Study of noise reduction effect and influencing parameters for a resilient wheel considering rotation effect
-
摘要: 以某款弹性车轮及其原型普通车轮为研究对象，在考虑车轮旋转带来的移动荷载效应和陀螺效应的前提下，应用2.5维结构有限元法和2.5维声学边界元法预测车轮在给定轮轨粗糙度激励下的振动和声辐射；针对40、80和120 km·h-1三个运行速度，分析了弹性车轮的降噪机理，研究了弹性车轮橡胶层的材料参数对弹性车轮降噪效果的影响。研究结果表明：车轮旋转使得原本非0节径模态频率处的声功率峰值分叉为2个峰值，其中一个峰值频率比原模态频率高，另一个峰值频率比原模态频率低，2个峰值频率差近似等于车轮的旋转频率乘以2倍的模态节径数；在所考虑的工况下，车轮旋转对车轮声辐射的影响最高达3.2 dB(A)，因此，在预测车轮的声辐射时，必须考虑旋转对预测结果的影响；如果橡胶弹性模量太小，则轮箍容易振动，从而有可能辐射比普通车轮更高的噪声；从车轮声辐射的角度，橡胶弹性模量存在一个最佳值，在这个值下，弹性车轮的声功率最低，且低于原型车轮的声功率10 dB(A)以上；增加橡胶阻尼总是有利于车轮噪声的控制，但增加阻尼产生的降噪效果随橡胶弹性模量的增大而降低；对于同一弹性车轮，随着运行速度的提升，相对原型普通车轮的降噪效果不断降低，速度从40 km·h-1增大到120 km·h-1，降噪效果降低达4 dB(A)以上。Abstract: An resilient wheel and its prototype ordinary wheel were taken as the research objects, the 2.5D structural finite element method and 2.5D acoustic boundary element method were used to predict the vibration and sound radiation of the wheels under the excitation of a given wheel-rail roughness and considering the moving load effect and gyro effect caused by the wheel rotation. The noise reduction mechanism of the resilient wheel was analyzed at the three running speeds of 40, 80 and 120 km·h-1, and the effect of the material parameters of the resilient wheel rubber layer on the noise reduction effect was studied. Research results show that the wheel rotation makes the acoustic power peak at the original non-zero node-diameter mode frequency bifurcated into two peaks, one of which is higher than the original mode frequency, and the other is lower than the original mode frequency. The difference between the two peak frequencies is approximately equal to the wheel rotation frequency multiplied by two times the number of mode node-diameter. Under considering all cases, the effect of the wheel rotation on the sound radiation of the wheel can be as high as 3.2 dB(A). Therefore, the vibro-acoustics of the wheel must be predicted by considering the wheel rotation. If the Young's modulus of the rubber layer is too low, the wheel rim will vibrate so strongly that the wheel radiates higher sound power than the ordinary wheel. In terms of sound radiation, there is an optimal Young's modulus for the rubber layer, at which the resilient wheel radiates lowest sound power more than 10 dB(A) lower than the ordinary wheel. Increasing rubber damping will reduce the sound radiation from the wheel, however, the reduction is adversely affected by the Young's modulus of the rubber. With the increase of running speed, the noise reduction effect of resilient wheel decreases continuously compared with the prototype common wheel, and the reduction is more than 4 dB(A) when wheel speed increases from 40 km·h-1 to 120 km·h-1. 4 tabs, 10 figs, 27 refs.
-
图 9 不同弹性模量下车轮的声功率级
Figure 9. Sound power levels of wheels with different elastic moduli
图 10 不同损失因子下的弹性车轮降噪量
Figure 10. Noise reductions of resilient wheels with different loss factors
表 1 静止车轮辐射声功率级
Table 1. Radiated sound power levels of wheels not in rotation
dB(A) 车速/(km·h-1) 40 80 120 普通车轮 80.54 91.97 99.50 不同弹性模量(MPa)的弹性车轮 210 000 67.90 78.31 89.68 2 300 63.76 76.88 85.24 575 70.95 86.07 93.02 144 82.45 98.89 105.79 36 85.27 95.78 102.66 
下载: 导出CSV
表 2 旋转车轮辐射声功率级
Table 2. Radiated sound power levels of wheels in rotation
dB(A) 车速/(km·h-1) 40 80 120 普通车轮 82.89 93.98 100.16 不同弹性模量(MPa)的弹性车轮 210 000 67.77 78.17 89.49 2 300 63.66 76.69 85.17 575 70.56 85.50 92.87 144 81.35 95.72 101.35 36 84.36 97.49 104.96
下载: 导出CSV
表 3 不同损失因子下的车轮声功率级(E=2 300 MPa)
Table 3. Sound power levels of wheels with different loss factors (E=2 300 MPa)
dB(A) 车速/(km·h-1) 40 80 120 损失因子 0.2 63.66 76.69 85.17 0.3 61.75 74.75 83.22 0.4 60.41 73.45 82.05 损失因子从0.2增至0.4的效果 3.25 3.24 3.12
下载: 导出CSV
表 4 不同损失因子下的车轮声功率级(E=575 MPa)
Table 4. Sound power levels of wheels with different loss factors (E=575 MPa)
dB(A) 车速/(km·h-1) 40 80 120 损失因子 0.2 70.56 85.50 92.78 0.3 68.25 82.98 90.24 0.4 66.67 81.25 88.64 损失因子从0.2增至0.4的效果 3.89 4.25 4.14
下载: 导出CSV
-
[1] THOMPSON D J, LATORRE IGLESIAS E, LIU Xiao-wan, et al. Recent developments in the prediction and control of aerodynamic noise from high-speed trains[J]. International Journal of Rail Transportation, 2015, 3(3): 119-150. doi: 10.1080/23248378.2015.1052996 [2] 张曙光. 350 km·h-1高速列车噪声机理、声源识别及控制[J]. 中国铁道科学, 2009, 30(1): 86-90. doi: 10.3321/j.issn:1001-4632.2009.01.015ZHANG Shu-guang. Noise mechanism, sound source localization and noise control of 350 km·h-1 high-speed train[J]. China Railway Science, 2009, 30(1): 86-90. (in Chinese) doi: 10.3321/j.issn:1001-4632.2009.01.015 [3] POISSON F, GAUTIER P E, LETOURNEAUX F. Noise sources for high-speed trains: a review of results in the TGV case[J]. Noise and Vibration Mitigation for Rail Transportation Systems, 2008: 71-77. [4] THOMPSON D J, GAUTIER P E. Review of research into wheel/rail rolling noise reduction[J]. Proceedings of the Institution of Mechanical Engineers, Part F: Journal of Rail and Rapid Transit, 2006, 220(4): 385-408. doi: 10.1243/0954409JRRT79 [5] 郑伟生. 轻轨、地铁车轮选型的研究[J]. 国外铁道车辆, 2000, 37(2): 17-22. doi: 10.3969/j.issn.1002-7610.2000.02.004ZHENG Wei-sheng. Research on model selection of wheels for light rail and metro cars[J]. Foregin Roling Stock, 2000, 37(2): 17-22. (in Chinese) doi: 10.3969/j.issn.1002-7610.2000.02.004 [6] 赵熙雍. 橡胶弹性车轮的发展与应用[J]. 机车电传动, 2001(4): 5-6, 12. doi: 10.3969/j.issn.1000-128X.2001.04.002ZHAO Xi-yong. Development and application of rubber elastic wheels[J]. Electric Drive for Locomotive, 2001(4): 5-6, 12. (in Chinese) doi: 10.3969/j.issn.1000-128X.2001.04.002 [7] 钟世云, 林建平, 龚农斌, 等. 低噪声车轮研究和应用的进展[J]. 电力机车与城轨车辆, 2005, 28(5): 1-4. doi: 10.3969/j.issn.1672-1187.2005.05.001ZHONG Shi-yun, LIN Jian-ping, GONG Nong-bin, et al. Development of research and application of low-noise railway wheels[J]. Electric Locomotives and Mass Transit Vehicles, 2005, 28(5): 1-4. (in Chinese) doi: 10.3969/j.issn.1672-1187.2005.05.001 [8] BOUVET P, VINCENT N, COBLENTZ A, et al. Optimization of resilient wheels for rolling noise control[J]. Journal of Sound and Vibration, 2000, 231(3): 765-777. doi: 10.1006/jsvi.1999.2561 [9] ESSLINGER V, KIESELBACH R, KOLLER R, et al. The railway accident of Eschede-technical background[J]. Engineering Failure Analysis, 2004, 11(4): 515-535. doi: 10.1016/j.engfailanal.2003.11.001 [10] 杨阳, 丁军君, 李芾, 等. 弹性车轮等效刚度对车辆动力学性能的影响[J]. 中国铁道科学, 2018, 39(3): 63-70. doi: 10.3969/j.issn.1001-4632.2018.03.09YANG Yang, DING Jun-jun, LI Fu, et al. Effect of equivalent stiffness of resilient wheel on vehicle dynamic performance[J]. China Railway Science, 2018, 39(3): 63-70. (in Chinese) doi: 10.3969/j.issn.1001-4632.2018.03.09 [11] CIGADA A, MANZONI S, VANALI M. Vibro-acoustic characterization of railway wheels[J]. Applied Acoustics, 2008, 69(6): 530-545. doi: 10.1016/j.apacoust.2007.01.002 [12] CIGADA A, MANZONI S, VANALI M. Geometry effects on the vibro-acoustic behavior of railway resilient wheels[J]. Journal of Vibration and Control, 2011, 17(12): 1761-1778. doi: 10.1177/1077546310362452 [13] KOO D H, KIM J C, YOO W H, et al. An experimental study of the effect of low-noise wheels in reducing noise and vibration[J]. Transportation Research Part D: Transport and Environment, 2002, 7(6): 429-439. doi: 10.1016/S1361-9209(02)00011-1 [14] 刘玉霞, 韩健, 周信, 等. 弹性车轮减振降噪特性分析[J]. 铁道学报, 2015, 37(6): 48-53. doi: 10.3969/j.issn.1001-8360.2015.06.007LIU Yu-xia, HAN Jian, ZHOU Xin, et al. Analysis of vibration and noise reduction characteristics of resilient wheel[J]. Journal of the China Railway Society, 2015, 37(6): 48-53. (in Chinese) doi: 10.3969/j.issn.1001-8360.2015.06.007 [15] TIAN Jian-hui, WANG Ke, XIAO Kan. Analysis of vibration and sound radiation characteristics of resilient wheel in metro[J]. American Journal of Mechanical and Industrial Engineering, 2018, 3(4): 55-63. doi: 10.11648/j.ajmie.20180304.13 [16] SUAREZ B, CHOVER J A, RODRIGUEZ P, et al. Effectiveness of resilient wheels in reducing noise and vibrations[J]. Proceedings of the Institution of Mechanical Engineers, Part F: Journal of Rail and Rapid Transit, 2011, 225(6): 545-565. doi: 10.1177/0954409711404104 [17] ZHOU Xin, HAN Jian, ZHAO Yue, et al. Characteristics of vibration and sound radiation of metro resilient wheel[J]. Chinese Journal of Mechanical Engineering, 2019, 32(4): 205-216. [18] 葛帅, 成功, 圣小珍, 等. 旋转对阻尼车轮降噪效果的影响分析[J]. 机械工程学报, 2021, 57(4): 164-173. https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB202104019.htmGE Shuai, CHENG Gong, SHENG Xiao-zhen, et al. Analysis of the influence of rotation on the noise reduction effect of damped wheels[J]. Journal of Mechanical Engineering, 2021, 57(4): 164-173. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB202104019.htm [19] SHENG Xiao-zhen, LIU Yu-xia, ZHOU Xin. The response of a high-speed train wheel to a harmonic wheel-rail force[J]. Journal of Physics: Conference Series, 2016, 744: 012145. doi: 10.1088/1742-6596/744/1/012145 [20] ZHONG Ting-sheng, CHENG Gong, SHENG Xiao-zhen, et al. Vibration and sound radiation of a rotating train wheel subject to a vertical harmonic wheel-rail force[J]. Journal of Modern Transportation, 2018, 26(2): 81-95. doi: 10.1007/s40534-017-0154-6 [21] 圣小珍. 高速旋转车轮的高频振动[J]. 南昌工程学院学报, 2018, 37(6): 1-13. doi: 10.3969/j.issn.1006-4869.2018.06.002SHENG Xiao-zhen. High frequency vibrations of train wheel in fast rotation[J]. Journal of Nanchang Institute of Technology, 2018, 37(6): 1-13. (in Chinese) doi: 10.3969/j.issn.1006-4869.2018.06.002 [22] THOMPSON D. Railway Noise and Vibration: Mechanisms, Modelling and Means of Control[M]. Amsterdam: Elsevier Science, 2009. [23] CHENG Gong, HE Yuan-peng, HAN Jian, et al. An investigation into the effects of modelling assumptions on sound power radiated from a high-speed train wheelset[J]. Journal of Sound and Vibration, 2021, 495: 115910. doi: 10.1016/j.jsv.2020.115910 [24] ISO 3095: 2005, Railway applications-acoustics-measurement of noise emitted by rail bound vehicles[S]. [25] SHENG Xiao-zhen, ZHONG Ting-sheng, LI Ya-guang. Vibration and sound radiation of slab high-speed railway tracks subject to a moving harmonic load[J]. Journal of Sound and Vibration, 2017, 395: 160-186. doi: 10.1016/j.jsv.2017.02.024 [26] XIAO Xin-biao, LI Ya-guang, ZHONG Ting-sheng, et al. Theoretical investigation into the effect of rail vibration dampers on the dynamical behaviour of a high-speed railway track[J]. Journal of Zhejiang University-SCIENCE A, 2017, 18(8): 631-647. doi: 10.1631/jzus.A1600697 [27] JONES C J C, THOMPSON D J. Rolling noise generated by railway wheels with visco-elastic layers[J]. Journal of Sound and Vibration, 2000, 231(3): 779-790. doi: 10.1006/jsvi.1999.2562 -
点击查看大图
图(10) / 表(4)
计量
- 文章访问数: 318
- HTML全文浏览量: 103
- PDF下载量: 37
- 被引次数: 0
