-
摘要: 以中国某型高速列车为研究对象, 针对高速列车运行时主要噪声来源之一的转向架区噪声开展试验研究, 掌握其噪声特性和规律, 研究了不同类型和位置的转向架区噪声特性, 预测了不同速度下转向架区噪声水平和频谱特性; 基于一定的假设, 采用测试数据类比法对车头转向架区噪声成分进行分离。研究结果表明: 列车在200~350 km·h-1速度范围内运行时, 车辆主要噪声源集中在转向架区; 转向架区噪声表现为车头转向架区噪声大于车尾转向架噪声, 200 km·h-1运行时车头转向架区噪声大于车尾转向架区噪声约3 dB(A), 主要原因为在车头转向架处气流冲击导致的气动噪声大于车尾转向架处涡流导致的气动噪声; 中间动车转向架区噪声大于中间拖车转向架区噪声, 200 km·h-1运行时中间动车转向架区噪声大于中间拖车转向架区噪声约5 dB(A), 主要原因为相比于中间拖车转向架区噪声, 中间动车转向架区增加了牵引系统噪声; 随着运行速度的提高, 转向架区噪声在全频段内显著提高, 噪声峰值频率也会增大, 主要原因为车轮滚动噪声所致, 速度越大, 其轨枕冲击频率越高; 中间拖车转向架区噪声随速度增长的3次方关系符合轮轨噪声随速度的增长趋势, 对于车头转向架区噪声来说, 气动噪声成分更加显著, 并且随着运行速度的提高, 气动噪声所占比重呈增加的趋势。Abstract: Taking a certain type of high-speed train in China as a research object, the bogie area noise that is one of the major noise sources of high-speed train in operating mode was tested, the noise characteristics and laws of different bogie types and different bogie positions were studied, and the noise values and spectrum characteristics at different speed levels were predicted. Based on certain assumptions, the noise components in the head-car bogie area were separated by using the test data analogy method. Research result shows that the main sources of vehicle noise are concentrated in the bogie area in the speed range of 200-350 km·h-1. The bogie area noise of the head-car is larger than that of the tail-car, and the amplification is approximately 3 dB(A) at the speed of 200 km·h-1. The main reason is that the aerodynamics noise caused by the airflow impact at the head-car bogie is greater than that caused by the eddy flow at the tail-car bogie. The bogie area noise of intermediate motor car is larger than that of the intermediate trailer car, and the amplification is approximately 5 dB(A) at the speed of 200 km·h-1. The main reason is that the traction system noise is generated in the motor bogie compared with the noise of trailer bogie. With the operating speed increasing, the noise in the bogie area significantly increases in the whole frequency band, and the noise-peak frequency also increases, which is mainly due to the wheel rolling noise. When the operating speed becomes higher, the sleeper impact frequency will be higher accordingly. The third-order relationship of noise increasement versus speed increasement in the bogie area of the intermediate trailer conforms with the growth trend of wheel-rail noise increasement versus speed increasement. In terms of the noise in head-car bogie area, the aerodynamics noise is more significant, and its proportion increases with the increase of operating speed.
-
图 3 200 km·h-1时车外噪声源识别结果
Figure 3. Identification result of exterior sound source at speed of 200 km·h-1
图 4 350 km·h-1时车外噪声源识别结果
Figure 4. Identification result of exterior sound source at speed of 350 km·h-1
图 5 转向架区噪声特性(车头和车尾)
Figure 5. Bogie area noise characteristics (head car and tail car)
图 6 转向架区噪声特性(动车和拖车)
Figure 6. Bogie area noise characteristics (motor car and trail car)
图 7 不同速度下不同转向架区噪声频谱特性
Figure 7. Noise spectrum characteristics in different bogie areas at different speeds
图 10 中间车-拖车转向架区噪声频谱
Figure 10. Noise spectrum in trailer bogie area of intermediate car
-
[1] REMINGTON P J, WITTIG L E. Prediction of the effectiveness of noise control treatments in urban rail elevated structures[J]. The Journal of the Acoustical Society of America, 1985, 78(6): 2017-2033. doi: 10.1121/1.392659 [2] REMINGTON P J. Wheel/rail rolling noise, I: theoretical analysis[J]. The Journal of the Acoustical Society of America, 1987, 81(6): 1805-1823. doi: 10.1121/1.394746 [3] THOMPSON D J, JONES C J C. A review of the modelling of wheel/rail noise generation[J]. Journal of Sound and Vibration, 2000, 231(3): 519-536. doi: 10.1006/jsvi.1999.2542 [4] MORITOH Y, ZENDA Y, NAGAKURA K. Noise control of high speed Shinkansen[J]. Journal of Sound and Vibration, 1996, 193(1): 319-334. doi: 10.1006/jsvi.1996.0273 [5] 王德威, 李帅, 张捷, 等. 高速列车车外噪声预测建模与声源贡献量分析[J]. 中南大学学报(自然科学版), 2018, 49(12): 3113-3120. doi: 10.11817/j.issn.1672-7207.2018.12.026WANG De-wei, LI Shuai, ZHANG Jie, et al. Prediction of external noise of high-speed train and analysis of noise source contribution[J]. Journal of Central South University (Science and Technology), 2018, 49(12): 3113-3120. (in Chinese). doi: 10.11817/j.issn.1672-7207.2018.12.026 [6] 朱剑月, 王毅刚, 杨志刚, 等. 高速列车转向架区域裙板对流场与气动噪声的影响[J]. 同济大学学报(自然科学版), 2017, 45(10): 1512-1521. doi: 10.11908/j.issn.0253-374x.2017.10.014ZHU Jian-yue, WANG Yi-gang, YANG Zhi-gang, et al. Effect of bogie fairing on flow and aerodynamic noise behavior around bogie of high-speed train[J]. Journal of Tongji University (Natural Science), 2017, 45(10): 1512-1521. (in Chinese). doi: 10.11908/j.issn.0253-374x.2017.10.014 [7] 朱剑月, 任利惠, 雷震宇. 高速列车转向架舱对转向架区域流场与气动噪声影响[J]. 同济大学学报(自然科学版), 2018, 46(11): 1556-1561. doi: 10.11908/j.issn.0253-374x.2018.11.013ZHU Jian-yue, REN Li-hui, LEI Zhen-yu. Effect of bogie cavity on flow and flow-induced noise behavior around high-speed train bogie region[J]. Journal of Tongji University (Natural Science), 2018, 46(11): 1556-1561. (in Chinese). doi: 10.11908/j.issn.0253-374x.2018.11.013 [8] 张亚东, 张继业, 李田. 高速列车气动噪声贡献量分析[J]. 交通运输工程学报, 2017, 17(4): 78-86. doi: 10.3969/j.issn.1671-1637.2017.04.008ZHANG Ya-dong, ZHANG Ji-ye, LI Tian. Contribution analysis of aerodynamic noise of high-speed train[J]. Journal of Traffic and Transportation Engineering, 2017, 17(4): 78-86. (in Chinese). doi: 10.3969/j.issn.1671-1637.2017.04.008 [9] 张亚东, 张继业, 张亮, 等. 高速列车动车转向架气动噪声数值分析[J]. 西南交通大学学报, 2016, 29(5): 870-877. doi: 10.3969/j.issn.0258-2724.2016.05.008ZHANG Ya-dong, ZHANG Ji-ye, ZHANG Liang, et al. Numerical analysis of aerodynamic noise of motor car bogie for high-speed ttrains[J]. Journal of Southwest Jiaotong University, 2016, 29(5): 870-877. (in Chinese). doi: 10.3969/j.issn.0258-2724.2016.05.008 [10] 李辉, 肖新标, 金学松. 基于神经网络方法的高速列车车外气动噪声预测[J]. 噪声与振动控制, 2015, 35(3): 56-59, 116. https://www.cnki.com.cn/Article/CJFDTOTAL-ZSZK201503014.htmLI Hui, XIAO Xin-biao, JIN Xue-song. Research on exterior aerodynamic noise prediction of high-speed trains based on neural network[J]. Noise and Vibration Control, 2015, 35(3): 56-59, 116. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZSZK201503014.htm [11] 李辉, 肖新标, 李志辉, 等. 某型受电弓300 km·h-1速度下气动噪声初步分析[J]. 铁道学报, 2016, 38(9): 18-22. doi: 10.3969/j.issn.1001-8360.2016.09.003LI Hui, XIAO Xin-biao, LI Zhi-hui, et al. Preliminary investigation into aerodynamic noise of a certain type of pantograph under speed of 300 km·h-1[J]. Journal of the China Railway Society, 2016, 38(9): 18-22. (in Chinese). doi: 10.3969/j.issn.1001-8360.2016.09.003 [12] 姚永芳, 孙振旭, 刘文, 等. 高速列车受电弓气动噪声特性分析[J]. 北京大学学报(自然科学版), 2020, 56(3): 385-398. https://www.cnki.com.cn/Article/CJFDTOTAL-BJDZ202003001.htmYAO Yong-fang, SUN Zhen-xu, LIU Wen, et al. Analysis of aerodynamic noise characteristics of pantograph in high speed train[J]. Acta Scientiarum Naturalium Universitatis Pekinensis, 2020, 56(3): 385-398. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-BJDZ202003001.htm [13] 左曙光, 魏欢, 严新富, 等. 基于声辐射控制的板结构优化设计[J]. 同济大学学报(自然科学版), 2012, 40(1): 88-96. doi: 10.3969/j.issn.0253-374x.2012.01.016ZUO Shu-guang, WEI Huan, YAN Xin-fu, et al. Radiation noise reduction of a plate-like structure by structural optimization[J]. Journal of Tongji University (Natural Science), 2012, 40(1): 88-96. (in Chinese). doi: 10.3969/j.issn.0253-374x.2012.01.016 [14] 宋雷鸣, 孙守光, 张新华. 用有限元法分析铁路客车车内空间的声学特性[J]. 噪声与振动控制, 2005, 2(4): 21-22. https://www.cnki.com.cn/Article/CJFDTOTAL-ZSZK200502006.htmSONG Lei-ming, SUN Shou-guang, ZHANG Xin-hua. Analysis of acoustic property of space inside rail car based FEM[J]. Noise and Vibration Control, 2005, 2(4): 21-22. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZSZK200502006.htm [15] 陈书明, 王登峰, 曹晓琳, 等. 车内噪声FE-SEA混合建模及分析方法[J]. 机械工程学报, 2010, 23(2): 140-144. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDGC201002003.htmCHEN Shu-ming, WANG Deng-feng, CAO Xiao-lin, et al. Hybrid FE-SEA modeling and analysis method of car interior noise[J]. Journal of Mechanical Engineering, 2010, 23(2): 140-144. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZDGC201002003.htm [16] 李莉, 尹铁峰, 朱茜, 等. 城轨高架环境噪声特性与不同频段能量[J]. 交通运输工程学报, 2018, 18(2): 120-128. doi: 10.3969/j.issn.1671-1637.2018.02.013LI Li, YIN Tie-feng, ZHU Xi, et al. Characteristics and energies in different frequency bands of environmental noise in urban elevated rail[J]. Journal of Traffic and Transportation Engineering, 2018, 18(2): 120-128. (in Chinese). doi: 10.3969/j.issn.1671-1637.2018.02.013 [17] 张捷, 肖新标, 韩健, 等. 高速列车车内客室端部噪声分布特性与声学模态分析[J]. 机械工程学报, 2014, 50(12): 97-103. https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB201412014.htmZHANG Jie, XIAO Xin-biao, HAN Jian, et al. Characteristics of noise distribution at the ends of the coach and acoustic modal analysis of high-speed train[J]. Journal of Mechanical Engineering, 2014, 50(12): 97-103. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB201412014.htm [18] 张捷, 肖新标, 张玉梅, 等. 100%低地板列车车内噪声传递特性分析[J]. 振动工程学报, 2015, 28(4): 541-549.ZHANG Jie, XIAO Xin-biao, ZHANG Yu-mei, et al. Study on transfer path characteristic of interior noise of 100% low-floor railway train[J]. Journal of Vibration Engineering, 2015, 28(4): 541-549. (in Chinese). [19] 张捷, 肖新标, 王谛, 等. 350 km·h-1以上高速列车观光区噪声特性及其评价研究[J]. 铁道学报, 2012, 34(10): 23-29. doi: 10.3969/j.issn.1001-8360.2012.10.004ZHANG Jie, XIAO Xin-biao, WANG Di, et al. Characteristics and evaluation of noises in the tourist cabin of a train running at more than 350 km·h-1[J]. Journal of The China Railway Society, 2012, 34(10): 23-29. (in Chinese). doi: 10.3969/j.issn.1001-8360.2012.10.004 [20] 张玉梅, 肖新标, 温泽峰, 等. 低地板车结构传声及车内噪声特性[J]. 噪声与振动控制, 2014, 34(4): 1-4, 9. doi: 10.3969/j.issn.1006-1335.2014.04.001ZHANG Yu-mei, XIAO Xin-biao, WEN Ze-feng, et al. Structure-borne sound transfer path of a low-floor vehicle and its interior noise property[J]. Noise and Vibration Control, 2014, 34(4): 1-4, 9. (in Chinese). doi: 10.3969/j.issn.1006-1335.2014.04.001 [21] 张玉梅, 王瑞乾, 李晔, 等. 高速列车车窗隔声量研究[J]. 机械工程学报, 2018, 54(4): 212-221. https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB201804032.htmZHANG Yu-mei, WANG Rui-qian, LI Ye, et al. Study on sound transmission loss of windows on high speed trains[J]. Journal of Mechanical Engineering, 2018, 54(4): 212-221. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB201804032.htm [22] 柳明, 张捷, 高阳, 等. 隧道内高速列车车内噪声特性及声源识别试验分析[J]. 机械工程学报, 2020, 56(8): 207-215. https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB202008024.htmLIU Ming, ZHANG Jie, GAO Yang, et al. Experimental analysis on characteristics and source identification of interior noise of a high-speed train running in a tunnel[J]. Journal of Mechanical Engineering, 2020, 56(8): 207-215. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB202008024.htm [23] 郭建强, 葛剑敏, 朱雷威. 高速列车车内"声-振"特性试验[J]. 同济大学学报(自然科学版), 2018, 46(10): 1421-1426, 1432. doi: 10.11908/j.issn.0253-374x.2018.10.014GUO Jian-qiang, GE Jian-min, ZHU Lei-wei. Experimental on the characteristics of "sound-vibration" in high speed train[J]. Journal of Tongji University(Natural Science), 2018, 46(10): 1421-1426, 1432. (in Chinese). doi: 10.11908/j.issn.0253-374x.2018.10.014 [24] 郭建强, 朱雷威, 刘晓龙, 等. 地铁司机室噪声与钢轨波磨关系的试验与仿真研究[J]. 机械工程学报, 2019, 55(16): 141-147. https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB201916015.htmGUO Jian-qiang, ZHU Lei-wei, LIU Xiao-long, et al. Experimental and simulation study on the relationship between interior noise of metro cab and rail corrugation[J]. Journal of Mechanical Engineering, 2019, 55(16): 141-147. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB201916015.htm [25] 韩光旭, 温泽峰, 张捷, 等. 车轮非圆化对高速列车振动噪声的影响[J]. 噪声与振动控制, 2014, 34(4): 10-13, 23. doi: 10.3969/j.issn.1006-1335.2014.04.003HAN Guang-xu, WEN Ze-feng, ZHANG Jie, et al. Influence of out-of-roundness of wheels of high-speed trains on interior vibration and noise[J]. Noise and Vibration Control, 2014, 34(4): 10-13, 23. (in Chinese). doi: 10.3969/j.issn.1006-1335.2014.04.003 [26] 刘加利. 高速列车气动噪声特性分析及降噪研究[D]. 成都: 西南交通大学, 2013.LIU Jia-li. Study on characteristics analysis and control of aeroacoustics of high-speed trains[D]. Chengdu: Southwest Jiaotong University, 2013. (in Chinese). [27] 刘加利, 张继业, 张卫华. 高速列车车身表面气动噪声源研究[J]. 铁道车辆, 2010, 48(5): 1-5.LIU Jia-li, ZHANG Ji-ye, ZHANG Wei-hua. Research on the aerodynamic noise source on surface of high-speed trains[J]. Rolling Stock, 2010, 48(5): 1-5. (in Chinese). [28] 刘加利, 张继业, 张卫华. 高速列车车内中高频气动噪声计算方法[J]. 交通运输工程学报, 2011, 11(3): 55-60. doi: 10.3969/j.issn.1671-1637.2011.03.010LIU Jia-li, ZHANG Ji-ye, ZHANG Wei-hua. Calculation method of interior aerodynamic noises with middle and high frequencies for high-speed train[J]. Journal of Traffic and Transportation Engineering, 2011, 11(3): 55-60. (in Chinese). doi: 10.3969/j.issn.1671-1637.2011.03.010 [29] DENG Yong-quan, XIAO Xin-biao, HE Bin, et al. Analysis of external noise spectrum of high-speed railway[J]. Journal of Central South University, 2014, 21: 4753-4761. [30] 王兴民, 贾尚帅, 陈红伟, 等. 高速列车双层地板的隔声特性研究[J]. 噪声与振动控制, 2020, 40(1): 176-179. https://www.cnki.com.cn/Article/CJFDTOTAL-ZSZK202001033.htmWANG Xing-min, JIA Shang-shuai, CHEN Hong-wei, et al. Research of acoustic transmission performance for double layer floors of high speed trains[J]. Noise and Vibration Control, 2020, 40(1): 176-179. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZSZK202001033.htm [31] 姜世杰, 杨松, 闻邦椿, 等. 高速列车外流场气动噪声的特性研究[J]. 东北大学学报(自然科学版), 2020, 41(1): 74-78. https://www.cnki.com.cn/Article/CJFDTOTAL-DBDX202001013.htmJIANG Shi-jie, YANG Song, WEN Bang-chun, et al. Study on characteristics of the external aerodynamic noise of high-speed trains[J]. Journal of Northeastern University (Natural Science), 2020, 41(1): 74-78. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-DBDX202001013.htm [32] MELLET C, LETOURNEAUX F, POISSON F, et al. High speed train noise emission: latest investigation of the aerodynamic/rolling noise contribution[J]. Journal of Sound and Vibration, 2006, 293: 535-546. -
下载:
点击查看大图
图(13)
计量
- 文章访问数: 662
- HTML全文浏览量: 141
- PDF下载量: 620
- 被引次数: 0
