高速列车驱动车轴动态特性分析

米彩盈; 安琪; 李芾

高速列车驱动车轴动态特性分析

西南交通大学机械工程学院, 四川成都 610031

基金项目:

国家自然科学创新研究群体基金项目 50521503

详细信息

作者简介:
米彩盈(1965-), 男, 山西山阴人, 西南交通大学教授, 工学博士, 从事机车车辆结构强度与可靠性研究

中图分类号: U260.311
计量
- 文章访问数: 194
- HTML全文浏览量: 58
- PDF下载量: 215
- 被引次数: 0
出版历程
- 收稿日期: 2006-12-10
- 刊出日期: 2007-08-25

Dynamic property analysis of axle shaft of high-speed train

School of Mechanical Engineering, Southwest Jiaotong University, Chengdu 610031, Sichuan, China

More Information

Author Bio:
Mi Cai-ying (1965-), male, Eng D, professor, +86-28-87600880, caiyingmi@163.com

摘要

摘要: 将车轮和轴箱分别简化为集中质量和转动惯量, 用连续弹性Timoshenko梁模拟变截面车轴, 建立弹性轮对与轨道耦合垂向动力学模型, 分析车轴动态刚度与轮轨作用力、车轴自身振动特性和车轴动应力的相互关系。发现: 轮对的一阶和二阶固有频率分别由76.34Hz和130.03Hz降低到53.68Hz和100.02Hz, 车轴的一阶模态振动加速度和弹性振动位移分别增加60.12%和92.21%, 轮轨动作用力增加6.23%, 车轴轮座内侧和轴颈危险截面的动应力分别增加39.30%和34.13%。分析结果表明: 轮轨动作用力和车轴的动应力随着车轴动刚度的降低而增加, 因此, 提高轻量化轮对的固有频率和动态刚度能保证高速列车安全运行和提高车轴疲劳强度。
- 高速列车 /
- 驱动车轴 /
- 动态特性 /
- Timoshenko梁
Abstract: Wheel and axle box were simplified to collective quality and inertia of moment, non-uniform axle shaft was simulated by using continuous elastic Timoshenko beam, an elastic wheelset/rail coupling vertical dynamics model was set up, and the relationships between the dynamic stiffness of axle shaft and wheel/track dynamic force, the vibratory characteristics and dynamic stress of axle shaft were analyzed. It is pointed that when the first natural frequency of wheelset reduces from 76.34 Hz to 53.68 Hz and the second natural frequency reduces from 130.03 Hz to 100.02 Hz, the first mode vibration acceleration and elastic vibration displacement of axle shaft increases by 60.12% and 92.91% respectively, wheel/track dynamic force increases by 6.23%, the dynamic stresses on the dangerous section inside wheel seat and on axle neck respectively increase by 39.30% and 34.13%. Analysis result shows that the dynamic force of wheelset and the dynamic stress of axle shaft increase with the dynamic stiffness decrease of axle shaft, so raising the dynamic stiffness of light wheelset can ensure the running safety of high-speed train and enhance the fatigue intensity of axle shaft.
- high-speed train /
- axle shaft /
- dynamic property /
- Timoshenko beam

HTML全文

图 1 轮对受力分析

Figure 1. Wheelset's load analysis

下载: 全尺寸图片幻灯片

图 2 车轴动态刚度对一阶模态振动加速度的影响

Figure 2. Influence of wheelset axle's dynamic stiffness on the first order mode vibration acceleration

下载: 全尺寸图片幻灯片

图 3 车轴动态刚度对二阶模态振动加速度的影响

Figure 3. Influence of wheelset axle's dynamic stiffness on the second order mode vibration acceleration

下载: 全尺寸图片幻灯片

图 4 车轴动态刚度对一阶弹性振动位移的影响

Figure 4. Influence of wheelset axle's dynamic stiffness on the first order elastic vibration displacement

下载: 全尺寸图片幻灯片

图 5 车轴动态刚度对二阶弹性振动位移的影响

Figure 5. Influence of wheelset axle's dynamic stiffness on the second order elastic vibration displacement

下载: 全尺寸图片幻灯片

图 6 车轴动态刚度对左侧轮轨垂向力的影响

Figure 6. Influence of wheelset axle's dynamic stiffness on vertical wheel-rail interaction force on left side

下载: 全尺寸图片幻灯片

图 7 车轴动态刚度对右侧轮轨垂向力的影响

Figure 7. Influence of wheelset axle's dynamic stiffness on vertical wheel-rail interaction force on right side

下载: 全尺寸图片幻灯片

图 8 车轴动态刚度对车轴轮座内侧截面5和轴颈截面7应力的影响

Figure 8. Influence of wheelset axle's dynamic stiffness on stresses on section No.5 inside wheel seat and axle journal section No.7

下载: 全尺寸图片幻灯片

表 1 垂向动力学系统自由度

Table 1. Degrees of freedom of vertical dynamics system

下载: 导出CSV

表 2 轮对固有频率

Table 2. Wheelset's natural frequencies Hz

下载: 导出CSV

参考文献(10)

[1]	Volf B, OndrouchJ, Hel witt P. Drehgestellt miterhörter dynamischer steifigkeit fürgrössere radsatzlasten[J]. Zeitschrif fürdas Gesamte System Bahn Glasers Annalen, 2001, 125(1): 35-40.
[2]	Volf B, Ondrouch J. Drehgestelle mit günstigen eingenschaften[J]. Zeitschrift fürdas Gesamte System Bahn Glasers Annalen, 2001, 125(9/10): 455-459.
[3]	Volf B, Ondrouch J. Die hochfrequenzbe wertung dynamischer eingenschaften von einsenbahn-rads tzen[J]. Zeitschrift fürdas Gesamte System Bahn Glasers Annalen, 1998, 122(9/10): 606-612.
[4]	翟婉明. 车辆-轨道耦合动力学[M]. 北京: 中国铁道出版社, 2003.
[5]	米彩盈, 李芾. 高速动力车车轴强度分析的工程方法[J]. 铁道学报, 2002, 24(2): 26-29. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB200202006.htm Mi Cai-ying, Li Fu. Project method of strength analysis about axles of high speed power car[J]. Journal of the China Rail way Society, 2002, 24(2): 26-29. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB200202006.htm
[6]	米彩盈. 高速动力车承载结构疲劳强度工程方法研究[D]. 成都: 西南交通大学, 2006.
[7]	Knothe K, Wu Yong-fang. Simulation des Überrollvorgangs Bei Diskret Gelagerter Schiene[M]. Düsseldorf: Verein Deutscher Ingenieure Verlag, 2000.
[8]	Wu Yong-fang. Semianalytische Gleismodelle zur Simulation der Mitte—und Hochfrequenten Fahrzeug/Fahrweg-Dynamik[M]. Düsseldorf: Verein Deutscher Ingenieure Verlag, 1997.
[9]	Garg V K, Dukkipati R V. Dynamics of Rail way Vehicle Systems[M]. Ottawa: Academic Press, 1984.
[10]	米彩盈, 安琪, 李芾. 基于传递矩阵法的轮对固有频率计算方法[J]. 交通运输工程学报, 2006, 6(4): 20-22. http://transport.chd.edu.cn/article/id/200604005 Mi Cai-ying, An Qi, Li Fu. Calculation method of wheelset natural frequency based on transfer matrixes[J]. Journal of Traffic and Transportation Engineering, 2006, 6(4): 20-22. (in Chinese) http://transport.chd.edu.cn/article/id/200604005