钢-混凝土组合箱梁抗震性能试验

周旺保; 蒋丽忠; 李方方; 黄志

钢-混凝土组合箱梁抗震性能试验

周旺保^1,,
蒋丽忠²,
李方方³,
黄志^{2, 4}

1.
武汉理工大学道路桥梁与结构工程湖北省重点实验室, 湖北武汉 430070
2.
中南大学土木工程学院, 湖南长沙 410075
3.
中铁隧道勘测设计院有限公司, 天津 300133
4.
宾夕法尼亚州立大学土木工程学院, 宾夕法尼亚帕克 17050

基金项目:

国家自然科学基金项目 51408449

国家自然科学基金项目 51378502

道路桥梁与结构工程湖北省重点实验室开放基金项目 DQJJ201309

中央高校基本科研业务费专项资金项目 2014-IV-049

详细信息

作者简介:
周旺保(1982-), 男, 湖南岳阳人, 武汉理工大学讲师, 工学博士, 从事组合结构稳定性与抗震研究

中图分类号: U448.34
计量
- 文章访问数: 559
- HTML全文浏览量: 86
- PDF下载量: 782
- 被引次数: 0
出版历程
- 收稿日期: 2014-06-26
- 刊出日期: 2014-12-25

Experiment of seismic performance for steel-concrete composite box-beam

1.
Hubei Key Laboratory of Roadway Bridge and Structure Engineering, Wuhan University of Technology, Wuhan 430070, Hubei, China
2.
School of Civil Engineering, Central South University, Changsha 410075, Hunan, China
3.
China Railway Tunnel Survey and Design Institute Co., Ltd., Tianjin 300133, China
4.
School of Civil Engineering, The Pennsylvania State University, Park 17050, Pennsylvania, USA

More Information

Author Bio:
ZHOU Wang-bao (1982-), male, lecturer, PhD, +86-27-87651786, zhwb@whut.edu.cn

摘要

摘要: 进行了4组不同剪力连接度与腹板高厚比的组合箱梁低周反复荷载试验, 对组合箱梁的失效模式、滞回性能、骨架曲线、耗能能力、延性、刚度退化规律等抗震性能进行了深入研究, 重点分析了腹板高厚比和剪力连接度对组合箱梁抗震性能的影响。研究结果表明: 由于腹板高厚比和剪力连接度的不同, 组合箱梁存在局部屈曲破坏、弯剪破坏、压弯破坏和剪切破坏4种失效模式; 荷载-挠度滞回曲线和骨架曲线可分为弹性、弹塑性与破坏3个阶段; 不同剪力连接度与腹板高厚比情况下的荷载-挠度滞回环丰满而稳定, 没有明显的捏缩现象, 体现良好的抗震性能; 剪力连接度越大, 组合箱梁骨架曲线越饱满, 耗能能力越强, 但延性变化不明显; 腹板高厚比越大, 组合箱梁延性越好, 耗能能力越强; 剪力连接度与腹板高厚比对组合箱梁刚度退化前期有较大影响, 后期影响变小。
- 桥梁工程 /
- 钢-混凝土组合箱梁 /
- 抗震性能 /
- 剪力连接度 /
- 腹板高厚比 /
- 延性
Abstract: Four steel-concrete composite box-beams (SCCBBs) with different shear connection degrees and height-width ratios of web were experimentally studied under low-cyclic reversed loading.The seismic performances, such as failure mode, hysteretic behavior, skeleton curve, energy-dissipating capacity, ductility, and rigidity degeneration rule, were deeply studied.The influences of shear connection degree and height-width ratio of web on the seismic performance were mainly analyzed.Study result shows that according to different shear connection degrees and height-width ratios of web, there are four types of failure modes, which are local buckling failure, bending-cutting failure, compressing-bending failure, and shear failure.Load-deflection hysteretic curve and skeleton curve can be divided into three stages that are elasticity, elastoplasticity, and failure.Load-deflection hysteretic loops, with different shear connection degrees and height-width ratios of web, are plump and do not have obvious rheostriction, which shows that SCCBB has good seismic performances.Skeleton curve becomes plumper and energy-dissipating capacity becomes higher when shear connection degree increases, but the change of ductility is not obvious.Ductility becomes better and energy-dissipating capacity bocomes higher when the height-width ratio of web increases.The influences of shear connection degree and height-width ratio of web on rigidity degeneration are greater at earlier stage and less at later stage.
- bridge engineering /
- steel-concrete composite box-beam /
- seismic performance /
- shear connection degree /
- height-width ratio of web /
- ductility

HTML全文

图 1 组合箱梁截面

Figure 1. Cross section of composite box-beam

下载: 全尺寸图片幻灯片

图 2 组合箱梁纵向剖面

Figure 2. Longitudinal profile of composite box-beam MPa

下载: 全尺寸图片幻灯片

图 3 组合箱梁加载装置示意

Figure 3. Schematic of loading device for composite box-beam

下载: 全尺寸图片幻灯片

图 4 组合箱梁加载装置实物

Figure 4. Realistic loading device of composite box-beam

下载: 全尺寸图片幻灯片

图 5 低周反复加载方法

Figure 5. Method of low-cyclic reversed loading

下载: 全尺寸图片幻灯片

图 6 竖向挠度测点布置

Figure 6. Arrangement of vertical deflection measuring-points

下载: 全尺寸图片幻灯片

图 7 试件破坏模式

Figure 7. Failure modes of specimens

下载: 全尺寸图片幻灯片

图 8 跨中荷载-挠度滞回曲线

Figure 8. Load-deflection hysteretic curves at mid-spans

下载: 全尺寸图片幻灯片

图 9 跨中荷载-挠度骨架曲线

Figure 9. Load-deflection skeleton curves at mid-spans

下载: 全尺寸图片幻灯片

图 10 试件屈服点的确定方法

Figure 10. Determination method of specimen yield point

下载: 全尺寸图片幻灯片

图 11 试件耗能-挠度曲线

Figure 11. Energy dissipation-deflection curves of specimens

下载: 全尺寸图片幻灯片

图 12 试件刚度退化

Figure 12. Rigidity degenerations of specimens

下载: 全尺寸图片幻灯片

表 1 组合箱梁试件参数

Table 1. Specimen parameters of composite box-beams

下载: 导出CSV

表 2 钢材力学性能

Table 2. Mechanical properties of steels

下载: 导出CSV

表 3 试件延性

Table 3. Ductilities of specimens

下载: 导出CSV

参考文献(22)

[1]	聂建国, 余志武. 钢-混凝土组合梁在我国的研究及应用[J]. 土木工程学报, 1999, 32 (2): 3-8. doi: 10.3321/j.issn:1000-131X.1999.02.001 NIE Jian-guo, YU Zhi-wu. Research and practice of composite steel-concrete beams in China[J]. China Civil Engineering Journal, 1999, 32 (2): 3-8. (in Chinese). doi: 10.3321/j.issn:1000-131X.1999.02.001
[2]	王春生, 宋天诣, 冯亚成, 等. 高强钢-混凝土组合梁受力性能分析[J]. 交通运输工程学报, 2008, 8 (2): 27-33. doi: 10.3321/j.issn:1671-1637.2008.02.007 WANG Chun-sheng, SONG Tian-yi, FENG Ya-cheng, et al. Structural behavior analysis of high strength steel-concrete composite girders[J]. Journal of Traffic and Transportation Engineering, 2008, 8 (2): 27-33. (in Chinese). doi: 10.3321/j.issn:1671-1637.2008.02.007
[3]	LIU Xiao-gang, FAN Jian-sheng, NIE Jian-guo, et al. Behavior of composite rigid frame bridge under bi-directional seismic excitations[J]. Journal of Traffic and Transportation Engineering: English Edition, 2014, 1 (1): 62-71. doi: 10.1016/S2095-7564(15)30090-8
[4]	周勇超, 胡圣能, 宋磊, 等. 钢-混凝土组合梁的温度骤变效应分析[J]. 交通运输工程学报, 2013, 13 (1): 20-26. doi: 10.3969/j.issn.1671-1637.2013.01.004 ZHOU Yong-chao, HU Sheng-neng, SONG Lei, et al. Effect analysis of steel-concrete composite beam caused by sudden change of temperature[J]. Journal of Traffic and Transportation Engineering, 2013, 13 (1): 20-26. (in Chinese). doi: 10.3969/j.issn.1671-1637.2013.01.004
[5]	ZHOU Wang-bao, JIANG Li-zhong, LIU Zhi-jie, et al. Closed-form solution for shear lag effects of steel-concrete composite box beams considering shear deformation and slip[J]. Journal of Central South University, 2012, 19 (10): 2976-2982. doi: 10.1007/s11771-012-1366-x
[6]	ZHOU Wang-bao, JIANG Li-zhong, YU Zhi-wu. Analysis of free vibration characteristic of steel-concrete composite boxgirder considering shear lag and slip[J]. Journal of Central South University, 2013, 20 (9): 2570-2577. doi: 10.1007/s11771-013-1770-x
[7]	周旺保. 钢-混凝土组合箱梁及其框架结构的静动力性能分析[D]. 长沙: 中南大学, 2013. ZHOU Wang-bao. Static and dynamic performances of steelconcrete composite box-beam and frame structure[D]. Changsha: Central South University, 2013. (in Chinese).
[8]	周旺保, 蒋丽忠, 李书进, 等. 钢-混凝土组合框架地震响应有限元时程分析[J]. 华中科技大学学报: 自然科学版, 2014, 42 (7): 61-65. https://www.cnki.com.cn/Article/CJFDTOTAL-HZLG201407012.htm ZHOU Wang-bao, JIANG Li-zhong, LI Shu-jin, et al. Finite element time history analysis on seismic response of steel-concrete composite frame structue[J]. Journal of Huazhong University of Science and Technology: Natural Science Edition, 2014, 42 (7): 61-65. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-HZLG201407012.htm
[9]	戚菁菁, 蒋丽忠, 周旺保. 钢-混凝土组合框架结构恢复力模型研究[J]. 中南大学学报: 自然科学版, 2013, 44 (9): 3863-3872. https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD201309043.htm QI Jing-jing, JIANG Li-zhong, ZHOU Wang-bao. Restoring force model of steel-concrete composite frame structure[J]. Journal of Central South University: Science and Technology, 2013, 44 (9): 3863-3872. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD201309043.htm
[10]	聂建国, 黄远. 钢-混凝土组合梁非线性地震反应分析模型[J]. 清华大学学报: 自然科学版, 2009, 49 (3): 329-332. doi: 10.3321/j.issn:1000-0054.2009.03.005 NIE Jian-guo, HUANG Yuan. Nonlinear model for seismic analysis of steel-concrete composite beams[J]. Journal of Tsinghua University: Science and Technology, 2009, 49 (3): 329-332. (in Chinese). doi: 10.3321/j.issn:1000-0054.2009.03.005
[11]	聂建国, 余洲亮, 叶清华. 钢-混凝土叠合板组合梁抗震性能的试验研究[J]. 清华大学学报: 自然科学版, 1998, 38 (10): 35-37. doi: 10.3321/j.issn:1000-0054.1998.10.010 NIE Jian-guo, YU Zhou-liang, YE Qing-hua. Seismic behaviour of composite steel-concrete beams[J]. Journal of Tsinghua University: Science and Technology, 1998, 38 (10): 35-37. (in Chinese). doi: 10.3321/j.issn:1000-0054.1998.10.010
[12]	聂建国, 余洲亮, 袁彦声, 等. 钢-混凝土组合梁恢复力模型的研究[J]. 清华大学学报: 自然科学版, 1999, 39 (6): 121-123. https://www.cnki.com.cn/Article/CJFDTOTAL-QHXB906.033.htm NIE Jian-guo, YU Zhou-liang, YUAN Yan-sheng, et al. Research on restoring force model of composite steel-concrete beams[J]. Journal of Tsinghua University: Science and Technology, 1999, 39 (6): 121-123. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-QHXB906.033.htm
[13]	辛学忠, 蒋丽忠, 曹华. 钢-混凝土连续组合梁的恢复力模型[J]. 建筑结构学报, 2006, 27 (1): 83-89. https://www.cnki.com.cn/Article/CJFDTOTAL-JZJB200601012.htm XIN Xue-zhong, JIANG Li-zhong, CAO Hua. Research of restoring force model on steel-concrete composite continuous beams[J]. Journal of Building Structures, 2006, 27 (1): 83-89. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JZJB200601012.htm
[14]	薛伟辰, 李杰, 李昆. 预应力钢-混凝土组合梁抗震性能试验研究[J]. 哈尔滨工业大学学报, 2007, 39 (4): 656-660. doi: 10.3321/j.issn:0367-6234.2007.04.034 XUE Wei-chen, LI Jie, LI Kun. Experimental studies on seismic performance of prestressed steel-concrete composite beams[J]. Journal of Harbin Institute of Technology, 2007, 39 (4): 656-660. (in Chinese). doi: 10.3321/j.issn:0367-6234.2007.04.034
[15]	薛伟辰, 李昆, 李杰. 钢混凝土组合梁低周反复荷载试验研究[J]. 地震工程与工程振动, 2002, 22 (6): 65-70. https://www.cnki.com.cn/Article/CJFDTOTAL-DGGC200206011.htm XUE Wei-chen, LI Kun, LI Jie. Study on steel-concrete composite beams under low-reversed cyclic loading[J]. Earthquake Engineering and Engineering Vibration, 2002, 22 (6): 65-70. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-DGGC200206011.htm
[16]	AYOUB A, FILIPPOU F C. Mixed formulation of nonlinear steel-concrete composite beam element[J]. Journal of Structural Engineering, 2000, 126 (3): 371-381. doi: 10.1061/(ASCE)0733-9445(2000)126:3(371)
[17]	蒋丽忠, 余志武, 曹华, 等. 钢-混凝土简支组合梁的恢复力模型[J]. 工业建筑, 2007, 37 (11): 85-87, 96. https://www.cnki.com.cn/Article/CJFDTOTAL-GYJZ200711022.htm JIANG Li-zhong, YU Zhi-wu, CAO Hua, et al. Research on restoring force model of steel-concrete composite beams[J]. Industrial Construction, 2007, 37 (11): 85-87, 96. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GYJZ200711022.htm
[18]	蒋丽忠, 余志武, 曹华, 等. 剪力连接度对钢-混凝土组合梁抗震性能的影响[J]. 建筑结构, 2008, 38 (3): 52-54, 120. https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG200803015.htm JIANG Li-zhong, YU Zhi-wu, CAO Hua, et al. Effect of shear connection degree on seismic resistant performance of steel-concrete composite beams[J]. Building Structures, 2008, 38 (3): 52-54, 120. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG200803015.htm
[19]	蒋丽忠, 邹飞, 余志武. 低周反复荷载作用下钢-混凝土组合梁的延性[J]. 铁道科学与工程学报, 2005, 2 (5): 23-27. https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD200505004.htm JIANG Li-zhong, ZOU Fei, YU Zhi-wu. Ductility of composite steel-concrete beams under repeative and cyclic loading[J]. Journal of Railway Science and Engineering, 2005, 2 (5): 23-27. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD200505004.htm
[20]	程鹏. 组合梁截面弯矩-曲率滞回性能分析[J]. 河北工业大学学报, 2009, 38 (3): 111-113. https://www.cnki.com.cn/Article/CJFDTOTAL-HBGB200903029.htm CHENG Peng. Analysis of moment-curvature hysteresis behavior of composite beams[J]. Journal of Hebei University of Technology, 2009, 38 (3): 111-113. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-HBGB200903029.htm
[21]	王文达, 韩林海. 钢管混凝土框架实用荷载-位移恢复力模型研究[J]. 工程力学, 2008, 25 (11): 62-69. https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200811015.htm WANG Wen-da, HAN Lin-hai. Research on practical resilience model of load versus displacement for concrete filled steel tubular frame[J]. Engineering Mechanics, 2008, 25 (11): 62-69. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200811015.htm
[22]	王文达, 韩林海, 游经团. 方钢管混凝土柱-钢梁外加强环节点滞回性能的实验研究[J]. 土木工程学报, 2006, 39 (9): 17-25. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC200609002.htm WANG Wen-da, HAN Lin-hai, YOU Jing-tuan. Experimental studies on hysteretic behaviors of steel beam to concrete filled SHS column connections with stiffening ring[J]. China Civil Engineering Journal, 2006, 39 (9): 17-25. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC200609002.htm