-
摘要: 采用触发采集方式现场实测了某下沉式地铁车辆段咽喉区钢轨、道床、地面、楼板及盖板的振动加速度, 采用插入损失、1/3倍频谱、Z振级曲线拟合等方法分析了现场实测数据, 进而分析了下沉式地铁车辆段咽喉区的振源特性与地铁振动沿盖板和不同层楼板的传播规律。分析结果表明: 在频域上, 钢轨比道床振动频带更宽, 没有明显的主频段, 其振动分布在800 Hz以内, 道床则有明显的主频段, 主要分布在80~200 Hz; 下沉式地铁车辆段地下1、2层钢轨至道床振动衰减幅度分别约为29.9、10.4 dB; 列车引起盖板的振动响应随测点与行车轨道中心线距离的增大呈线性衰减规律, 其线性衰减率约为0.2 dB·m-1; 由于边墙对振动的反射与折射, 振动传至盖板端部时出现局部放大现象; 列车无论在地铁车辆段端部还是在中间股道行车, 随着测点与行车轨道中心线距离的增大, 车辆段盖板振级在2.5、5.0 Hz低频处基本不变, 在10 Hz处衰减缓慢, 在25、40、80 Hz中高频处衰减明显; 列车在地下1、2层行车时诱发的振动的向上传播呈逐层衰减规律, 列车在地下1层行车引起的盖板振动比其在地下2层行车时大约16.1 dB; 下沉式地铁车辆段咽喉区轨道接头多、道岔多的特点导致该区域盖板车致振动响应突出, 需重点对该区域进行减振设计。Abstract: The vibration accelerations of rail, ballast bed, ground, floor and cover plate in the throat area of a sinking metro depot were measured on site by the trigger acquisition method. The field measured data were analyzed by the methods of insertion loss, one-third octave band spectrum and curve fitting of Z direction vibration level. Furthermore, the vibration source characteristics in the throat area of sinking metro depot and the transmission law of vibration along the cover plate and different floors were analyzed. Analysis result shows that in the frequency domain, the frequency band of rail vibration is wider than that of ballast bed, and there is no obvious main frequency band. The vibration distribution of rail is within 800 Hz. While the ballast bed has an obvious main frequency band within 80-200 Hz. The vibration attenuations from the rail to the ballast bed at the first and second floors underground are about 29.9 and 10.4 dB, respectively. The train-induced vibration response of cover plate decreases linearly with the increase of distance between the measuring point and the center line of running track, and the linear attenuation rate is about 0.2 dB·m-1. Due to the reflection and refraction of the side wall to the vibration, the local amplification phenomenon occurs when the vibration is transmitted to the end of cover plate. No matter the train is running at the end of metro depot or in the middle track, with the increase of distance between the measuring point and the center line of running track, the vibration level of cover plate is basically the same at the low frequencies of 2.5 and 5.0 Hz, decreases slowly at 10 Hz, and decreases obviously at the middle and high frequencies of 25, 40 and 80 Hz. The upward propagation of train-induced vibration shows a floor-by-floor attenuation law. The vibration of cover plate caused by the train operation at the first floor underground is about 16.1 dB greater than that at the second floor underground. The characteristics of many rail joints and turnouts in the throat area of sinking metro depot lead to the prominent vibration response of cover plate in this area. It is necessary to focus on the vibration reduction design of this area.
-
表 1 地铁车辆段测试区域基本信息
Table 1. Basic information of test area in metro depot
测试区域 咽喉区 车辆类型 A型 每节车长/m 23 车宽/m 3.1 轴质量/t 16 编组/节 6 轨道类型 整体道床 钢轨类型 阻尼钢轨 扣件类型 CZI 轨枕类型 短轨枕 地下1层列车运行速度/(km·h-1) 14.4 地下2层列车运行速度/(km·h-1) 20.2 表 2 钢轨与道床振动响应
Table 2. Vibration responses of rail and ballast bed
位置 分析指标 钢轨 道床 地下1层 加速度峰值平均值/(m·s-2) 12.78 0.51 Z振级平均值/dB 95.89 85.48 主频段/Hz 50~800 80~200 地下2层 加速度峰值平均值/(m·s-2) 17.67 0.26 Z振级平均值/dB 104.06 74.15 主频段/Hz 50~800 80~200 表 3 列车引起咽喉区各层测点Z振级
Table 3. Z direction vibration levels of measuring points in throat area induced by train dB
工况 指标 地下2层 地下1层 盖板 地下2层行车 Z振级 71.1 67.6 61.3 Z振级衰减 3.5 6.3 地下1层行车 Z振级 88.5 77.4 Z振级衰减 11.1 -
[1] METRIKINE A V, VROUWENVELDER A C W M. Surface ground vibration due to a moving train in a tunnel: two-dimensional model[J]. Journal of Sound and Vibration, 2000, 234(1): 43-66. doi: 10.1006/jsvi.1999.2853 [2] GUPTA S, LIU W F, DEGRANDE G, et al. Prediction of vibrations induced by underground railway traffic in Beijing[J]. Journal of Sound and Vibration, 2008, 310(1): 608-630. [3] PERSSON P, PERSSON K, SANDBERG G. Numerical study on reducing building vibrations by foundation improvement[J]. Engineering Structures, 2016, 124: 361-375. doi: 10.1016/j.engstruct.2016.06.020 [4] VOGIATZIS K, MOUZAKIS H. Ground-borne noise and vibration transmitted from subway networks to multi-storey reinforced concrete buildings[J]. Transport, 2018, 33(2): 446-453. [5] LÓPEZ-MENDOZAA D, ROMERO A, CONNOLLY D P, et al. Scoping assessment of building vibration induced by railway traffic[J]. Soil Dynamics and Earthquake Engineering, 2017, 93: 147-161. doi: 10.1016/j.soildyn.2016.12.008 [6] LOPES P, ALVES COSTA P, CALCADA R, et al. Influence of soil stiffness on building vibrations due to railway traffic in tunnels: numerical study[J]. Computers and Geotechnics, 2014, 61: 277-291. doi: 10.1016/j.compgeo.2014.06.005 [7] HUSSEIN M, HUNT H, KUO K, et al. The use of sub-modelling technique to calculate vibration in buildings from underground railways[J]. Proceedings of the Institution of Mechanical Engineers, Part F: Journal of Rail and Rapid Transit, 2015, 229(3): 303-314. doi: 10.1177/0954409713511449 [8] SANAYEI M, MAURYA P, MOORE J A. Experiment of building foundation and ground-borne vibrations due to surface trains and subways[J]. Engineering Structures, 2013, 53: 102-111. doi: 10.1016/j.engstruct.2013.03.038 [9] SANAYEI M, KAYIPARAMBILA P, MOORE J A, et al. Measurement and prediction of train-induced vibrations in a full-scale building[J]. Engineering Structures, 2014, 77: 119-128. doi: 10.1016/j.engstruct.2014.07.033 [10] KOUROUSSIS G, VERLINDEN O, CONTI C. Free field vibrations caused by high-speed lines: measurement and time domain simulation[J]. Soil Dynamics and Earthquake Engineering, 2011, 31: 692-707. doi: 10.1016/j.soildyn.2010.11.012 [11] KOUROUSSIS G, VERLINDEN O, CONTI C. Efficiency of resilient wheels on the alleviation of railway ground vibrations[J]. Proceedings of the Institution of Mechanical Engineers, Part F: Journal of Rail and Rapid Transit, 2011, 226(4): 381-396. [12] 刘维宁, 马蒙, 刘卫丰, 等. 我国城市轨道交通环境振动影响的研究现况[J]. 中国科学: 技术科学, 2016, 46(6): 547-559. https://www.cnki.com.cn/Article/CJFDTOTAL-JEXK201606001.htmLIU Wei-ning, MA Meng, LIU Wei-feng, et al. Overview on current research of environmental vibration influence induced by urban mass transit in China[J]. Scientia Sinica (Technologica), 2016, 46(6): 547-559. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JEXK201606001.htm [13] 夏禾, 张楠, 曹艳梅. 列车对周围地面及建筑物振动影响的试验研究[J]. 铁道学报, 2004, 26(4): 93-98. doi: 10.3321/j.issn:1001-8360.2004.04.020XIA He, ZHANG Nan, CAO Yan-mei. Experimental study of train-induced vibrations of ground and nearby buildings[J]. Journal of the China Railway Society, 2004, 26(4): 93-98. (in Chinese). doi: 10.3321/j.issn:1001-8360.2004.04.020 [14] 孙晓静, 袁扬, 马蒙, 等. 地铁列车运行引起远场低频振动响应预测研究[J]. 振动与冲击, 2017, 36(4): 198-202. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201704031.htmSUN Xiao-jing, YUAN Yang, MA Meng, et al. Prediction of metro train-induced low frequency vibration responses in far field[J]. Journal of Vibration and Shock, 2017, 36(4): 198-202. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201704031.htm [15] 侯博文. 地铁-房建合建体系耦合动力学及振动控制技术研究[D]. 北京: 北京交通大学, 2016.HOU Bo-wen. Research on subway-building combined structure system coupling dynamics and vibration control[D]. Beijing: Beijing Jiaotong University, 2016. (in Chinese). [16] 洪俊青, 刘伟庆. 地铁对周边建筑物振动影响分析[J]. 振动与冲击, 2006, 25(4): 142-145. doi: 10.3969/j.issn.1000-3835.2006.04.038HONG Jun-qing, LIU Wei-qing. Analysis of effects induced by subway train on surrounding building vibration[J]. Journal of Vibration and Shock, 2006, 25(4): 142-145. (in Chinese). doi: 10.3969/j.issn.1000-3835.2006.04.038 [17] 王毅, 徐辉. 地铁车辆段平台居住小区振动与噪声污染控制[J]. 中国环境监测, 1999, 15(6): 43-45. https://www.cnki.com.cn/Article/CJFDTOTAL-IAOB199906015.htmWANG Yi, XU Hui. A brief talk on the pollution controlling of vibration and noise of the community built on the platform of subway traffic[J]. Environmental Monitoring in China, 1999, 15(6): 43-45. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-IAOB199906015.htm [18] ZOU Chao, WANG Yi-min, WANG Peng, et al. Measurement of ground and nearby building vibration and noise induced by trains in a metro depot[J]. Science of the Total Environment, 2015, 536: 761-773. doi: 10.1016/j.scitotenv.2015.07.123 [19] ZOU Chao, WANG Yi-min, MOORE J A, et al. Train-induced field vibration measurement of ground and over-track buildings[J]. Science of the Total Environment, 2017, 575: 1339-1351. doi: 10.1016/j.scitotenv.2016.09.216 [20] ZOU Chao, MOORE J A, SANAYEI M, et al. Impedance model for estimating train-induced building vibrations[J]. Engineering Structures, 2018, 172: 739-750. doi: 10.1016/j.engstruct.2018.06.032 [21] TAO Zi-yu, WANG Yi-min, SANAYEI M, et al. Experimental study of train-induced vibration in over-track buildings in a metro depot[J]. Engineering Structures, 2019, 198: 109473. doi: 10.1016/j.engstruct.2019.109473 [22] TAO Zi-yu, WANG Yi-min, ZOU Chao, et al. Assessment of ventilation noise impact from metro depot with over-track platform structure on workers and nearby inhabitants[J]. Environmental Science and Pollution Research, 2019, 26: 9203-9218. doi: 10.1007/s11356-019-04378-w [23] 汪益敏, 曾泽民, 邹超, 等. 地铁车辆段试车线列车振动影响的试验研究[J]. 华南理工大学学报(自然科学版), 2014, 42(12): 1-8. https://www.cnki.com.cn/Article/CJFDTOTAL-HNLG201412002.htmWANG Yi-min, ZENG Ze-min, ZOU Chao, et al. Experimental investigation into train-induced vibrations of test-line at metro depot[J]. Journal of South China University of Technology (Natural Science Edition), 2014, 42(12): 1-8. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-HNLG201412002.htm [24] 邹超, 汪益敏, 汪朝晖, 等. 地铁车辆段咽喉区地面振动传播规律实测与分析[J]. 振动与冲击, 2015, 34(16): 200-206. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201516034.htmZOU Chao, WANG Yi-min, WANG Zhao-hui, et al. Field measurement and analysis of ground vibration in the throat area of metro depot[J]. Journal of Vibration and Shock, 2015, 34(16): 200-206. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201516034.htm [25] 李绿宇, 国巍, 蒋丽忠, 等. 沈阳地铁车辆段上盖双子楼隔振性能的振动台试验研究[J]. 振动与冲击, 2017, 36(6): 56-62, 74. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201706009.htmLI Lyu-yu, GUO Wei, JIANG Li-zhong, et al. Shaking table tests on the isolation performance of two buildings built on the top head of Shenyang metro depot[J]. Journal of Vibration and Shock, 2017, 36(6): 56-62, 74. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201706009.htm [26] 谢伟平, 赵娜, 何卫, 等. 地铁上盖物业振动舒适度分析[J]. 土木工程学报, 2013, 46(6): 90-96. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201306017.htmXIE Wei-ping, ZHAO Na, HE Wei, et al. Analysis on vibration serviceability of over-track buildings[J]. China Civil Engineering Journal, 2013, 46(6): 90-96. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201306017.htm [27] 何卫, 谢伟平. 地铁车辆段列车动荷载特性实测研究[J]. 振动与冲击, 2016, 35(8): 132-137. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201608020.htmHE Wei, XIE Wei-ping. Field measurement of the subway train loading in a car depot[J]. Journal of Vibration and Shock, 2016, 35(8): 132-137. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201608020.htm [28] 谢伟平, 陈艳明, 姚春桥. 地铁车辆段上盖物业车致振动分析[J]. 振动与冲击, 2016, 35(8): 110-115. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201608017.htmXIE Wei-ping, CHEN Yan-ming, YAO Chun-qiao. Vibration analysis of train depot over-track buildings induced by train load[J]. Journal of Vibration and Shock, 2016, 35(8): 110-115. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201608017.htm [29] 冯青松, 王子玉, 刘全民, 等. 双振源激励下地铁车辆段上盖建筑物振动特性[J]. 交通运输工程学报, 2019, 19(4): 59-69. http://transport.chd.edu.cn/article/id/201904006FENG Qing-song, WANG Zi-yu, LIU Quan-min, et al. Vibration characteristics of metro depot upper building under double vibration source excitation[J]. Journal of Traffic and Transportation Engineering, 2019, 19(4): 59-69. (in Chinese). http://transport.chd.edu.cn/article/id/201904006 [30] 邬玉斌, 张斌, 刘应华, 等. 地铁车辆段库上建筑环境振动影响规律研究[J]. 铁道学报, 2015, 37(8): 98-103. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201508020.htmWU Yu-bin, ZHANG Bin, LIU Ying-hua, et al. Law of vibrations influence of subway on metro depot superstructure[J]. Journal of the China Railway Society, 2015, 37(8): 98-103. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201508020.htm [31] 何蕾, 宋瑞祥, 邬玉斌, 等. 车速对车辆段上盖物业振动影响的实测分析[J]. 建筑结构, 2015, 45(19): 96-99. https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG201519025.htmHE Lei, SONG Rui-xiang, WU Yu-bin, et al. Analysis on actual measurement of train speed influence on the vibration of over-track building of metro-depot[J]. Building Structure, 2015, 45(19): 96-99. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG201519025.htm [32] 金浩, 刘维宁. 枕下减振垫铺设方式对梯式轨道减振性能影响试验研究[J]. 土木工程学报, 2015, 48(2): 73-78. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201502012.htmJIN Hao, LIU Wei-ning. Experimental study on vibration reduction characteristics of ladder track with different arrangement of sleeper pads[J]. China Civil Engineering Journal, 2015, 48(2): 73-78. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201502012.htm