Running safety of hybrid rigid frame railway bridge with double-deck combined steel truss during earthquakes
-
摘要: 针对特殊地区地震作用下大跨度桥梁行车安全性问题,以某铁路某双层结合钢桁混合刚构桥为工程背景,建立了考虑材料非线性、切向摩擦与轮轨赫兹准确接触关系的列车-轨道-桥梁耦合振动分析模型,并基于ABAQUS-Python软件二次开发,实现了钢轨随机不平顺的施加;选取EL Centro地震波为输入波,分析了强震作用下双层结合钢桁混合刚构桥的损伤演化规律,计算了不同地震强度、不同车速下列车脱轨系数、轮重减载率、车体振动加速度等动力响应指标,分析了关键参数对地震作用下桥上行车安全性的影响规律,提出了该混合刚构桥基于行车安全性能的车速限值。研究结果表明:在罕遇地震作用(0.38g)下,桥梁各构件均出现不同程度的塑性损伤,桥墩破坏区域较大,震后桥梁仍具有一定的承载力;震时列车脱轨系数随地震强度增大而显著增大;车体最大振动加速度与地震强度近似呈线性增长;列车轮重减载率是控制行车安全的关键指标,其峰值与车速呈正相关;当车速为200 km·h-1,地震强度大于0.10g时,列车轮重减载率存在超限情况,列车在下桥时会出现长时间轮轨分离现象;从行车安全性的角度,在设计地震作用0.20g时,安全车速为160 km·h-1。
-
关键词:
- 桥梁工程 /
- 列车-轨道-桥梁耦合振动 /
- 双层结合钢桁混合刚构桥 /
- 地震作用 /
- 桥梁损伤演化规律 /
- 行车安全性
Abstract: A hybrid rigid frame railway bridge with a double-deck combined steel truss was taken as the engineering background to investigate the running safety of long-span bridges during earthquakes in special areas. A train-track-bridge coupled vibration analysis model was established by taking into account material nonlinearity, tangential friction, and accurate wheel-rail Hertzian contact relationship. In addition, the application of random irregularities of the rails was realized on the basis of the secondary development of ABAQUS-Python software. The EL Centro seismic wave was selected as the input excitation to analyze the damage evolution laws of the hybrid rigid frame bridge with a double-deck combined steel truss under the action of a strong earthquake. The dynamic response indexes under different earthquake intensities and different train speeds were calculated, including the train derailment coefficient, wheel load reduction rate, and train body vibration acceleration. The influence laws of key parameters on the running safety of the bridge during earthquakes were revealed, and the train speed limit based on the running safety was proposed for the hybrid rigid frame bridge. Research results show that the plastic damage in different degrees occurs on each component of the bridge under a rare earthquake (0.38g), the bridge piers are damaged in large areas, and the bridge still has a certain bearing capacity after the earthquake. The train derailment coefficient during the earthquake rises significantly with the increase in the earthquake intensity. The maximum train body vibration acceleration presents an approximately linear increase with the earthquake intensity. The wheel load reduction rate of a train is the key control indicator to the running safety, and its peak value is positively correlated with the train speed. The wheel load reduction rate of a train exceeds the limit, and wheel-rail separation occurs for a long time at the moment when the train gets off the bridge under the train speed of 200 km·h-1 and the earthquake intensity greater than 0.10g. The safe speed is 160 km·h-1 under 0.20g design earthquake from the perspective of running safety. 2 tabs, 13 figs, 30 refs. -
表 1 德国低干扰轨道谱参数取值
Table 1. Spectral parameter values of German low-interference orbit
轨道级别 Ωc/(rad·m-1) Ωr/(rad·m-1) Ωs/(rad·m-1) Aa/[m2·(rad·m-1)] Av/[m2·(rad·m-1)] Ag/[m2·(rad·m-1)] 低干扰 0.824 6 0.020 6 0.438 0 2.12×10-7 4.03×10-7 5.32×10-8 表 2 钢筋材料参数
Table 2. Rebar material parameters
材料 弹性模量/GPa 泊松比 应力/MPa 塑性应变 普通钢筋 200 0.3 335 0 455 0.05 -
[1] LI Y L, ZHU S Y, CAI C S, et al. Dynamic response of railway vehicles running on long-span cable-stayed bridge under uniform seismic excitations[J]. International Journal of Structural Stability and Dynamics, 2016, 16(5): 1550005. doi: 10.1142/S0219455415500054 [2] ZENG Z P, LIU F S, WANG W D. Three-dimensional train-track-bridge coupled dynamics model based on the explicit finite element method[J]. Soil Dynamics and Earthquake Engineering, 2022, 153: 107066. doi: 10.1016/j.soildyn.2021.107066 [3] YANG Y B, WU Y S. Dynamic stability of trains moving over bridges shaken by earthquakes[J]. Journal of Sound and Vibration, 2002, 258(1): 65-94. doi: 10.1006/jsvi.2002.5089 [4] 张楠, 夏禾. 地震对多跨简支梁桥上列车运行安全的影响[J]. 世界地震工程, 2001, 17(4): 93-99. doi: 10.3969/j.issn.1007-6069.2001.04.016ZHANG Nan, XIA He. Influence of earthquakes on running safety of vehicles on multi-span girders bridge[J]. World Earthquake Engineering, 2001, 17(4): 93-99. (in Chinese) doi: 10.3969/j.issn.1007-6069.2001.04.016 [5] ZENG Q, DIMITRAKOPOULOS E G. Seismic response analysis of an interacting curved bridge-train system under frequent earthquakes[J]. Earthquake Engineering and Structural Dynamics, 2016, 45(7): 1129-1148. doi: 10.1002/eqe.2699 [6] 陈令坤, 蒋丽忠. 地震作用下高速铁路列车-无砟轨道-桥梁系统动力响应及列车走行安全研究[J]. 中国铁道科学, 2013, 34(1): 131-133. doi: 10.3969/j.issn.1001-4632.2013.01.20CHEN Ling-kun, JIANG Li-zhong. Research on the dynamic response of high-speed railway train-ballastless track-bridge system and train running safety under earthquake[J]. China Railway Science, 2013, 34(1): 131-133. (in Chinese) doi: 10.3969/j.issn.1001-4632.2013.01.20 [7] YU J, ZHOU W B, JIANG L Z. Study on the estimate for seismic response of high-speed railway bridge-track system[J]. Engineering Structures, 2022, 267: 114711. doi: 10.1016/j.engstruct.2022.114711 [8] XIA H, HAN Y, ZHANG N, et al. Dynamic analysis of train-bridge system subjected to non-uniform seismic excitations[J]. Earthquake Engineering and Structural Dynamics, 2006, 35(12): 1563-1579. doi: 10.1002/eqe.594 [9] 韩艳, 夏禾, 张楠. 考虑非一致地震输入的车-桥系统动力响应分析[J]. 中国铁道科学, 2006, 27(5): 46-53. doi: 10.3321/j.issn:1001-4632.2006.05.009HAN Yan, XIA He, ZHANG Nan. Dynamic response analysis of train-bridge system under non-uniform seismic excitations[J]. China Railway Science, 2006, 27(5): 46-53. (in Chinese) doi: 10.3321/j.issn:1001-4632.2006.05.009 [10] 雷虎军, 李小珍. 非一致地震激励下列车-轨道-桥梁耦合振动模型[J]. 西南交通大学学报, 2013, 48(5): 803-809. doi: 10.3969/j.issn.0258-2724.2013.05.004LEI Hu-jun, LI Xiao-zhen. Dynamic model for train-track-bridge coupling system subjected to non-uniform seismic excitation[J]. Journal of Southwest Jiaotong University, 2013, 48(5): 803-809. (in Chinese) doi: 10.3969/j.issn.0258-2724.2013.05.004 [11] WANG W, ZHANG Y H, OUYANG H J. Influence of random multi-point seismic excitations on the safety performance of a train running on a long-span bridge[J]. International Journal of Structural Stability and Dynamics, 2020, 20(4): 2050054. doi: 10.1142/S0219455420500546 [12] 韩艳, 夏禾. 地震作用下高速铁路桥梁的动力响应及行车安全性研究[J]. 中国铁道科学, 2006, 27(3): 136-138. doi: 10.3321/j.issn:1001-4632.2006.03.025HAN Yan, XIA He. Dynamic responses of high-speed railway bridges and running safety of vehicles during earthquakes[J]. China Railway Science, 2006, 27(3): 136-138. (in Chinese) doi: 10.3321/j.issn:1001-4632.2006.03.025 [13] LI H Y, YU Z W, MAO J F, et al. Nonlinear random seismic analysis of 3D high-speed railway track-bridge system based on OpenSEES[J]. Structures, 2020, 24: 87-98. doi: 10.1016/j.istruc.2020.01.003 [14] 杜宪亭, 乔宏, 夏禾, 等. 地震作用下结构拟静力分量对车桥系统动力响应的影响分析[J]. 振动与冲击, 2016, 35(16): 6-11. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201616002.htmDU Xian-ting, QIAO Hong, XIA He, et al. Influence of structure quasi-static components on the dynamic response of train-bridge systems during earthquakes[J]. Journal of Vibration and Shock, 2016, 35(16): 6-11. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201616002.htm [15] CHEN L K, JIANG L Z, QIN H X, et al. Nonlinear seismic assessment of isolated high-speed railway bridge subjected to near-fault earthquake scenarios[J]. Structure and Infrastructure Engineering, 2019, 15(11): 1529-1547. doi: 10.1080/15732479.2019.1639775 [16] 雷虎军, 李小珍. 非一致地震激励下列车-轨道-桥梁耦合振动及行车安全性研究[J]. 中国铁道科学, 2014, 35(6): 138-140. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK201406023.htmLEI Hu-jun, LI Xiao-zhen. Coupling vibration and running safety of train-track-bridge system under non-uniform seismic excitations[J]. China Railway Science, 2014, 35(6): 138-140. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK201406023.htm [17] 雷虎军, 刘伟. 脉冲型近场地震作用下列车-简支梁桥的耦合振动[J]. 土木与环境工程学报(中英文), 2022, 44(3): 44-53. https://www.cnki.com.cn/Article/CJFDTOTAL-JIAN202203006.htmLEI Hu-jun, LIU Wei. Coupling vibration analysis of train-s imply supported beam bridge under near-field earthquake with pulse[J]. Journal of Civil Engineering and Environmental Engineering, 2022, 44(3): 44-53. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-JIAN202203006.htm [18] QIAO Hong, DU Xian-ting, XIA He, et al. The effect of local topography on the seismic response of a coupled train-bridge system[J]. Structural Engineering and Mechanics, 2019, 69(2): 177-191. [19] 雷虎军, 孙昱坤. 地震动分量对车-轨-桥系统动力响应影响研究[J]. 桥梁建设, 2020, 50(5): 73-77. https://www.cnki.com.cn/Article/CJFDTOTAL-QLJS202005013.htmLEI Hu-jun, SUN Yu-kun. Influence of ground motion components on dynamic response of train-track-bridge system[J]. Bridge Construction, 2020, 50(5): 73-77. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-QLJS202005013.htm [20] WANDJI ZOUMB P A, LI X Z, WANG M. Effects of earthquake-induced hydrodynamic force on train-bridge interactions[J]. Journal of Bridge Engineering, 2022, 27(4): 04022010. [21] 雷虎军, 黄江泽. 考虑桩土相互作用的车-轨-桥系统地震响应分析[J]. 西南交通大学学报, 2021, 56(2): 229-237. https://www.cnki.com.cn/Article/CJFDTOTAL-XNJT202102002.htmLEI Hu-jun, HUANG Jiang-ze. Seismic responses analysis of train-track-bridge system considering pile-soil interaction[J]. Journal of Southwest Jiaotong University, 2021, 56(2): 229-237. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-XNJT202102002.htm [22] SHAMSI M, ZAKERINEJAD M, VAKILI A H. Seismic analysis of soil-pile-bridge-train interaction for isolated monorail and railway bridges under coupled lateral-vertical ground motions[J]. Engineering Structures, 2021, 248: 113258. [23] 国巍, 李君龙, 刘汉云. 强地震下高速铁路桥上行车精细化模拟及行车安全性分析[J]. 工程力学, 2018, 35(S1): 259-264, 277. https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX2018S1044.htmGUO Wei, LI Jun-long, LIU Han-yun. The analysis of running safety of high-speed-train on bridge by using refined simulation considering strong earthquake[J]. Engineering Mechanics, 2018, 35(S1): 259-264, 277. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX2018S1044.htm [24] 邓子铭, 郭向荣, 张志勇. 地震作用对钢桁梁桥车桥系统耦合振动的影响分析[J]. 中南大学学报(自然科学版), 2011, 42(1): 184-191. https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD201101032.htmDENG Zi-ming, GUO Xiang-rong, ZHANG Zhi-yong. Coupled vibration of train-bridge system of steel truss bridge with seismic effect[J]. Journal of Central South University (Science and Technology), 2011, 42(1): 184-191. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD201101032.htm [25] 熊建珍, 高芒芒, 俞翰斌. 天兴洲长江大桥斜拉桥在地震作用下的车-桥耦合振动分析[J]. 中国铁道科学, 2006, 27(5): 54-59. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK200605009.htmXIONG Jian-zhen, GAO Mang-mang, YU Han-bin. Vehicle-bridge coupling vibration analysis of cable-stayed bridge of Tianxingzhou Yangtze River Bridge under earthquakes[J]. China Railway Science, 2006, 27(5): 54-59. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK200605009.htm [26] GONG W, ZHU Z H, WANG K, et al. A real-time co-simulation solution for train-track-bridge interaction[J]. Journal of Vibration and Control, 2021, 27(13/14): 1606-1616. [27] LU X Z, KIM C W, CHANG K C. Finite element analysis framework for dynamic vehicle-bridge interaction system based on ABAQUS[J]. International Journal of Structural Stability and Dynamics, 2020, 20(3): 2050034. [28] JIN Z B, PEI S L, LI X Z, et al. Effect of vertical ground motion on earthquake-induced derailment of railway vehicles over simply-supported bridges[J]. Journal of Sound and Vibration, 2016, 383: 277-294. [29] ZENG Q, DIMITRAKOPOULOS E G. Vehicle-bridge interaction analysis modeling derailment during earthquakes[J]. Nonlinear Dynamics, 2018, 93(4): 2315-2337. [30] 田国英, 高建敏, 翟婉明. 高速铁路轨道不平顺管理标准的对比分析[J]. 铁道工程学报, 2015, 37(3): 64-71. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201503013.htmTIAN Guo-ying, GAO Jian-min, ZHAI Wan-ming. Comparative analysis of track irregularity management standards for high-speed railways[J]. Journal of the China Railway Society, 2015, 37(3): 64-71. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201503013.htm