燃油硫分对柴油机排气成分的影响

魏海军; 孙培廷

燃油硫分对柴油机排气成分的影响

大连海事大学轮机工程学院, 辽宁大连 116026

基金项目:

国家自然科学基金项目 50276006

详细信息

作者简介:
魏海军(1971-), 男, 浙江上虞人, 大连海事大学副教授, 工学博士, 从事现代轮机工程研究

中图分类号: U664.121
计量
- 文章访问数: 302
- HTML全文浏览量: 106
- PDF下载量: 547
- 被引次数: 0
出版历程
- 收稿日期: 2005-10-20
- 刊出日期: 2006-03-25

Effect of Fuel Oil Sulfur on Marine Engine Emissions

School of Marine Engineering, Dalian Maritime University, Dalian 116026, Liaoning, China

More Information

Author Bio:
WEI Hai-jun(1971-), male, associate professor, 86-411-84726029, hxl@dlmu.edu.cn

摘要

摘要: 为研究燃油中不同的硫质量分数在柴油机内的燃烧状况及对柴油机排气成分的影响, 通过对比试验, 利用化学发光法、定电位电解法、磁气风式法、Galvanic Cell Type法及过滤称重法分别测定了硫分质量分数为0、1.5、3.0和5.0时的NO_x、SO_x、CO_x、残碳颗粒(DS) 及可溶性有机物质(SOF) 的浓度及对着火延迟的影响。实验结果表明燃油硫质量分数对柴油机燃烧状况有着一定程度的影响, 随着燃油硫质量分数的增加, 燃油消耗量也随之增加, 在硫质量分数3.5%范围内对燃油消耗量的影响最为显著, 随后处于平缓, 并从而影响排烟温度。CO随硫质量分数的增加而明显上升, 但CO₂基本保持不变; 随着硫质量分数的增加, SOF生成量反而下降, 而DS的生成量则随之上升; NO_x含量随着燃油中硫分质量分数的增加而呈下降的趋势。
- 轮机工程 /
- 柴油机 /
- 排气 /
- 燃油硫分 /
- 实验
Abstract: In order to study engine burning conditions and the harmful matters of engine exhaust gas when diesel oil has different sulfur contents, the harmful matters, such as NO_x, SO_x, CO_x, DS and SOF, were measured by chemiluminescence detector, electro chemical cell, magnetic type, galvanic cell type, filtration and weight method when the sulphur contents of fuel oil were 1%, 1.5%, 3.0% and 5.0% respectively.Test result shows that the different sulfur contents of diesel oil have obvious effect on the burning condition and exhaust gas temperature of marine engine, the fuel oil consume ratio increases with sulfur content increase, and it reaches the maximum value when sulfur content is within 3.5%, CO content increases with sulfur content increase, but CO₂ content is invariable, SOF content and NO_x content decrease with sulfur content increase, but DS content increases.
- marine engineering /
- diesel engine /
- emission /
- sulfur content /
- testing

HTML全文

图 1 实验装置

Figure 1. Experiment Equipments

下载: 全尺寸图片幻灯片

图 2 硫质量分数对燃油消耗率的影响

Figure 2. Influence of Sulphur Contenton Fuel Oil Consume Ratio

下载: 全尺寸图片幻灯片

图 3 硫质量分数对排烟温度、SO_x、CO和CO₂的影响

Figure 3. Influence of Sulphur Content on gas Temperature, SO_x, CO and CO₂ Contents

下载: 全尺寸图片幻灯片

图 4 硫质量分数对示功图的影响

Figure 4. Effect of Different Sullphur Contents on Indicator Diagram

下载: 全尺寸图片幻灯片

图 5 测量结果比较

Figure 5. Comparison of Test Results

下载: 全尺寸图片幻灯片

表 1 柴油机技术参数

Table 1. Technical Parameters of Tested Engine

项目	参数
机型	YANMAR NF19
缸径/mm	109.8
活塞行程/mm	105.4
压缩比	16.3
最大功率(2 400 r·min^-1) /kW	19
额定功率(2 400 r·min^-1) /kW	16

下载: 导出CSV

表 2 柴油特性参数

Table 2. Characteristic Parameters of Diesel Oil

项目	参数
密度/ (kg·m^-3)	0.870 2
燃点/℃	68
运动粘度/ (mm²·s^-1)	2.4
水分/%	< 0.05
灰分/%	< 0.01
硫分/%	< 0.07

下载: 导出CSV

参考文献(8)

[1]	OGASAWARAK, MURAMATSUG, MAKI NOS. De-NO_x Converter of Diesel Engine Vehicle for Practical Use[J]. JSAE Review, 1995, 16 (1): 61-76. doi: 10.1016/0389-4304(94)00062-X
[2]	OBUCHI A, KANEKOI. APractical Scale Evaluation of Catalysts for the Selective Reduction of NO_x with Organic Substances Using a Diesel Exhaust[J]. Applied Catalysis, 1998, 16 (1): 37-47.
[3]	MIYADERA T. Selective Reduction of NO_x by Ethanol on Catalysts Composed of Ag/Al₂O₃ and Cu/TiO₂ without Formation of Harmful by-Products[J]. Applied Catalysis, 1998, 16 (2): 155-164. doi: 10.1016/S0926-3373(97)00069-6
[4]	姚春德, 李云强, 王银山, 等. 用柴油/醇组合燃烧法在城市车用柴油机上实现同时降低碳烟与NOx排放的研究[J]. 环境科学学报, 2004, 24 (5): 828-833. doi: 10.3321/j.issn:0253-2468.2004.05.012 YAO Chun-de, LI Yun-qiang, WANG Yin-shan, et al. Study on the Simultaneous Reductions of PM and NO_x by Using Diesel/Alcohol Compound Combustion Mode in Diesel Engines for City Bus[J]. ACTA Scientise Circumstantiae, 2004, 24 (5): 828-833. (in Chinese) doi: 10.3321/j.issn:0253-2468.2004.05.012
[5]	姚春德, 吉庆, 李琦, 等. 汽油加生物添加剂对发动机废气排放的影响研究[J]. 环境科学学报, 2005, 25 (6): 743-748. doi: 10.3321/j.issn:0253-2468.2005.06.006 YAO Chun-de, JI Qing, LI Qi, et al. The Effects of Bio-Additives for Gasoline on Engine Emissions[J]. ACTA Scientise Circumstantiae, 2005, 25 (6): 743-748. (in Chinese) doi: 10.3321/j.issn:0253-2468.2005.06.006
[6]	彭美春, 赵锌泽, 许志刚, 等. 轻型汽车ASM排放特性[J]. 交通运输工程学报, 2005, 5 (2): 65-67. http://transport.chd.edu.cn/article/id/200502016 PENG Mei-chun, ZHAO Xin-ze, XU Zhi-gang, et al. ASM Exhaust Emission Characteristics of Light Vehicle[J]. Journal of Traffic and Transportation Engineering, 2005, 5 (2): 65-67. (in Chinese) http://transport.chd.edu.cn/article/id/200502016
[7]	冯晓, 陈思龙. 改善城市道路机动车排放污染的智能交通手段[J]. 交通运输工程学报, 2002, 2 (2): 73-77. http://transport.chd.edu.cn/article/id/200202018 FENG Xiao, CHEN Si-long. An ITS Method to Decrease Motor-Vehicle Pollutionin Urban Area[J]. Journal of Traffic and Transportation Engineering, 2002, 2 (2): 73-77. (in Chinese) http://transport.chd.edu.cn/article/id/200202018
[8]	吴义虎, 周育才, 张利军, 等. 车用汽油机污染物排放特性模糊分析方法及应用研究[J]. 中国公路学报, 2001, 14 (3): 101-105. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL200103023.htm WU Yi-hu, ZHOU Yu-cai, ZHANG Li-jun, et al. Research on Fuzzy Analysis of Exhaust Emission in Automotive Gasoline Engines and Its Application[J]. China Journal of Highway and Transport, 2001, 14 (3): 101-105. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL200103023.htm