-
摘要: 通过发动机台架试验, 针对发动机进气系统的非线性特性, 基于发动机进气通路动态模型, 给出了进气压力与系统参数之间的关系, 根据卡尔曼滤波的应用特性, 提出了基于扩展的卡尔曼滤波的发动机进气量估计算法, 得到了进气量估计的实时递推方程, 计算了发动机瞬态工况下的进气压力, 并与实际测量值进行了比较。对于较小的负荷变化率, 压力计算值与测量值偏差小于3%, 而较大的负荷变化率时, 偏差有增大趋势, 但其误差小于5%。结果表明进气量估计算法可以较精确地计算出发动机瞬态工况的进气量。Abstract: The bench test of electronic control gasoline engine was carried out, the nonlinear character of engine intake system was taken into account, the relation between manifold pressure and intake system parameters was given based on engine intake dynamic model. According to the application trait of Kalman filter, an estimate method of engine intake flowrate was put forward based on extended Kalman filter (EKF), the iterative equation was obtained by the simple linearization of nonlinear system, the intake pressures of transient operation condition were computed with different load rates. The comparison result of computation value and measure value shows that their deviation is within 3% for low load ratio, and has increasing tendency for high load ratio, but it is within 5%. The result indicates that the method can compute engine transient intake quantity exactly.
-
Key words:
- automotive engineering /
- gasoline engine /
- intake flowrate /
- optimum estimate /
- extended Kalman filter
-
[1] 张欣, 夏渊, 李国岫, 等. 车用稀燃增压单一燃料CNG发动机电控系统的研究[J]. 中国公路学报, 2003, 16(1): 113-117. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL200301027.htmZhang Xin, Xia Yuan, Li Guo-xiu, et al. Study of electric control system for lean burn turbo-charged CNG vehicle engines[J]. China Journal of Highway and Transport, 2003, 16(1): 113-117. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL200301027.htm [2] 刘军山, 帅石金, 王建昕. 电控汽油喷射发动机瞬态过程空燃比控制[J]. 车用发动机, 2002, 25(3): 22-25. https://www.cnki.com.cn/Article/CJFDTOTAL-CYFD200203007.htmLiu Jun-shan, Shuai Shi-jin, Wang Jian-xin. Transient AFR control of electronic fuel injection gasoline engine[J]. Vehicle Engine, 2002, 25(3): 22-25. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-CYFD200203007.htm [3] 李国蚰, 虞育松. 电控喷射汽油机瞬态空燃比控制策略的研究[J]. 车用发动机, 2005, 28(1): 1-4. https://www.cnki.com.cn/Article/CJFDTOTAL-CYFD200501001.htmLi Guo-xiu, Yu Yu-song. Study on the transient air-fuel ratio control strategy of electronic controlled gasoline engine[J]. Vehicle Engine, 2005, 28(1): 1-4. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-CYFD200501001.htm [4] Elbert H, Spencer C S. Mean value modeling of spark ignition engines[J]. SAE Paper, 900616. [5] Hendricks E. The analysis of mean value SI engine model[J]. SAE Paper, 920682. [6] Servati H B, Delosh R G. A regression model for volumetric efficiency[J]. SAE Paper, 860328. [7] Powell J D, Fekote N P, Chang C F. Observer-based air-fuel ratio control[J]. IEEE Control System Magazine, 1998, 18(5): 72-82. doi: 10.1109/37.722254 [8] Scherer M, Ganser T. Data fusing for optimization of spark ignition engine control[J]. SPIE, 1997, 2784: 50-60. [9] 杨兆升, 朱中. 基于卡尔曼滤波理论的交通流量实时预测模型[J]. 中国公路学报, 1999, 12(3): 63-67. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL199903008.htmYang Zhao-sheng, Zhu Zhong. A real time traffic volume prediction model based on the Kalman filtering theory[J]. China Journal of Highway and Transport, 1999, 12(3): 63-67. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL199903008.htm [10] 杨世春. 基于模型的LPG单一燃料发动机电控系统的研究[D]. 长春: 吉林大学, 2004. [11] 何兆成, 余志. 城市道路网络动态OD估计模型[J]. 交通运输工程学报, 2005, 5(2): 94-98. http://transport.chd.edu.cn/article/id/200502023He Zhao-cheng, Yu Zhi. Dynamic OD estimation model of urban network[J]. Journal of Traffic and Transportation Engineering, 2005, 5(2): 94-98. (in Chinese) http://transport.chd.edu.cn/article/id/200502023 -
下载:
点击查看大图
图(2)
计量
- 文章访问数: 303
- HTML全文浏览量: 83
- PDF下载量: 444
- 被引次数: 0
