-
摘要: 为了研究弯道行驶中制动工况对半挂汽车列车稳定性的影响, 运用动力学理论与虚拟样机仿真软件ADAMS, 建立了具有21自由度的半挂汽车列车整车模型, 分析了在弯道行驶极限工况下, 半挂汽车列车折叠角、侧向加速度、横摆角速度、车速、轮速、轮胎侧偏角随时间的变化关系。通过整车系统的稳态转向试验与阶跃试验, 验证了模型具有较好的仿真精度。仿真结果表明: 转向后3 s实施制动, 在3 s的时间内, 牵引车侧向加速度变为0, 横摆角速度达到极值33 rad·s-1后迅速减小, 而半挂车侧向加速度达到极值4 m·s-2, 横摆角速度逐渐减小为0;在制动过程中, 牵引车后轴先抱死拖滑, 由此引起半挂汽车列车发生折叠现象, 从而导致弯道行驶制动稳定性降低。Abstract: In order to study the effect of braking condition on the stability of tractor-semitrailer running on curve, a whole vehicle model of tractor-semitrailer with 21 degrees of freedom was established by using dynamics theory and virtual prototype simulation software ADAMS. The change relations of folding angle, lateral acceleration, yaw angle velocity, vehicle speed, wheel speed and tire side-slip angle with time were analyzed when tractor-semitrailer ran on curve under the ultimate condition. Through the whole vehicle test of stable steering and step, the simulation accuracy of the model was verified. Simulation result shows that when tractor-semitrailer brakes after 3 s of turning, in 3 s, tractor's lateral acceleration becomes 0, yaw angle velocity reaches extreme value 33 rad·s-1, then decreases rapidly.While trailer's lateral acceleration reaches extreme value 4 m·s-2, and yaw angle velocity gradually decreases to 0. In the braking process on curve, tractor's rear axle first locks and slips, thus the folding phenomenon of tractor-semitrailer probably happens, which leads to the reduction of braking stability.
-
Key words:
- automobile engineering /
- tractor-semitrailer /
- running on curve /
- braking stability /
- virtual simulation
-
图 1 半挂汽车列车单轨双质心模型
Figure 1. Model of single lane and double centroids of tractor-semitrailer
图 3 侧偏角差值与横向加速度的关系
Figure 3. Relationship of slip angle difference and lateral acceleration
表 1 半挂汽车列车结构尺寸参数
Table 1. Structural representation parameters of tractor-semitrailer
名称 符号 数值 空载 满载 牵引车前轴与质心距离/m a1 1.96 1.96 牵引车后轴与质心距离/m b1 2.35 2.35 牵引点与牵引车质心距离/m c 2.05 2.05 牵引车质心高度/m h 0.90 0.85 半挂车质心高度/m h′ 0.97 2.10 牵引点与半挂车质心距离/m a2 5.23 5.92 半挂车后轴与质心距离/m b2 3.30 2.61 牵引车前轴轮距/m d1 2.14 2.14 牵引车后轴轮距/m d2 1.82 1.82 半挂车后轴轮距/m d3 2.16 2.16 
下载: 导出CSV
-
[1] 夏长高. 汽车高速行驶操纵性柔性多体动力学预测方法[J]. 交通运输工程学报, 2004, 4(4): 30-33. http://transport.chd.edu.cn/article/id/200404008XI A Chang-gao. Flexible multibody systemdynamics predicting method of high-speed vehicle handling[J]. Journal of Traffic and Transportation Engineering, 2004, 4(4): 30-33. (in Chinese) http://transport.chd.edu.cn/article/id/200404008 [2] 刘喜东, 马建, 郭荣庆. 制动工况下汽车转向系统敏感度分析方法[J]. 交通运输工程学报, 2008, 8(3): 20-23. http://transport.chd.edu.cn/article/id/200803005LIU Xi-dong, MA Jian, GUO Rong-qing. Sensitivity analysis method of vehicle steering system under braking condition[J]. Journal of Traffic and Transportation Engineering, 2008, 8(3): 20-23. (in Chinese) http://transport.chd.edu.cn/article/id/200803005 [3] SUH M W, PARK Y K, KWON S J, et al. A simulation program for the braking characteristics of tractor-semitrailer vehicle[J]. SAE Paper, 2000-01-3415: 1-11. [4] 吕安涛, 林玮静. 半挂汽车列车安全性设计的技术发展趋势[J]. 专用汽车, 2003(2): 9-11. https://www.cnki.com.cn/Article/CJFDTOTAL-ZYQC200302002.htmLU An-tao, LI N Wei-jing. Technique development trend of semi-trailer train safety design[J]. Special Purpose Vehicle, 2003(2): 9-11. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZYQC200302002.htm [5] 冯向敏. 半挂汽车列车的主动侧倾控制[D]. 长春: 吉林大学, 2005.FENG Xiang-min. Active roll control of tractor semi-trailer[D]. Changchun: Jilin University, 2005. (in Chinese) [6] 刘宏飞, 许洪国, 关志伟, 等. 半挂汽车列车直线行驶横向摆振研究[J]. 汽车技术, 2005(1): 11-14. https://www.cnki.com.cn/Article/CJFDTOTAL-QCJS200501003.htmLI U Hong-fei, XU Hong-guo, GUAN Zhi-wei, et al. Study on shimmy of a semi-trailer combination vehicle driving on straight line[J]. Automobile Technology, 2005(1): 11-14. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-QCJS200501003.htm [7] 郑仲浪, 吕彭民. 基于舒适性及道路友好性的拖挂车辆悬架参数优化方法[J]. 交通运输工程学报, 2009, 9(5): 49-53. http://transport.chd.edu.cn/article/id/200905009ZHENG Zhong-lang, LU Peng-min. Optimization method of suspension parameters for articulated vehicle based on ride comfort and road-friendliness[J]. Journal of Traffic and Transportation Engineering, 2009, 9(5): 49-53. (in Chinese) http://transport.chd.edu.cn/article/id/200905009 [8] 王国林, 韦超毅, 陆永华, 等. 半挂汽车列车模型的建立与试验[J]. 农业机械学报, 2005, 36(11): 17-19, 37. https://www.cnki.com.cn/Article/CJFDTOTAL-NYJX200511005.htmWANG Guo-lin, WEI Chao-yi, LU Yong-hua, et al. Modeling and experiments of tractor trailer[J]. Transactions of the Chinese Society for Agricultural Machinery, 2005, 36(11): 17-19, 37. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-NYJX200511005.htm [9] 关志伟, 许洪国, 李春明, 等. 应用虚拟样机技术进行半挂汽车列车制动动力学分析[J]. 汽车技术, 2005(10): 17-19. https://www.cnki.com.cn/Article/CJFDTOTAL-QCJS200510005.htmGUAN Zhi-wei, XU Hong-guo, LI Chun-ming, et al. Analysis of brake dynamics of tractor-semitrailer combinations with virtual prototype technology[J]. Automobile Technology, 2005(10): 17-19. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-QCJS200510005.htm [10] 刘宏飞. 半挂汽车列车横摆动力学仿真及控制策略研究[D]. 长春: 吉林大学, 2005.LI U Hong-fei. Study on si mulation and control strategy for yaw motion dynamics of tractor-semitrailer[D]. Changchun: Jilin University, 2005. (in Chinese) [11] 王东杰. 半挂汽车列车弯道行驶横向稳定性分析[D]. 青岛: 青岛理工大学, 2008.WANG Dong-jie. Analysis on the lateral stability of tractor-semitrailer running on a curve[D]. Qingdao: Qingdao Technological University, 2008. (in Chinese) -
点击查看大图
图(14) / 表(1)
计量
- 文章访问数: 760
- HTML全文浏览量: 177
- PDF下载量: 652
- 被引次数: 0
