan, QIU Jun-ling, et al. Stress analysis of CFG pile composite foundation in consolidating saturated mine tailings dam[J]. Advances in Materials Science and Engineering, 2016, 2016 (1): 1-12. [19] SAMANTA M, BHOWMIK R. 3D numerical analysis of piled raft foundation in stone column improved soft soil[J]. International Journal of Geotechnical Engineering, 2019, 13 (5): 474-483. doi: 10.1080/19386362.2017.1368139 [20] ABUSHARAR S W, ZHENG Jun-jie, CHEN Bao-guo. Finite element modeling of the consolidation behavior of multi-column supported road embankment[J]. Computers and Geotechnics, 2009, 36 (4): 676-685. doi: 10.1016/j.compgeo.2008.09.006 [21] WANG Xian-zhi, ZHENG Jun-jie, YIN Jian-hua. On composite foundation with different vertical reinforcing elements under vertical loading: a physical model testing study[J]. Journal of Zhejiang University—Science A (Applied Physics and Engineering), 2010, 11 (2): 80-87. doi: 10.1631/jzus.A0900252 [22] LIANG Fa-yun, CHEN Long-zhu, SHI Xu-guang. Numerical analysis of composite piled raft with cushion subjected to vertical load[J]. Computers and Geotechnics, 2003, 30 (6): 443-453. doi: 10.1016/S0266-352X(03)00057-0 [23] MOAYED R Z, IZADI E, MIRSEPAHI M. 3D finite elements analysis of vertically loaded composite piled raft[J]. Journal of Central South University, 2013, 20 (6): 1713-1723. doi: 10.1007/s11771-013-1664-y [24] SHARMA V J, VASANVALA S A, SOLANKI C H. Behaviour of load-bearing components of a cushioned composite piled raft foundation under axial loading[J]. Slovak Journal of Civil Engineering, 2014, 22 (4): 25-34. doi: 10.2478/sjce-2014-0020 [25] 白晓红, 崔广仁. CFG桩与夯实水泥土桩复合地基承载力计算[J]. 河南科技大学学报(自然科学版), 2003, 24 (2): 90-93. doi: 10.3969/j.issn.1672-6871.2003.02.026BAI Xiao-hong, CUI Guang-ren. Calculation of bearing capacity of composite base of CFG piles and compacted cement-soil piles[J]. Journal of Henan University of Science and Technology (Natural Science), 2003, 24 (2): 90-93. (in Chinese). doi: 10.3969/j.issn.1672-6871.2003.02.026 [26] 翟晓力, 葛忻声, 张黎明, 等. 湿陷性黄土地区某高层建筑长短桩复合地基现场试验研究[J]. 建筑结构, 2013, 43 (10): 84-88, 75. https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG201310020.htmZHAI Xiao-li, GE Xin-sheng, ZHANG Li-ming, et al. In-situ test study on the long-short-pile composite foundation of a high-rise building in collapsible loess area[J]. Building Structure, 2013, 43 (10): 84-88, 75. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG201310020.htm [27] 李善珍, 马学宁, 田兆斌. 高速铁路长短桩加固黄土地基模型试验研究[J]. 铁道学报, 2016, 38 (10): 78-84. doi: 10.3969/j.issn.1001-8360.2016.10.011LI Shan-zhen, MA Xue-ning, TIAN Zhao-bin. Experimental study on long-short piles reinforced loess foundation for high speed railway[J]. Journal of the China Railway Society, 2016, 38 (10): 78-84. (in Chinese). doi: 10.3969/j.issn.1001-8360.2016.10.011 [28] 李善珍, 马学宁, 田兆斌. 路堤荷载下长短桩加固黄土地基影响因素的分析[J]. 铁道科学与工程学报, 2017, 14 (2): 241-249. doi: 10.3969/j.issn.1672-7029.2017.02.006LI Shan-zhen, MA Xue-ning, TIAN Zhao-bin. Research on influence factors of long-short pile reinforced loess foundation under embankment[J]. Journal of Railway Science and Engineering, 2017, 14 (2): 241-249. (in Chinese). doi: 10.3969/j.issn.1672-7029.2017.02.006 [29] 马学宁, 李善珍, 田兆斌, 等. 长短桩复合地基变形及承载特性研究[J]. 铁道工程学报, 2016, 33 (3): 6-11. doi: 10.3969/j.issn.1006-2106.2016.03.002MA Xue-ning, LI Shan-zhen, TIAN Zhao-bin, et al. Research on the deformation and bearing characteristics of composite foundation with long and short piles[J]. Journal of Railway Engineering Society, 2016, 33 (3): 6-11. (in Chinese). doi: 10.3969/j.issn.1006-2106.2016.03.002 [30] 马天忠, 朱彦鹏, 任永忠, 等. 黄土地区长短组合桩的承载力及变形特性试验研究[J]. 岩土工程学报, 2018, 40 (增1): 259-265, 92. https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC2018S1043.htmMA Tian-zhong, ZHU Yan-peng, REN Yong-zhong, et al. Bearing capacity and displacement characteristics of long-short composite piles in loess areas[J]. Chinese Journal of Geotechnical Engineering, 2018, 40 (S1): 259-265, 92. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC2018S1043.htm [31] 朱彦鹏, 杨校辉, 马天忠, 等. 黄土塬地区大直径长桩承载性状与优化设计研究[J]. 岩石力学与工程学报, 2017, 36 (4): 1012-1023. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201704025.htmZHU Yan-peng, YANG Xiao-hui, MA Tian-zhong, et al. Bearing behavior and optimization design of large-diameter long pile foundation in loess subsoil[J]. Chinese Journal of Rock Mechanics and Engineering, 2017, 36 (4): 1012-1023. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201704025.htm -
点击查看大图
图(15) / 表(3)
计量
- 文章访问数: 2085
- HTML全文浏览量: 226
- PDF下载量: 1321
- 被引次数: 0
