Fracture influence of longitudinal-continuous base layer on force characteristics of CRTSⅡ slab ballastless track on bridge
-
摘要: 考虑纵连底座板断裂建立了CRTSⅡ型板式无砟轨道与桥梁纵向相互作用的力学模型, 采用有限元法求解力学模型, 确定了无砟轨道关键参数。以某大跨度连续梁桥为例, 降温幅度分别为10、20、30、40、50℃时, 纵连底座板在连续梁上7个代表性位置发生断裂后, 分析了钢轨、轨道板、砂浆和桥梁墩台的纵向力与位移。分析结果表明: 降温幅度为30℃时, 纵连底座板在连续梁上发生断裂时, 钢轨和轨道板的最大纵向附加力分别为155.75、233.21 kN, 断板对钢轨和轨道板纵向附加力有较大影响; 降温幅度不大于10℃时, 纵连底座板在连续梁上任意位置发生断裂, 轨道板与底座板的纵向相对位移均小于0.5 mm, 砂浆不会开裂; 降温幅度为50℃时, 纵连底座板在连续梁上任意位置断裂引起的固定支座纵向附加力最大为196.12 kN, 不会直接造成桥梁固定支座破坏; 建议在维修作业时, 锯切纵连底座板与其铺设时的温度差应不大于10℃, 并检算钢轨的强度是否能满足要求。Abstract: The mechanics model of longitudinal interaction between CRTSⅡ slab ballastless track and bridge was established considering the fracture of longitudinal-continuous base layer(LCBL), and was solved by finite element method.Key calculation parameters of ballastless track were determined.A bridge with long-span continuous beam was taken as an example, the longitudinal forces and displacements of rail, slab, mortar and bridge support were analyzed when LCBLs with the temperature reductions of 10, 20, 30, 40, 50 ℃ were fractured at 7 typical positions on long-span continuous beam.Analysis result indicates that when the temperature reduction of LCBL is 30 ℃, and LCBL is fractured on long-span continuous beam, the maximal additional longitudinal forces of rail and slab are 155.75 kN and 233.21 kN respectively.The influence of LCBL fracture on the additional longitudinal forces of rail and slab are significant.When the temperature reduction of LCBL does not exceed 10 ℃, no matter LCBL is fractured at any position on long-span continuous beam, the longitudinal relative displacement between slab and LCBL is less than 0.5 mm, and mortar can't crack.When the temperature reduction of LCBL is 50 ℃, the maximal additional longitudinal force of fixed support caused by LCBL fracture at any position on long-span continuous beam is 196.12 kN, bridge fixed support can't be destroyed directly by LCBL fracture.When the maintenance operation of LCBL is carried out, it is recommended that the temperature difference between sawing and laid LCBL can't exceed 10 ℃, and rail strength must be checked out to meet the requirements.
-
表 3 钢轨纵向附加力最大值(断板股道)
Table 3. Maximal additional longitudinal forces of rail (track with fractured LCBL)
下载: 导出CSV
表 4 钢轨纵向附加力最大值(非断板股道)
Table 4. Maximal additional longitudinal forces of rail (track with non-fractured LCBL)
下载: 导出CSV
表 5 轨道板纵向附加力最大值(断板股道)
Table 5. Maximal additional longitudinal forces of slab (track with fractured LCBL)
下载: 导出CSV
表 6 轨道板纵向附加力最大值(非断板股道)
Table 6. Maximal additional longitudinal forces of slab(track with non-fractured LCBL)
下载: 导出CSV
-
[1] 方利, 王志强, 李成辉. 简支梁桥上CRTSⅡ型板式无砟轨道制动力影响因素分析[J]. 铁道学报, 2012, 34(1): 72-76. doi: 10.3969/j.issn.1001-8360.2012.01.013FANG Li. WANG Zhi-qiang, LI Cheng-hui. Analysis on influencing factors of braking force of CRTSⅡballastless track slab on simply-supported beam bridges[J]. Journal of the China Railway Society, 2012, 34(1): 72-76. (in Chinese). doi: 10.3969/j.issn.1001-8360.2012.01.013 [2] 蔡小培, 高亮, 孙汉武, 等. 桥上纵连板式无砟轨道无缝线路力学性能分析[J]. 中国铁道科学, 2011, 32(6): 28-33. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK201106006.htmCAI Xiao-pei, GAO Liang, SUN Han-wu, et al. Analysis on the mechanical properties of longitudinally connected ballastless track continuously welded rail on bridge[J]. China Railway Science, 2011, 32(6): 28-33. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK201106006.htm [3] 郑先奇. CRTSⅡ型板式无砟轨道桥上滑动层、挤塑板施工技术[J]. 铁道标准设计, 2012(8): 12-15. doi: 10.3969/j.issn.1004-2954.2012.08.004ZHENG Xian-qi. Construction technology of sliding layer and extruded sheet upon bridge of CRTS-fl slab ballastless track[J]. Railway Standard Design, 2012(8): 12-15. (in Chinese). doi: 10.3969/j.issn.1004-2954.2012.08.004 [4] 王平, 徐浩, 陈嵘, 等. 路基上CRTSⅡ型板式轨道裂纹影响分析[J]. 西南交通大学学报, 2012, 47(6): 929-934. doi: 10.3969/j.issn.0258-2724.2012.06.004WANG Ping, XU Hao, CHEN Rong, et al. Effects analysis of cracking of CRTSⅡslab track on subgrade[J]. Journal of Southwest Jiaotong University, 2012, 47(6): 929-934. (in Chinese). doi: 10.3969/j.issn.0258-2724.2012.06.004 [5] 徐浩, 谢铠泽, 陈嵘, 等. CRTSⅡ型板式轨道宽接缝开裂及修补材料对轨道板的影响分析[J]. 铁道标准设计, 2012(7): 30-32, 37. doi: 10.3969/j.issn.1004-2954.2012.07.008XU Hao, XIE Kai-ze, CHEN Rong, et al. Influence on track slab caused by crack and repairing material at wide juncture of CRTS-Ⅱslab-type track[J]. Railway Standard Design, 2012(7): 30-32, 37. (in Chinese). doi: 10.3969/j.issn.1004-2954.2012.07.008 [6] RUGE P, BIRK C. Longitudinal forces in continuously welded rails on bridge decks due to nonlinear track-bridge interaction[J]. Computers and Structures, 2007, 85(7/8): 458-475. [7] SONG M K, NOH H C, CHOI C K. A new three-dimensional finite element analysis model of high-speed train-bridge interactions[J]. Engineering Structures, 2003, 25(13): 1611-1626. doi: 10.1016/S0141-0296(03)00133-0 [8] 闫斌, 戴公连, 董林育. 客运专线斜拉桥梁轨相互作用设计参数[J]. 交通运输工程学报, 2012, 12(1): 31-37. doi: 10.3969/j.issn.1671-1637.2012.01.006YAN Bin, DAI Gong-lian, DONG Lin-yu. Design parameters of track-bridge interaction on passenger dedicated line cablestayed bridge[J]. Journal of Traffic and Transportation Engineering, 2012, 12(1): 31-37. (in Chinese). doi: 10.3969/j.issn.1671-1637.2012.01.006 [9] 郑鹏飞, 闫斌, 戴公连. 高速铁路斜拉桥上无缝线路断缝值研究[J]. 华中科技大学学报: 自然科学版, 2012, 40(9): 85-88. https://www.cnki.com.cn/Article/CJFDTOTAL-HZLG201209020.htmZHENG Peng-fei, YAN Bin, DAI Gong-lian. Rail broken gap study on continuous welded rail on cable-stayed bridge of high-speed railway[J]. Journal of Huazhong University of Science and Technology; Natural Science Edition, 2012, 40(9): 85-88. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-HZLG201209020.htm [10] 徐庆元, 王平, 届晓晖. 高速铁路桥上无缝线路断轨力计算模型[J]. 交通运输工程学报, 2006, 6(3): 23-26. doi: 10.3321/j.issn:1671-1637.2006.03.006XU Qing-yuan, WANG Ping, QU Xiao-hui. Computation model of rupture force between continuously welded rail and high-speed railway bridge[J]. Journal of Traffic and Transportation Engineering, 2006, 6(3): 23-26. (in Chinese). doi: 10.3321/j.issn:1671-1637.2006.03.006 [11] 任娟娟, 王平, 刘学毅. 客运专线桥上纵连式无砟道岔伸缩力与位移影响因素分析[J]. 铁道学报, 2011, 33(2): 79-85. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201102020.htmREN Juan-juan, WANG Ping, LIU Xue-yi. Influencing factors of temperature force and displacement of longitudinally coupled ballastless welded turnout on bridges of dedicated passenger lines[J]. Journal of the China Railway Society, 2011, 33(2): 79-85. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201102020.htm [12] 任娟娟, 王平, 李培刚, 等. 偶然荷载对桥上岔区纵连无砟轨道受力和位移的影响[J]. 中国铁道科学, 2011, 32(1): 41-47. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK201101010.htmREN Juan-juan, WANG Ping, LI Pei-gang, et al. Influence of the accidental loading on the force and displacement of longitudinal coupled slab track with seamless turnout on bridges[J]. China Railway Science, 2011, 32(1): 41-47. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK201101010.htm [13] 徐庆元, 张旭久. 高速铁路博格纵连板桥上无砟轨道纵向力学特性[J]. 中南大学学报: 自然科学版, 2009, 40(2): 526-532. https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD200902048.htmXU Qing-yuan, ZHANG Xu-jiu. Longitudinal forces characteristic of Bogl longitudinal connected ballastless track on highspeed railway bridge[J]. Journal of Central South University: Science and Technology, 2009, 40(2): 526-532. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD200902048.htm [14] 陈小平. 考虑桥梁伸缩的纵连底座板配筋计算方法[J]. 西南交通大学学报t2012, 47(5): 754-760.CHEN Xiao-ping. Calculation of longitudinal connected slab reinforcement considering expansion and contraction of bridge[J]. Journal of Southwest Jiaotong University, 2012, 47(5): 754-760. (in Chinese). [15] 陈小平. 大跨度连续梁桥上CRTSⅡ型板式无砟轨道伸缩附加力的影响因素分析[J]. 福州大学学报: 自然科学版, 2012, 40(3): 383-387. https://www.cnki.com.cn/Article/CJFDTOTAL-FZDZ201203019.htmCHEN Xiao-ping. Analysis on influencing factors of additional expansion and contraction forces between CRTSⅡ slab ballastless track and long-span continuous beam bridge[J]. Journal of Fuzhou University, Natural Science Edition, 2012, 40(3): 383-387. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-FZDZ201203019.htm [16] LIU Xiao-gang, FAN Jian-sheng, NIE Jian-guo, et al. Behavior of composite rigid frame bridge under bi-directional seismic excitations[J]. Journal of Traffic and Transportation Engineering: English Edition, 2014, 1(1): 62-71. -
点击查看大图
图(10) / 表(7)
计量
- 文章访问数: 748
- HTML全文浏览量: 118
- PDF下载量: 680
- 被引次数: 0
