Screening method of suspected irregularity for medium- and low-speed maglev tracks based on Box-Whisker plot
-
摘要: 为了减少中低速磁浮轨道检测工作量和轨道检测设备占用线路的时间，提升轨道不平顺检测效率，提出了通过行车记录仪采集悬浮系统有关数据来筛选轨道疑似不平顺的方法；依据轨道线路不平顺异常对悬浮间隙、悬浮电磁铁垂向加速度及电磁铁电流等都会造成明显突变异常的基本思想，基于Box-Whisker图设定筛选阈值，利用悬浮间隙、悬浮电磁铁垂向加速度及电磁铁电流等数据进行三元阈值的异常筛选，并针对可能漏筛的数据再次分别基于一元和二元阈值筛选，并综合上述结果来判定轨道路段的异常等级，将多次被筛选出的异常判定为疑似不平顺路段；为进一步提升不平顺异常路段筛选结果的准确性，依据同一车厢的不同悬浮控制点通过相同不平顺异常路段时的数据应体现出重复性异常的思想，融合行车记录仪记录的多个悬浮控制点数据的筛选结果，以此综合评判路段的疑似不平顺，在此基础上应用提出的方法分析了长沙磁浮线M车厢左侧10处悬浮控制系统的数据。研究结果表明：提出的方法使现有全路段不平顺检测方式转变为利用轨检设备有针对性地检测疑似异常路段的方式，线路检测维护时间可减少20%左右。Abstract: In order to reduce the workload of medium- and low-speed maglev track detection and the time occupied by track detection equipment and improve the efficiency of track irregularity detection, a method for screening suspected track irregularities by collecting the relevant data of suspension system through the driving recorder was proposed. According to the basic idea that the abnormal irregularity of the track line would cause obvious mutation anomalies to the suspension gap, vertical acceleration of the suspension electromagnet, and electromagnet current, based on the Box-Whitker plot, the screening threshold was set up, and the abnormal screening of the ternary threshold was carried out by using the data of suspension gap, vertical acceleration of the suspension electromagnet, and electromagnet current, and the data that might be missed were screened again based on the monadic and binary thresholds. The above results were used to determine the abnormal level of the track section, and the abnormal sections that had been screened many times were judged as sections with suspected irregularity. To further improve the accuracy of the screening results of abnormal sections with irregularity, according to the data of different suspension control points of the same carriage passing through the same abnormal section with irregularity, the idea of abnormal repeatability should be reflected, and the data of multiple suspension control points recorded by the driving recorder were be fused in terms of the screening results, so as to comprehensively judge the suspected irregularity of the section. On this basis, the proposed method was applied to analyze the data of 10 suspension control systems on the left side of M carriage on Changsha Maglev Line. Research results show that the proposed method can screen out suspected abnormal sections so that the existing whole-section irregularity detection method can be transformed into a method using track inspection equipment to detect suspected abnormal sections in a targeted manner. The maintenance time of line detection can reduce by about 20%.
-
图 4 M车1R控制点单程运行的实测数据
Figure 4. Detection data at 1R control points of vehicle M by one way
图 6 M车1R控制点悬浮间隙差的频数分布
Figure 6. Frequency distribution of suspension gap differences at 1R control points of vehicle M
图 8 原始数据、目标异常点及显著异常点对比
Figure 8. Comparison of original data, target outliers and significant outliers
表 1 统计分析结果
Table 1. Statistical analysis results
物理量 σ Cv S K 悬浮间隙/mm 0.575 0.064 0.169 3.981 垂向加速度/(m·s-2) 1.161 0.117 0.300 20.730 电流/A 4.720 0.138 0.274 3.020 
下载: 导出CSV
表 3 异常评价结果
Table 3. Outliers evaluation results
路段编号 一元阈值/个 二元阈值/组 三元阈值/组 等级 a i s s、i s、a a、i 63 12 2 1 2 1 1 1 Ⅰ 115 14 5 2 5 2 2 2 Ⅰ 64 11 4 5 1 1 2 0 Ⅱ 280 12 1 1 1 1 0 0 Ⅱ 288 12 1 4 0 3 1 0 Ⅱ 333 8 1 1 0 0 1 0 Ⅱ 60 4 0 1 0 0 0 0 Ⅲ 135 1 1 1 0 0 0 0 Ⅲ 48 7 0 0 0 0 0 0 69 0 0 0 0 0 0 0
下载: 导出CSV
表 4 M车左侧轨道数据处理结果
Table 4. Data processing results of left track of vehicle M
路段编号 Ⅰ级/次 Ⅱ级/次 Ⅲ级/次 共计/次 15 5 3 0 8 17 1 5 1 7 55 0 5 0 5 56 2 0 0 2 72 3 3 2 8 102 3 6 0 9 110 0 8 0 8 119 0 5 0 5 120 0 6 0 6 166 3 2 1 6 167 2 4 2 8 255 3 6 0 9 274 2 2 0 4 291 2 2 0 4 310 1 0 0 1 354 3 5 0 8
下载: 导出CSV
表 5 左侧轨道疑似不平顺路段
Table 5. Suspected irregularity sections of left track
路段编号 Ⅰ级贡献率 Ⅱ级贡献率 Ⅲ级贡献率 总计占比 等级 15 0.5 0.3 0.0 0.8 Y 72 0.3 0.3 0.2 0.8 Y 102 0.3 0.6 0.0 0.9 Y 167 0.2 0.4 0.2 0.8 Y 255 0.3 0.6 0.0 0.9 Y 354 0.3 0.5 0.0 0.8 Y 17 0.1 0.5 0.1 0.7 C 110 0.0 0.8 0.0 0.8 C 119 0.0 0.5 0.0 0.5 C 120 0.0 0.6 0.0 0.6 C 166 0.3 0.2 0.1 0.6 C
下载: 导出CSV
-
[1] 高雄杰, 于龙, 陈唐龙. 基于中点弦测法的中低速磁浮轨道不平顺检测[J]. 铁道学报, 2020, 42(8): 116-122. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB202008016.htmGAO Xiong-jie, YU Long, CHEN Tang-long. Detection of medium and low speed maglev track irregularity based onMCO[J]. Journal of the China Railway Society, 2020, 42(8): 116-122. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB202008016.htm [2] 周文武, 吴峻, 李中秀, 等. 低速磁浮轨道几何参数测量系统[J]. 国防科技大学学报, 2013, 35(4): 51-55. doi: 10.3969/j.issn.1001-2486.2013.04.010ZHOU Wen-wu, WU Jun, LI Zhong-xiu, et al. A track geometry measurement system for low speed maglev [J]. Journal of National University of Defense Technology, 2013, 35(4): 51-55. (in Chinese) doi: 10.3969/j.issn.1001-2486.2013.04.010 [3] 杨铭, 林国斌, 毕晟. 中低速磁浮轨道不平顺检测算法及其仿真计算[J]. 城市轨道交通研究, 2018, 21(12): 101-105. https://www.cnki.com.cn/Article/CJFDTOTAL-GDJT201812029.htmYANG Ming, LIN Guo-bin, BI Sheng. Detection algorithm and simulation of the track irregularity for medium and low-speed maglev train[J]. Urban Mass Transit, 2018, 21(12): 101-105. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-GDJT201812029.htm [4] 余佩倡, 李杰, 周丹峰, 等. 磁浮轨道不平顺对悬浮系统影响的抑制方法[J]. 国防科技大学学报, 2016, 38(4): 191-198. https://www.cnki.com.cn/Article/CJFDTOTAL-GFKJ201604030.htmYU Pei-chang, LI Jie, ZHOU Dan-feng, et al. Method for suppressing influence of track irregularity to maglev suspension system[J]. Journal of National University of Defense Technology, 2016, 38(4): 191-198. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-GFKJ201604030.htm [5] 宗斌, 刘飞香, 张琨, 等. 中低速磁浮线路智能养护技术及装备[J]. 中国机械工程, 2021, 32(4): 407-411. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGJX202104004.htmZONG Bin, LIU Fei-xiang, ZHANG Kun, et al. Intelligent maintenance technology and equipment for medium-low speedmaglev lines[J]. China Mechanical Engineering, 2021, 32(4): 407-411. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZGJX202104004.htm [6] 吴峻, 周文武, 唐训发, 等. 自带动力中低速磁浮F轨轨道检测仪: 中国, ZL201721520973.3[P]. 2018-06-22. WU Jun, ZHOU Wen-wu, TANG Xun-fa, et al. Self-powered medium and low speed maglev F rail track detectors: China, ZL201721520973.3[P]. 2018-06-22. (in Chinese) [7] 胡立峰. 中低速磁悬浮F型轨道静态几何参数检测仪的研制[D]. 长沙: 中南大学, 2011.HU Li-feng. Development of static geometric parameters detector for medium and low speed magnetic levitation F-type track[D]. Changsha: Central South University, 2011. (in Chinese) [8] 周鹤, 罗华军, 吴志会. 中低速磁浮轨道检测装置研究[J]. 电力机车与城轨车辆, 2017, 40(5): 14-18. https://www.cnki.com.cn/Article/CJFDTOTAL-DJJI201705004.htmZHOU He, LUO Hua-jun, WU Zhi-hui. Research on track detection device for mid-low speed maglev transportation[J]. Electric Locomotives and Mass Transit Vehicles, 2017, 40(5): 14-18. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-DJJI201705004.htm [9] 朱震寰. 某中低速磁浮轨道巡检车动力学特性研究[J]. 铁道建筑技术, 2020(9): 17-21. https://www.cnki.com.cn/Article/CJFDTOTAL-TDJS202009004.htmZHU Zhen-huan. Study on dynamic characteristics of a medium and low speed maglev inspection vehicle[J]. Railway Construction Technology, 2020(9): 17-21. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TDJS202009004.htm [10] 高雄杰. 中低速磁浮F轨轨道不平顺检测及评估研究[D]. 成都: 西南交通大学, 2018.GAO Xiong-jie. Research on F-rail track irregularity detection and evaluation of medium and low speed maglev[D]. Chengdu: Southwest Jiaotong University, 2018. (in Chinese) [11] 张拥军, 陈勇, 陈夏平, 等. 磁悬浮轨道几何参数测量方法研究[J]. 中国测试, 2019, 45(3): 46-52. https://www.cnki.com.cn/Article/CJFDTOTAL-SYCS201903009.htmZHANG Yong-jun, CHEN Yong, CHEN Xia-ping, et al. Research on the measurement for the geometric parameters of the maglev railway[J]. China Measurement and Test, 2019, 45(3): 46-52. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-SYCS201903009.htm [12] 李宁睿. 中低速磁悬浮轨道检测装置的开发与研究[D]. 湘潭: 湘潭大学, 2017.LI Ning-rui. Development and research of detecting device for medium and low speed maglev rail[D]. Xiangtan: Xiangtan University, 2017. (in Chinese) [13] 李中秀, 吴峻, 张云洲, 等. 基于轨排特征的中低速磁浮轨道检测里程校正方法[J]. 铁道建筑, 2021, 61(4): 143-146. https://www.cnki.com.cn/Article/CJFDTOTAL-TDJZ202104032.htmLI Zhong-xiu, WU Jun, ZHANG Yun-zhou, et al. Mileage correction method based on track laying features for medium-low speed maglev track detection[J]. Railway Engineering, 2021, 61(4): 143-146. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TDJZ202104032.htm [14] 李新泉. 中低速磁浮轨检仪方案选型及参数动态优化研究[J]. 铁道标准设计, 2023, 67(4): 39-46. https://www.cnki.com.cn/Article/CJFDTOTAL-TDBS202304008.htmLI Xin-quan. Research on schemes selection and parameters dynamic optimization of medium-low speed maglev track detector[J]. Railway Standard Design, 2023, 67(4): 39-46. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TDBS202304008.htm [15] TANG Jun-yuan, WU Jun, HUANG Sheng-jun. On middle and low speed maglev track irregularity detection based on threshold filtering algorithm[C]//IEEE. 6th Data DrivenControl and Learning Systems Conference. New York: IEEE, 2017: 699-703. [16] 王昊天, 厉小润, 赵辽英. 基于箱型图与折点阈值边界的电缆分割方法[J]. 计算机应用与软件, 2021, 38(9): 244-249. https://www.cnki.com.cn/Article/CJFDTOTAL-JYRJ202109040.htmWANG Hao-tian, LI Xiao-run, ZHAO Liao-ying. Cable segmentation method based on box-plot and turning pointthreshold boundary[J]. Computer Applications and Software, 2021, 38(9): 244-249. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-JYRJ202109040.htm [17] 刘耀宗, 邓文熙, 龚朴. 低速磁浮列车单悬浮架机电控制建模及动力学特性研究[J]. 铁道学报, 2014, 36(9): 39-43. https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201409008.htmLIU Yao-zong, DENG Wen-xi, GONG Pu. Dynamics-control modeling and analysis for bogie of low-speed maglev train[J]. Journal of the China Railway Society, 2014, 36(9): 39-43. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TDXB201409008.htm [18] 马卫华, 罗世辉, 张敏, 等. 中低速磁浮车辆研究综述[J]. 交通运输工程学报, 2021, 21(1): 199-216. doi: 10.19818/j.cnki.1671-1637.2021.01.009MA Wei-hua, LUO Shi-hui, ZHANG Min, et al. Researchreview on medium and low speed maglev vehicle[J]. Journal of Traffic and Transportation Engineering, 2021, 21(1): 199-216. (in Chinese) doi: 10.19818/j.cnki.1671-1637.2021.01.009 [19] 敖建安, 魏高恒, 马卫华, 等. 轨道精度对中低速磁浮列车-轨排-桥梁动力作用影响[J]. 铁道科学与工程学报, 2020, 17(11): 2738-2747. https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD202011004.htmAO Jian-an, WEI Gao-heng, MA Wei-hua, et al. Influence of geometry accuracy of track structure on dynamic performance of the coupled medium-low speed maglev train-rail-bridge system[J]. Journal of Railway Science and Engineering, 2020, 17(11): 2738-2747. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-CSTD202011004.htm [20] ZHOU Wen-wu, WU Jun, LI Zhong-xiu, et al. Trackinspection device mounted on commercial train for urban maglev[C]//IEEE. Proceeding of the 11th World Congress on Intelligent Control and Automation. New York: IEEE, 2015: 3605-3611. [21] 王荣杰, 牛嘉洋, 李子赟, 等. 基于离群指数的数据异常点检测方法[J]. 数码设计, 2021(13): 91-99.WANG Rong-jie, NIU Jia-yang, LI Zi-yun, et al. Data outlier detection method based on outlier index[J]. Digital Inside, 2021(13): 91-99. (in Chinese) [22] 李锐, 沈雨奇, 蒋捷, 等. 公共地图服务中访问热点区域的时空规律挖掘[J]. 武汉大学学报(信息科学版), 2018, 43(9): 1408-1415. https://www.cnki.com.cn/Article/CJFDTOTAL-WHCH201809018.htmLI Rui, SHEN Yu-qi, JIANG Jie, et al. Temporal and spatial characteristics of hotspots in public map service[J]. Geomatics and Information Science of Wuhan University, 2018, 43(9): 1408-1415. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-WHCH201809018.htm [23] 谢志炜, 温锐刚, 孟安波, 等. 基于箱形图和隔离森林的施工人次数据处理与预测研究[J]. 工程管理学报, 2018, 32(5): 92-96. https://www.cnki.com.cn/Article/CJFDTOTAL-JCGL201805017.htmXIE Zhi-wei, WEN Rui-gang, MENG An-bo, et al. Data processing and forecast analysis of construction workers based on boxplot method and isolation forest[J]. Journal of Engineering Management, 2018, 32(5): 92-96. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-JCGL201805017.htm [24] 梁博渊, 高骏, 刘宏亮, 等. 基于振动特征估计的气体绝缘开关设备故障检测与定位[J]. 科学技术与工程, 2020, 20(31): 12836-12842. https://www.cnki.com.cn/Article/CJFDTOTAL-KXJS202031023.htmLIANG Bo-yuan, GAO Jun, LIU Hong-liang, et al. Fault detection and location of gas insulated switchgear based on vibration characteristic estimation[J]. Science Technology and Engineering, 2020, 20(31): 12836-12842. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-KXJS202031023.htm [25] 马明寅, 狄岚, 梁久祯. 基于图像校正和模板分割的纺织品瑕疵检测[J]. 南京大学学报(自然科学), 2021, 57(1): 29-41. https://www.cnki.com.cn/Article/CJFDTOTAL-NJDZ202101004.htmMA Ming-yin, DI Lan, LIANG Jiu-zhen. Fabric defect detection based on image correction and template segmentation[J]. Journal of Nanjing University (Natural Science), 2021, 57(1): 29-41. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-NJDZ202101004.htm [26] 王泽汉, 杨新斌. 中低速磁浮车辆S形曲线通过性能分析[J]. 铁道车辆, 2020, 58(11): 1-3. https://www.cnki.com.cn/Article/CJFDTOTAL-TDCL202011001.htmWANG Ze-han, YANG Xin-bin. Analysis of S-curve negotiation performance of medium and low speed maglev vehicles[J]. Rolling Stock, 2020, 58(11): 1-3. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TDCL202011001.htm [27] 吴泽泰, 蔡仁钦, 徐书燕, 等. 基于K近邻法的WiFi定位研究与改进[J]. 计算机工程, 2017, 43(3): 289-293. https://www.cnki.com.cn/Article/CJFDTOTAL-JSJC201703048.htmWU Ze-tai, CAI Ren-qin, XU Shu-yan, et al. Research and improvement of WiFi positioning based on K nearest neighbor method[J]. Computer Engineering, 2017, 43 (3): 289- 293. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-JSJC201703048.htm [28] 王强. 基于神经网络逼近的磁浮列车动态悬浮控制[J]. 科学技术与工程, 2021, 21(28): 12117-12123. https://www.cnki.com.cn/Article/CJFDTOTAL-KXJS202128026.htmWANG Qiang. Dynamic levitation control of maglev train based on neural network approximation[J]. Science Technology and Engineering, 2021, 21(28): 12117-12123. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-KXJS202128026.htm [29] 李伟强, 冯洋, 赵春发. 桥梁竖向变形引起的中低速磁浮轨道不平顺分析[J]. 铁道标准设计, 2021, 65(6): 77-82. https://www.cnki.com.cn/Article/CJFDTOTAL-TDBS202106016.htmLI Wei-qiang, FENG Yang, ZHAO Chun-fa. Analysis on track irregularities of medium-low speed maglev transit induced by bridge deformation[J]. Railway Standard Design, 2021, 65(6): 77-82. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TDBS202106016.htm [30] 梁潇, 向湘林, 彭也也, 等. 中低速磁浮车辆与U型梁耦合振动响应[J]. 同济大学学报(自然科学版), 2021, 49(12): 1678-1687. https://www.cnki.com.cn/Article/CJFDTOTAL-TJDZ202112005.htmLIANG Xiao, XIANG Xiang-lin, PENG Ye-ye, et al. Coupled vibration response of vehicle-U-type girder system formedium-low speed maglev[J]. Journal of Tongji University (Natural Science), 2021, 49(12): 1678-1687. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TJDZ202112005.htm [31] 龙志强, 郝阿明, 常文森. 考虑轨道周期性不平顺的磁浮列车悬浮控制系统设计[J]. 国防科技大学学报, 2003, 25(2): 84-89. https://www.cnki.com.cn/Article/CJFDTOTAL-GFKJ200302020.htmLONG Zhi-qiang, HAO A-ming, CHANG Wen-sen. Suspension controller design of maglev train considering therail track periodical irregularity[J]. Journal of National University of Defense Technology, 2003, 25(2): 84-89. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-GFKJ200302020.htm -
点击查看大图
图(8) / 表(5)
计量
- 文章访问数: 530
- HTML全文浏览量: 240
- PDF下载量: 59
- 被引次数: 0
