Analysis of electromagnet structure parameters of medium and low speed maglev train based on test data
Article Text (Baidu Translation)
-
摘要: 为提高中低速磁浮列车的承载能力，基于等效磁路法建立了全尺寸悬浮电磁铁磁路模型，推导了包含悬浮电磁铁结构参数的垂向电磁力表达式；基于影响因素分析方法，对比研究了线圈匝数、电磁铁宽度、极板长度等结构参数对悬浮电磁铁垂向电磁力的影响；通过单电磁铁试验台对比了不同悬浮间隙和线圈电流下，线圈匝数分别为320和410时悬浮电磁铁垂向电磁力和浮重比的变化规律，验证了优化线圈匝数对提升中低速磁浮列车悬浮性能的可行性。研究结果表明：相比电磁铁宽度和极板长度，线圈匝数是影响磁浮列车悬浮性能的主要因素，但在10~30 A的小电流范围和大悬浮间隙(>10 mm)的范围内，改变线圈匝数对悬浮电磁铁垂向电磁力的提升效果较弱；当悬浮间隙为8 mm，线圈电流为30~50 A时，410匝悬浮电磁铁相对320匝悬浮电磁铁对悬浮电磁铁垂向电磁力的提升效果明显，平均垂向电磁力提升约2.94 kN，提升比例约为27.8%，平均浮重比提升约2.83，提升比例约为15.33%；随着线圈电流进一步增加，悬浮间隙进一步减小，平均垂向电磁力提升约3.38 kN，提升比例约为25.5%，平均浮重比提升约3.06，提升比例约为13.22%，说明当悬浮间隙为8 mm，线圈电流为30~50 A时，410匝悬浮电磁铁对中低速磁浮列车悬浮性能的提升效果最佳，而410匝悬浮电磁铁垂向电磁力的方差和标准差比320匝悬浮电磁铁的大，说明增加线圈匝数会使得悬浮电磁铁垂向电磁力对参数的变化更敏感。Abstract: To improve the carrying capacity of medium and low speed maglev trains, based on the equivalent magnetic circuit method, a full-size levitation electromagnet magnetic circuit model was established. In addition, the vertical electromagnetic force expression containing the levitation electromagnet structure parameters was deduced. According to the influence factor analysis method, the influences of structure parameters such as the number of coil turns, electromagnet width, and pole plate length on the vertical electromagnetic force of the levitation electromagnet were comparatively investigated. Through the single electromagnet test bench, the changes in the vertical electromagnetic forces and lift-to-weight ratios of levitation electromagnets with 410 and 320 coil turns were compared under different levitation gaps and coil currents. The feasibility of optimizing the coil turns to improve the levitation performance of medium and low speed maglev trains was verified. Research results show that compared with the electromagnet width and pole plate length, the coil turns is the main factor affecting the levitation performance of maglev trains, but in the small current range of 10-30 A and the large levitation gap (>10 mm), changing the coil turns has a weak effect on the enhancement of vertical electromagnetic force of the levitation electromagnet. When the levitation gap is 8 mm, and the current of the coil is 30-50 A, the levitation electromagnet with 410 coil turns is more effective than that with 320 coil turns in improving the vertical electromagnetic force of the levitation electromagnet, and the average vertical electromagnetic force increases by about 2.94 kN, with an enhancement ratio of about 27.8%. The average lift-to-weight ratio increases by about 2.83, and the enhancement ratio is about 15.33%. As the coil current further increases, and the levitation gap further reduces, the average vertical electromagnetic force increases by about 3.38 kN, and the enhancement ratio is about 25.5%. The average lift-to-weight ratio improves by about 3.06, and the enhancement ratio is about 13.22%. It shows that the levitation electromagnet with 410 coil turns has the best effect on improving the levitation performance of medium and low speed maglev trains when the levitation gap is 8 mm, and the coil current is 30-50 A. The variance and standard deviation of vertical electromagnetic force of the levitation electromagnet with 410 coil turns are greater than those with 320 coil turns, indicating that increasing the coil turns will make the vertical electromagnetic force of the levitation electromagnet more sensitive to parameter changes.
-
图 4 磁饱和效应下结构参数对悬浮电磁铁垂向电磁力影响
Figure 4. Influences of structure parameters on vertical electromagnetic force of levitation electromagnet under magnetic saturation effect
图 6 单电磁铁垂向电磁力试验台
Figure 6. Single electromagnet vertical electromagnetic force test bench
图 7 不同悬浮间隙下320和410匝悬浮电磁铁垂向电磁力对比
Figure 7. Comparison of vertical electromagnetic forces between levitation electromagnets with 320 and 410 coil turns under different levitation gaps
图 8 悬浮电磁铁温度测点布置
Figure 8. Arrangement of temperature measuring points for levitation electromagnet
图 9 不同悬浮间隙下320和410匝悬浮电磁铁浮重比对比
Figure 9. Comparison of lift-to-weight ratios between levitation electromagnets with 320 and 410 coil turns under different levitation gaps
表 1 悬浮电磁铁垂向电磁力正相关关联系数
Table 1. Positive correlation coefficients of vertical electromagnetic force of levitation electromagnet
序号 极板长度关联系数 线圈匝数关联系数 1 0.519 1 0.600 4 2 0.525 1 0.605 6 3 0.531 3 0.611 1 4 0.537 7 0.616 6 5 0.544 3 0.622 4 6 0.551 1 0.628 4 7 0.558 2 0.634 5 8 0.565 5 0.640 9 9 0.573 1 0.647 5 10 0.581 0 0.654 3 
下载: 导出CSV
表 2 悬浮电磁铁垂向电磁力负相关关联系数
Table 2. Negative correlation coefficients of vertical electromagnetic force of levitation electromagnet
序号 铁芯宽度关联系数 极板高度关联系数 1 0.489 9 0.475 0 2 0.499 8 0.484 7 3 0.510 0 0.494 7 4 0.520 4 0.505 0 5 0.531 1 0.515 5 6 0.542 1 0.526 4 7 0.553 3 0.537 5 8 0.564 8 0.548 9 9 0.576 6 0.560 7 10 0.588 8 0.572 7
下载: 导出CSV
表 3 320和410匝悬浮电磁铁垂向电磁力对比
Table 3. Comparison of vertical electromagnetic forces between levitation electromagnets with 320 and 410 coil turns
悬浮电流范围/A 悬浮间隙/mm 线圈匝数 电磁力平均值/kN 电磁力标准差/kN 电磁力方差/kN 电磁力极差/kN 10~30 6 320 7.52 3.45 11.92 8.5 410 10.00 4.35 18.93 10.8 8 320 5.36 2.45 6.02 6.1 410 7.36 3.38 11.41 8.3 10 320 4.24 1.90 3.62 4.7 410 5.72 2.57 6.59 6.3 12 320 3.52 1.62 2.61 4.0 410 4.70 2.07 4.31 5.1 30~50 6 320 13.94 1.71 2.92 4.3 410 17.52 1.86 3.45 4.7 8 320 10.58 1.51 2.28 3.9 410 13.52 1.63 2.65 4.0 10 320 8.34 1.24 1.53 3.1 410 10.82 1.50 2.24 3.7 12 320 7.04 1.08 1.16 2.7 410 9.10 1.34 1.79 3.3 50~70 6 320 17.04 0.79 0.63 2.0 410 21.00 0.89 0.79 2.4 8 320 13.26 0.63 0.40 1.6 410 16.64 0.91 0.82 2.3 10 320 10.62 0.65 0.42 1.6 410 13.60 0.83 0.68 2.1 12 320 9.08 0.59 0.35 1.5 410 11.54 0.68 0.47 1.8
下载: 导出CSV
表 4 悬浮电磁铁温升测试结果
Table 4. Temperature rise test results of levitation electromagnets
线圈匝数 测试状态 表面温度/℃ 中心温度/℃ 320 初始状态 23.8 24.6 终末状态 55.0 86.7 410 初始状态 24.2 24.7 终末状态 58.0 90.2
下载: 导出CSV
表 5 320和410匝悬浮电磁铁浮重比对比分析结果
Table 5. Comparative analysis results of lift-to-weight ratios between levitation electromagnets with 320 and 410 coil turns
悬浮电流范围/A 悬浮间隙/mm 线圈匝数 浮重比平均值 浮重比标准差 浮重比方差 浮重比极差 10~30 6 320 13.12 6.02 36.26 14.83 410 15.74 6.85 46.87 17.00 8 320 9.35 4.28 18.33 10.64 410 11.58 5.32 28.27 13.06 10 320 7.40 3.32 11.00 8.20 410 9.00 4.04 16.33 9.91 12 320 6.14 2.82 7.94 6.98 410 7.40 3.27 10.66 8.03 30~50 6 320 24.32 2.98 8.89 7.50 410 27.58 2.92 8.54 7.40 8 320 18.45 2.63 6.93 6.80 410 21.28 2.56 6.57 6.29 10 320 14.54 2.16 4.65 5.41 410 17.03 2.35 5.54 5.82 12 320 12.28 1.88 3.53 4.71 410 14.32 2.10 4.42 5.19 50~70 6 320 29.72 1.38 1.91 3.49 410 33.05 1.40 1.96 3.78 8 320 23.13 1.11 1.23 2.79 410 26.19 1.43 2.04 3.62 10 320 18.52 1.13 1.28 2.79 410 21.40 1.30 1.69 3.31 12 320 15.84 1.03 1.06 2.62 410 18.16 1.08 1.16 2.83
下载: 导出CSV
-
[1] 邓自刚, 刘宗鑫, 李海涛, 等. 磁悬浮列车发展现状与展望[J]. 西南交通大学学报, 2022, 57(3): 455-474, 530.DENG Zi-gang, LIU Zong-xin, LI Hai-tao, et al. Development status and prospect of maglev train[J]. Journal of Southwest Jiaotong University, 2022, 57(3): 455-474, 530. (in Chinese) [2] PRASAD N, JAIN S, GUPTA S. Electrical components of maglev systems: emerging trends[J]. Urban Rail Transit, 2019, 5(2): 67-79. doi: 10.1007/s40864-019-0104-1 [3] 徐飞, 罗世辉, 邓自刚. 磁悬浮轨道交通关键技术及全速度域应用研究[J]. 铁道学报, 2019, 41(3): 40-49. doi: 10.3969/j.issn.1001-8360.2019.03.006XU Fei, LUO Shi-hui, DENG Zi-gang. Study on key technologies and whole speed range application of maglev rail transport[J]. Journal of the China Railway Society, 2019, 41(3): 40-49. (in Chinese) doi: 10.3969/j.issn.1001-8360.2019.03.006 [4] 马卫华, 罗世辉, 张敏, 等. 中低速磁浮车辆研究综述[J]. 交通运输工程学报, 2021, 21(1): 199-216. doi: 10.19818/j.cnki.1671-1637.2021.01.009MA Wei-hua, LUO Shi-hui, ZHANG Min, et al. Research review on medium and low speed maglev vehicle[J]. Journal of Traffic and Transportation Engineering, 2021, 21(1): 199-216. (in Chinese) doi: 10.19818/j.cnki.1671-1637.2021.01.009 [5] WANG Dang-xiong, LI Xiao-zhen, LIANG Lin, et al. Influence of the track structure on the vertical dynamic interaction analysis of the low-to-medium-speed maglev train-bridge system[J]. Advances in Structural Engineering, 2019, 22(14): 2937-2950. doi: 10.1177/1369433219854550 [6] 翟婉明, 赵春发. 磁浮车辆/轨道系统动力学(Ⅰ)——磁/轨相互作用及稳定性[J]. 机械工程学报, 2005, 41(7): 1-10. doi: 10.3321/j.issn:0577-6686.2005.07.001ZHAI Wan-ming, ZHAO Chun-fa. Dynamics of maglev vehicle/guideway systems (Ⅰ)—magnet/rail interaction and system stability[J]. Journal of Mechanical Engineering, 2005, 41(7): 1-10. (in Chinese) doi: 10.3321/j.issn:0577-6686.2005.07.001 [7] 李苗, 马卫华, 龚俊虎, 等. 中低速磁浮车辆-桥梁耦合系统动力性能试验[J]. 交通运输工程学报, 2022, 22(1): 141-154. doi: 10.19818/j.cnki.1671-1637.2022.01.012LI Miao, MA Wei-hua, GONG Jun-hu, et al. Dynamic performance test of medium and low speed maglev vehicle-bridge coupled system[J]. Journal of Traffic and Transportation Engineering, 2022, 22(1): 141-154. (in Chinese) doi: 10.19818/j.cnki.1671-1637.2022.01.012 [8] HA H, PARK J, PARK K S. Advanced numerical analysis for vibration characteristics and ride comfort of ultra-high-speed maglev train[J]. Microsystem Technologies, 2020, 26(1): 183-193. doi: 10.1007/s00542-019-04540-x [9] 刘少克, 倪鸿雁, 张葵葵. 基于数值分析的磁浮列车悬浮电磁铁电磁场分布研究[J]. 铁道学报, 2007, 29(6): 40-43. doi: 10.3321/j.issn:1001-8360.2007.06.007LIU Shao-ke, NI Hong-yan, ZHANG Kui-kui. Research for electromagnetic field of suspension electromagnet of maglev train based on numerical analysis[J]. Journal of the China Railway Society, 2007, 29(6): 40-43. (in Chinese) doi: 10.3321/j.issn:1001-8360.2007.06.007 [10] 倪鸿雁, 刘少克. 磁悬浮列车悬浮电磁铁电磁场三维有限元分析[J]. 铁道机车车辆, 2005, 25(5): 43-45.NI Hong-yan, LIU Shao-ke. Finite element analysis on 3D electromagnetic field of suspension magnet of maglev train[J]. Railway Locomotive and Car, 2005, 25(5): 43-45. (in Chinese) [11] 杨成洪, 吴晓, 何更旺, 等. 中低速磁浮列车悬浮磁铁特性研究[J]. 机械设计与制造, 2021(3): 1-5.YANG Cheng-hong, WU Xiao, HE Geng-wang, et al. Study on performance of the mid-low speed maglev train suspension magnet[J]. Machinery Design and Manufacture, 2021(3): 1-5. (in Chinese) [12] 李海涛. 中低速磁浮列车悬浮电磁铁电磁特性研究与优化[J]. 新型工业化, 2021, 11(1): 62-64.LI Hai-tao. Research and optimization on electromagnetic characteristics of levitation electromagnet in medium and low speed maglev train[J]. The Journal of New Industrialization, 2021, 11(1): 62-64. (in Chinese) [13] 李晨阳, 杨新斌. 中低速磁浮列车悬浮电磁铁电磁分析[J]. 交通技术, 2020, 9(6): 445-454.LI Chen-yang, YANG Xin-bin. Electromagnetic analysis of suspended electromagnet of medium-low speed maglev train[J]. Open Journal of Transportation Technologies, 2020, 9(6): 445-454. (in Chinese) [14] CHUNG Y D, LEE C Y, JANG J Y, et al. Theoretical and FEM analysis of suspension and propulsion system with HTS hybrid electromagnets in an EMS maglev model[J]. Physica C: Superconductivity and its Applications, 2011, 471(21/22): 1487-1491. [15] 刘少克, 倪鸿雁, 张葵葵. 中低速磁悬浮列车悬浮电磁铁线圈电感计算[J]. 机车电传动, 2008(1): 45-47.LIU Shao-ke, NI Hong-yan, ZHANG Kui-kui. Inductance calculation for suspension electromagnet coil of mid-to-low speed maglev train[J]. Electric Drive for Locomotives, 2008(1): 45-47. (in Chinese) [16] 范屹立, 罗世辉, 张敏, 等. 铁芯高度对悬浮电磁铁性能影响研究[J]. 铁道科学与工程学报, 2019, 16(12): 3102-3109.FAN Yi-li, LUO Shi-hui, ZHANG Min, et al. Research on the influence of core height on performance of suspension electromagnet[J]. Journal of Railway Science and Engineering, 2019, 16(12): 3102-3109. (in Chinese) [17] INOUE T, ISHIDA Y. Nonlinear forced oscillation in a magnetically levitated system: the effect of the time delay of the electromagnetic force[J]. Nonlinear Dynamics, 2008, 52(1): 103-113. [18] HÄGELE N, DIGNATH F. Vertical dynamics of the maglev vehicle transrapid[J]. Multibody System Dynamics, 2009, 21(3): 213-231. doi: 10.1007/s11044-008-9136-0 [19] ZHAI Ming-da, LONG Zhi-qiang, LI Xiao-long. Calculation and evaluation of load performance of magnetic levitation system in medium-low speed maglev train[J]. International Journal of Applied Electromagnetics and Mechanics, 2019, 61(4): 519-536. doi: 10.3233/JAE-190031 [20] LI Miao, CHEN Xiao-hao, LUO Shi-hui, et al. Analysis on abnormal low-frequency vertical vibration of medium-low-speed maglev vehicle[J]. Mechanical Systems and Signal Processing, 2023, 200: 110510. doi: 10.1016/j.ymssp.2023.110510 [21] LI Miao, GAO Ding-gang, LUO Shi-hui, et al. Experimental investigation on vibration characteristics of the medium-low-speed maglev vehicle-turnout coupled system[J]. Railway Engineering Science, 2022, 30(2): 242-261. doi: 10.1007/s40534-021-00266-7 [22] 王滢, 刘方麟, 刘世杰, 等. 中低速磁浮列车速度对悬浮力影响分析[J]. 西南交通大学学报, 2023, 58(4): 792-798.WANG Ying, LIU Fang-lin, LIU Shi-jie, et al. Influence of speed on levitation force of medium-low-speed maglev train[J]. Journal of Southwest Jiaotong University, 2023, 58(4): 792-798. (in Chinese) [23] LIU Shao-ke, AN Bang, LIU Si-kai, et al. Characteristic research of electromagnetic force for mixing suspension electromagnet used in low-speed maglev train[J]. IET Electric Power Applications, 2015, 9(3): 223-228. doi: 10.1049/iet-epa.2013.0414 [24] DING Jing-fang, YANG Xin, LONG Zhi-qiang. Structure and control design of suspension electromagnet for electromagnetic levitation medium-speed maglev train[J]. Journal of Vibration and Control, 2019, 25(6): 1179-1193. doi: 10.1177/1077546318813405 [25] LIANG Da, ZHANG Kun-lun, JIANG Qi-long, et al. A novel analytic method to calculate the equivalent stray capacitance of the low-speed maglev train's suspension electromagnet[J]. Energies, 2020, 13(20): 5469. doi: 10.3390/en13205469 [26] 黄允凯, 周涛. 基于等效磁路法的轴向永磁电机效率优化设计[J]. 电工技术学报, 2015, 30(2): 73-79. doi: 10.3969/j.issn.1000-6753.2015.02.010HUANG Yun-kai, ZHOU Tao. Efficiency optimization design of axial flux permanent magnet machines using magnetic equivalent circuit[J]. Transactions of China Electrotechnical Society, 2015, 30(2): 73-79. (in Chinese) doi: 10.3969/j.issn.1000-6753.2015.02.010 [27] HAN D K, CHANG J H. Design of electromagnetic linear actuator using the equivalent magnetic circuit method[J]. IEEE Transactions on Magnetics, 2016, 52(3): 7002104. [28] 刘清辉, 单磊, 马卫华, 等. 考虑剩磁作用的中低速磁浮电磁力分析[J]. 西南交通大学学报, 2023, 58(4): 863-869, 895.LIU Qing-hui, SHAN Lei, MA Wei-hua, et al. Electromagnetic force analysis of medium-low-speed maglev considering remanence[J]. Journal of Southwest Jiaotong University, 2023, 58(4): 863-869, 895. (in Chinese) [29] ZIDARIČ B, MILJAVEC D. A new ferromagnetic hysteresis model for soft magnetic composite materials[J]. Journal of Magnetism and Magnetic Materials, 2011, 323(1): 67-71. doi: 10.1016/j.jmmm.2010.08.031 [30] LIU T, KIKUCKI K, ARA K, et al. Magnetomechanical effect of low carbon steel studied by two kinds of magnetic minor hysteresis loops[J]. NDT and E International, 2006, 39(5): 408-413. doi: 10.1016/j.ndteint.2005.12.001 [31] XU Zhi, YANG Xiao-kuan, ZHAO Xiao-hua, et al. Differences in driving characteristics between normal and emergency situations and model of car-following behavior[J]. Journal of Transportation Engineering, 2012, 138(11): 1303-1313. doi: 10.1061/(ASCE)TE.1943-5436.0000434 [32] 周建民, 余加昌, 张龙, 等. 结合CEEMDAN和灰度关联分析方法的滚动轴承性能退化评估[J]. 华东交通大学学报, 2019, 36(5): 91-96.ZHOU Jian-min, YU Jia-chang, ZHANG Long, et al. Performance degradation evaluation of rolling bearing based on CEEMDAN and gray correlation analysis[J]. Journal of East China Jiaotong University, 2019, 36(5): 91-96. (in Chinese) [33] 刘国清, 张昆仑, 陈殷. HSST型磁浮列车悬浮电磁铁的优化设计[J]. 微特电机, 2013, 41(3): 33-35, 39. doi: 10.3969/j.issn.1004-7018.2013.03.010LIU Guo-qing, ZHANG Kun-lun, CHEN Yin. Optimal design of electromagnet in HSST vehicle's levitation system[J]. Small and Special Electrical Machines, 2013, 41(3): 33-35, 39. (in Chinese) doi: 10.3969/j.issn.1004-7018.2013.03.010 -
点击查看大图
图(9) / 表(5)
计量
- 文章访问数: 274
- HTML全文浏览量: 100
- PDF下载量: 54
- 被引次数: 0
