-
摘要: 为合理地计算UHPC构件的局部受压承载力,建立了有、无间接钢筋UHPC的局部受压试验数据库,以此为基础分析和评估了NF P 18-710、CECS 38:2004、DBJ 43/T 325—2017和JTG 3362—2018中的局部受压承载力计算公式;基于UHPC局部受压试验数据库提出了考虑混凝土强度和钢纤维影响的UHPC局部承压修正系数和间接钢筋影响系数,进而修正了JTG 3362—2018的局部受压承载力计算公式。研究结果表明:无间接钢筋UHPC的局部受压承载力试验值与NF P 18-710、CECS 38:2004、DBJ 43/T 325—2017和JTG 3362—2018计算值之比的均值分别为0.97、0.81、1.33和1.09,有间接钢筋UHPC的局部受压承载力试验值与CECS 38:2004、DBJ 43/T 325—2017和JTG 3362—2018计算值之比的均值分别为0.91、1.31和1.13;各规范公式的混凝土局部受压承载力公式未充分反映混凝土抗压强度和钢纤维的影响,间接钢筋的局部受压承载力计算公式未充分反映约束面积比、混凝土抗压强度和钢纤维的影响;NF P 18-710可较好地预测无间接钢筋UHPC的局部受压承载力,CECS 38:2004计算所得UHPC的局部受压承载力偏大,且间接钢筋的局部受压承载力预测结果离散性大,DBJ 43/T 325—2017和JTG 3362—2018的计算结果偏保守。有、无间接钢筋UHPC的局部受压承载力试验值与JTG 3362—2018修正公式的预测值之比的均值分别为1.00和1.04,标准差均小于0.20,因此,JTG 3362—2018修正公式可较好地预测有、无间接钢筋UHPC的局部受压承载力,可为国内UHPC桥梁结构设计规范的编制提供参考。Abstract: To reasonably calculate the local compressive bearing capacity of UHPC members, the local compression test database of UHPCs with and without indirect reinforcement was developed. Based on the database, the calculation formulae of local compressive bearing capacity in codes of NF P 18-710, CECS 38: 2004, DBJ 43/T 325—2017, and JTG 3362—2018 were analyzed and evaluated. A UHPC local compression correction factor and an indirect reinforcement influence factor were proposed to analyze the effects of concrete strength and steel fibers used in the UHPC local compression test database. Subsequently, the local compressive bearing capacity calculation formula in JTG 3362—2018 was modified. Research results indicate that the average ratios of experimental local compressive bearing capacities of UHPCs without indirect reinforcement to the calculated values by UHPC codes of NF P 18-710, CECS 38: 2004, DBJ 43/T 325—2017, and JTG 3362—2018 are 0.97, 0.81, 1.33, and 1.09, respectively. The average ratios of experimental local compressive bearing capacities of UHPCs with indirect reinforcement to the calculated values by CECS 38: 2004, DBJ 43/T 325—2017, and JTG 3362—2018 are 0.91, 1.31, and 1.13, respectively. Therefore, the calculation formulae of concrete local compressive bearing capacity in different codes do not completely reflect the influences of concrete compressive strength and steel fibers. Similarly, the local compressive bearing capacity calculation formulae of indirect reinforcement do not completely reflect the effects of constrained area ratio, concrete compressive strength, and steel fibers. NF P 18-710 can better predict the local compressive bearing capacity of UHPC without indirect reinforcement. CECS 38: 2004 overestimates the local compressive bearing capacity of UHPC, thereby diverging the estimated bearing capacity of indirect reinforcement. As for DBJ 43/T 325—2017 and JTG 3362—2018, their calculation results are relatively conservative. The average ratios of the experimental local compressive bearing capacities to the predicted values by the modified JTG 3362—2018 formula are 1.00 and 1.04 for UHPCs with and without indirect reinforcement, respectively, and the standard deviations in both cases are less than 0.20. Therefore, the modified formula in JTG 3362—2018 can better predict the local compressive capacities of UHPCs with and without indirect reinforcement, and thus it can provide a reference for the design specifications of domestic UHPC bridge structures. 1 tab, 13 figs, 31 refs.
-
表 1 无间接钢筋UHPC局部受压承载力预测结果统计指标
Table 1. Statistical indices of prediction results of UHPC local compressive bearing capacity without indirect reinforcement
计算公式 ξ 平均值 标准差 相关性系数 小于1的比例/% 最大值 最小值 NF P 18-710 0.97 0.24 0.87 48.7 1.77 0.51 CECS 38:2004 0.81 0.15 0.90 93.2 1.03 0.49 DBJ 43/T 325—2017 1.33 0.25 0.90 12.8 1.71 0.78 JTG 3362—2018 1.09 0.27 0.84 35.0 1.52 0.52 -
[1] 邵旭东, 邱明红, 晏班夫, 等. 超高性能混凝土在国内外桥梁工程中的研究与应用进展[J]. 材料导报, 2017, 31(12): 33-43. https://www.cnki.com.cn/Article/CJFDTOTAL-CLDB201723004.htmSHAO Xu-dong, QIU Ming-hong, YAN Ban-fu, et al. A review on the research and application of ultra-high performance concrete in bridge engineering around the world[J]. Material Reports, 2017, 31(12): 33-43. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-CLDB201723004.htm [2] 邵旭东, 邱明红. 基于UHPC材料的高性能装配式桥梁结构研发[J]. 西安建筑科技大学学报(自然科学版), 2019, 51(2): 160-167. https://www.cnki.com.cn/Article/CJFDTOTAL-XAJZ201902002.htmSHAO Xu-dong, QIU Ming-hong. Research on high performance fabricated bridge structures based on UHPC[J]. Journal of Xi'an University of Architecture and Technology (Natural Science Edition), 2019, 51(2): 160-167. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-XAJZ201902002.htm [3] 邵旭东, 曹君辉. 面向未来的高性能桥梁结构研发与应用[J]. 建筑科学与工程学报, 2017, 34(5): 41-58. doi: 10.3969/j.issn.1673-2049.2017.05.005SHAO Xu-dong, CAO Jun-hui. Research and application of high performance bridge structures toward future[J]. Journal of Architecture and Civil Engineering, 2017, 34(5): 41-58. (in Chinese) doi: 10.3969/j.issn.1673-2049.2017.05.005 [4] 邵旭东, 樊伟, 黄政宇. 超高性能混凝土在结构中的应用[J]. 土木工程学报, 2021, 54(1): 1-13. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC202101001.htmSHAO Xu-dong, FAN Wei, HUANG Zheng-yu. Application of ultra-high-performance concrete in engineering structures[J]. China Civil Engineering Journal, 2021, 54(1): 1-13. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC202101001.htm [5] 邵旭东, 詹豪, 雷薇, 等. 超大跨径单向预应力UHPC连续箱梁桥概念设计与初步实验[J]. 土木工程学报, 2013, 46(8): 83-89. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201308014.htmSHAO Xu-dong, ZHAN Hao, LEI Wei, et al. Conceptual design and preliminary experiment of super-long-span continuous box-girder bridge composed of one-way prestressed UHPC[J]. China Civil Engineering Journal, 2013, 46(8): 83-89. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201308014.htm [6] 邱明红, 邵旭东, 甘屹东, 等. 单向预应力UHPC连续箱梁桥面体系优化设计研究[J]. 土木工程学报, 2017, 50(11): 87-97. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201711009.htmQIU Ming-hong, SHAO Xu-dong, GAN Yi-dong, et al. Research on optimal design of deck system in longitudinal prestressed UHPC continuous box girder bridge[J]. China Civil Engineering Journal, 2017, 50(11): 87-97. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201711009.htm [7] 邵旭东, 张良, 张松涛, 等. 新型UHPC连续箱梁桥的体外预应力锚固构造形式研究[J]. 湖南大学学报(自然科学版), 2016, 43(3): 1-7. doi: 10.3969/j.issn.1674-2974.2016.03.001SHAO Xu-dong, ZHANG Liang, ZHANG Song-tao, et al. Study on structural forms of external prestressing anchorage for a novel continuous UHPC box-girder bridge[J]. Journal of Hunan University (Natural Sciences), 2016, 43(3): 1-7. (in Chinese) doi: 10.3969/j.issn.1674-2974.2016.03.001 [8] 冯峥, 李传习, 潘仁胜, 等. 密集横隔板UHPC箱梁锚固区局部承压性能研究[J]. 工程力学, 2020, 37(5): 94-103, 119. https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX202005012.htmFENG Zheng, LI Chuan-xi, PAN Ren-sheng, et al. Study on local compressive performance for anchorage zone of UHPC box-girder with densely distributed diaphragms[J]. Engineering Mechanics, 2020, 37(5): 94-103, 119. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX202005012.htm [9] 李传习, 冯峥, 郭立成, 等. 密集横隔板UHPC箱梁锚固区局部效应分析及配筋设计[J]. 公路交通科技, 2020, 37(5): 53-63. https://www.cnki.com.cn/Article/CJFDTOTAL-GLJK202005007.htmLI Chuan-xi, FENG Zheng, GUO Li-cheng, et al. Local effect analysis and reinforcement design for anchorage zone of UHPC box girder with densely distributed diaphragms[J]. Journal of Highway and Transportation Research and Development, 2020, 37(5): 53-63. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-GLJK202005007.htm [10] 蔡绍怀. 混凝土及配筋混凝土的局部承压强度[J]. 土木工程学报, 1963, 9(6): 1-10. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC196306000.htmCAI Shao-huai. Local compressive strength of concrete and reinforced concrete[J]. China Civil Engineering Journal, 1963, 9(6): 1-10. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC196306000.htm [11] 刘永颐, 曹声远, 杨熙坤, 等. 混凝土及钢筋混凝土的局部承压问题[J]. 建筑结构, 1982(4): 1-9. https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG198204000.htmLIU Yong-yi, CAO Sheng-yuan, YANG Xi-kun, et al. Local pressure problems in concrete and reinforced concrete[J]. Building Structure, 1982(4): 1-9. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG198204000.htm [12] 曹声远, 杨熙坤, 徐凯怡. 钢筋混凝土局部承压的试验研究[J]. 哈尔滨建筑工程学院学报, 1983(2): 1-22. https://www.cnki.com.cn/Article/CJFDTOTAL-HEBJ198302000.htmCAO Sheng-yuan, YANG Xi-kun, XU Kai-yi. Experimental research on local compression of reinforced concrete[J]. Journal of Harbin University of Civil Engineering and Architecture, 1983(2): 1-22. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-HEBJ198302000.htm [13] 曹声远, 杨熙坤, 徐凯恰. 钢筋混凝土局部承压的工作机理[J]. 哈尔滨建筑工程学院学报, 1984(1): 1-8. https://www.cnki.com.cn/Article/CJFDTOTAL-HEBJ198401000.htmCAO Sheng-yuan, YANG Xi-kun, XU Kai-yi. The working mechanism of local compression of reinforced concrete[J]. Journal of Harbin University of Civil Engineering and Architecture, 1984(1): 1-8. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-HEBJ198401000.htm [14] 曹声远, 杨熙坤, 徐凯怡. 钢筋混凝土局部承压强度理论[J]. 哈尔滨建筑工程学院学报, 1984(2): 25-33. https://www.cnki.com.cn/Article/CJFDTOTAL-HEBJ198402002.htmCAO Sheng-yuan, YANG Xi-kun, XU Kai-yi. Theory of local compressive strength of reinforced concrete[J]. Journal of Harbin University of Civil Engineering and Architecture, 1984(2): 25-33. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-HEBJ198402002.htm [15] 刘永颐, 关建光, 王传志. 混凝土局部承压强度及破坏机理[J]. 土木工程学报, 1985, 18(2): 53-65.LIU Yong-yi, GUAN Jian-guang, WANG Chuan-zhi. Bearing strength of concrete and its failure mechanism[J]. China Civil Engineering Journal, 1985, 18(2): 53-65. (in Chinese) [16] 杨波, 赵景海, 樊承谋. 钢纤维混凝土局部承压的试验研究[J]. 哈尔滨建筑工程学院学报, 1994(2): 84-89. https://www.cnki.com.cn/Article/CJFDTOTAL-HEBJ402.013.htmYANG Bo, ZHAO Jing-hai, FAN Cheng-mou. Experimental research on the steel fiber reinforced concrete with partial pressure[J]. Journal of Harbin University of Civil Engineering and Architecture, 1994(2): 84-89. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-HEBJ402.013.htm [17] 赵景海, 邙静喆. 钢纤维混凝土局部受压试验研究[J]. 河南科学, 2002, 20(6): 702-704. doi: 10.3969/j.issn.1004-3918.2002.06.023ZHAO Jing-hai, MANG Jing-zhe. Experimental research on steel fiber concrete subjected local loading[J]. Henan Science, 2002, 20(6): 702-704. (in Chinese) doi: 10.3969/j.issn.1004-3918.2002.06.023 [18] 范征宇, 邙静喆, 赵景海. CF60钢纤维混凝土局部受压的试验研究[J]. 低温建筑技术, 2003(1): 36-37. doi: 10.3969/j.issn.1001-6864.2003.01.018FAN Zheng-yu, MANG Jing-zhe, ZHAO Jing-hai. Experimental research on partial compression of CF60 steel fiber concrete[J]. Low Temperature Architecture Technology, 2003(1): 36-37. (in Chinese) doi: 10.3969/j.issn.1001-6864.2003.01.018 [19] 郑文忠, 赵军卫, 张博一. 活性粉末混凝土局压承载力试验与分析[J]. 南京理工大学学报(自然科学版), 2008, 32(3): 381-386. doi: 10.3969/j.issn.1005-9830.2008.03.027ZHENG Wen-zhong, ZHAO Jun-wei, ZHANG Bo-yi. Experiment and analysis of local compression bearing capacity of reactive powder concrete[J]. Journal of Nanjing University of Science and Technology (Natural Science), 2008, 32(3): 381-386. (in Chinese) doi: 10.3969/j.issn.1005-9830.2008.03.027 [20] 张利娜, 巴方, 张伟. 活性粉末混凝土局部抗压性能试验研究[J]. 工业建筑, 2009, 39(增1): 939-942. https://www.cnki.com.cn/Article/CJFDTOTAL-GYJZ2009S1253.htmZHANG Li-na, BA Fang, ZHANG Wei. The test study on local compressive performance of RPC[J]. Industrial Construction, 2009, 39(S1): 939-942. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-GYJZ2009S1253.htm [21] 周威, 郑文忠, 胡海波. 钢筋网片约束活性粉末混凝土局压性能试验研究[J]. 建筑结构学报, 2013, 34(11): 141-150. https://www.cnki.com.cn/Article/CJFDTOTAL-JZJB201311019.htmZHOU Wei, ZHENG Wen-zhong, HU Hai-bo. Bearing capacity of reactive powder concrete reinforced by orthogonal ties[J]. Journal of Building Structures, 2013, 34(11): 141-150. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-JZJB201311019.htm [22] 周威, 胡海波, 郑文忠. 高强螺旋筋约束活性粉末混凝土局压承载力试验[J]. 土木工程学报, 2014, 47(8): 63-72. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201408011.htmZHOU Wei, HU Hai-bo, ZHENG Wen-zhong. Bearing capacity of reactive powder concrete reinforced by high-strength steel spirals[J]. China Civil Engineering Journal, 2014, 47(8): 63-72. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC201408011.htm [23] 周威, 胡海波. 预留孔道活性粉末混凝土局压性能与承载力分析[J]. 工程力学, 2014, 31(7): 119-128. https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX201407018.htmZHOU Wei, HU Hai-bo. Analysis on bearing capacity and behavior of reactive powder concrete with empty concentric duct under local pressure[J]. Engineering Mechanics, 2014, 31(7): 119-128. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX201407018.htm [24] ZHOU Wei, HU Hai-bo, ZHENG Wen-zhong. Bearing capacity of reactive powder concrete reinforced by steel fibers[J]. Construction and Building Materials, 2013, 48: 1179-1186. doi: 10.1016/j.conbuildmat.2013.07.103 [25] 李文全. 活性粉末混凝土预应力锚固区局压性能研究[D]. 长沙: 湖南大学, 2017.LI Wen-quan. Performance study on the local compression of reactive powder concrete under anchorages[D]. Changsha: Hunan University, 2017. (in Chinese) [26] BOULAY C, TOUTLEMONDE F, CLE'ENT J L, et al. Safety of VHSC structures under concentrated loading: experimental approach[J]. Magazine of Concrete Research, 2004, 56(9): 523-535. doi: 10.1680/macr.2004.56.9.523 [27] CHOI E S, LEE J W, JOH C B, et al. A local compression tests of UHPC anchor blocks for post-tensioning tendons[J]. Key Engineering Materials, 2012, 525/526: 561-564. doi: 10.4028/www.scientific.net/KEM.525-526.561 [28] KIM J S, JOH C B, CHOI Y S, et al. Load transfer test of post-tensioned anchorage zone in ultra high performance concrete[J]. Engineering, 2015, 7(3): 115-128. doi: 10.4236/eng.2015.73010 [29] KIM J H, KWAK H G, KIM B S, et al. Finite element analyses and design of post-tensioned anchorage zone in ultra-high-performance concrete beams[J]. Advances in Structural Engineering, 2019, 22(2): 323-336. doi: 10.1177/1369433218787727 [30] NF P 18-710, national addition to Eurocode 2—design of concrete structures: specific rules for ultra-high performance fibre-reinforced concrete (UHPFRC)[S]. [31] 郑文忠, 吕雪源. 活性粉末混凝土研究进展[J]. 建筑结构学报, 2015, 36(10): 45-58. https://www.cnki.com.cn/Article/CJFDTOTAL-JZJB201510007.htmZHENG Wen-zhong, LYU Xue-yuan. Literature review of reactive powder concrete[J]. Journal of Building Structures, 2015, 36(10): 44-58. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-JZJB201510007.htm