Volume 12 Issue 6
. 
Turn off MathJax
Article Contents
Article Navigation >  Journal of Traffic and Transportation Engineering  > 2012  >  12(6): 41-47
WU Bing, WEN Ze-feng, WANG Heng-yu, JIN Xue-song. Numerical analysis method of wheel/rail adhesion under water lubrication for high-speed railway[J]. Journal of Traffic and Transportation Engineering, 2012, 12(6): 41-47. doi: 10.19818/j.cnki.1671-1637.2012.06.007
Citation: WU Bing, WEN Ze-feng, WANG Heng-yu, JIN Xue-song. Numerical analysis method of wheel/rail adhesion under water lubrication for high-speed railway[J]. Journal of Traffic and Transportation Engineering, 2012, 12(6): 41-47. doi: 10.19818/j.cnki.1671-1637.2012.06.007
shu

Numerical analysis method of wheel/rail adhesion under water lubrication for high-speed railway

doi: 10.19818/j.cnki.1671-1637.2012.06.007

  • State Key Laboratory of Traction Power, Southwest Jiaotong University, Chengdu 610031, Sichuan, China

More Information
  • Author Bio:

    WU Bing(1987-), male, doctoral student, +86-28-86466051, jiaoda-wubing@163.com

    JIN Xue-son g(1956-), male, professor, PhD, +86-28-87634355, xsjin@home.swjtu.edu.cn

  • Received Date: 2012-07-21
  • Publish Date: 2012-12-25
    Abstract
  • Multigrid method was introduced into the calculation of wheel/rail adhesion under wet condition at high speed, and the influence of train speed and contact pressure on water film thickness was investigated under wet condition without thinking about surface roughness. Numerical analysis result shows that surface roughness and water film thickness have same order, and surface roughness is not ignored. Partial lubrication theory was applied to study the contact characteristics of wheel and rail under water lubrication based on the numerical analysis result, and the relationship between train speed and adhesion coefficient was investigated. Computation result indicates that with the increase of train speed, adhesion coefficient decreases rapidly, and its values are below 0.1. The comparison of experimental result obtained by JD-1 testing machine at the simulation speeds of 60, 90 and 120 km·h-1 and numerical analysis result shows that the maximum relative error of adhesion coefficient is less than 8%, so the numerical analysis method is accurate to estimate adhesion coefficient.

     

    • FullText(HTML)
  • loading
    • References(22)
  • [1]
    沈志云, 张卫华, 金学松, 等. 轮轨接触力学研究的最新进展[J]. 中国铁道科学, 2001, 22(2): 1-14. doi: 10.3321/j.issn:1001-4632.2001.02.001

    SHEN Zhi-yun, ZHANG Wei-hua, JIN Xue-song, et al. Advances in wheel/rail contact mechanics[J]. China Railway Science, 2001, 22(2): 1-14. (in Chinese). doi: 10.3321/j.issn:1001-4632.2001.02.001
    [2]
    OHYAMA T. Tribological studies on adhesion phenomena between wheel and rail at high speeds[J]. Wear, 1991, 144(1/2): 263-275.
    [3]
    大山忠夫. 高速域におけゐ車輪/レ一ル間の粘着力に及ぼす表面污染の影響(第2報)——接觸領域におけゐ摩擦系數と接觸剛性が粘着力に及ぼす影響[J]. 潤滑, 1987, 33(7): 548-554.

    TADAO O. Influence of surface contamination on adhesion force between wheel and rail at high speeds(2nd report)—effects of friction coefficients and tangential contact rigidity on adhesion force[J]. Japan Society of Lubrication Engineers, 1987, 33(7): 548-554.
    [4]
    大山忠夫, 大野薰, 中野敏. 高速域におけゐ車輪/レ一ル間の粘着力に及ぼす表面污染の影響(第1報)——微量油付着狀態におけゐ粘着力の舉動[J]. 潤滑, 1987, 33(7): 540-547.

    TADAO O, KAORU O, SATOSHI N. Influence of surface contamination on adhesion force between wheel and rail at high speeds(1st report)—behavior of adhesion force under the surfaces contaminated with a small amount of liquid paraffin[J]. Japan Society of Lubrication Engineers, 1987, 33(7): 540-547.
    [5]
    CHEN H, BAN T, ISHIDA M, et al. Experimental investigation of influential factors on adhesion between wheel and rail under wet conditions[J]. Wear, 2008, 265(9/10): 15041511.
    [6]
    KUMAR S, 钱立新. 轮轨接触参数的实验室模拟及轮轨冲角、蛇形运动、油水污染、真实接触面积对黏着蠕滑性能的影响[J]. 中国铁道科学, 1984, 5(1): 12-35. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK198401001.htm

    KUMAR S, QIAN Li-xin. Laboratory simulation of wheel and rail contact related parameters and influence of contact area, angel of attack, kinematic oscillation and water, oil contamination on wheel and rail adhesion[J]. China Railway Science, 1984, 5(1): 12-35. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK198401001.htm
    [7]
    ARIAS-CUEVAS O. Low adhesion in the wheel-rail contact[D]. Delft: Delft University, 2010.
    [8]
    WANG W J, ZHANG H F, WANG H Y, et al. Study on the adhesion behavior of wheel/rail under oil, water and sanding conditions[J]. Wear, 2011, 271(9/10): 2693-2698.
    [9]
    大山忠夫, 中野敏. 高速域におけゐ車輪/レ一ル間の粘着力に及ぼす表面污染の影響(第3報)——潤滑油膜が形成された場合の粘着力の舉動[J]. 潤滑, 1987, 33(10): 751-758.

    TADAO O, SATOSHI N. Influence of surface contamination on adhesion force between wheel and rail at high speeds(3rd report)—behavior of adhesion force under the formation of lubricant film[J]. Japan Society of Lubrication Engineers, 1987, 33(10): 751-758.
    [10]
    CHEN H, BAN T, ISHIDA M, et al. Adhesion between rail/wheel under water lubricated contact[J]. Wear, 2002, 253(1/2): 75-81.
    [11]
    CHEN H, ISHIDA M, NAKAHARA T. Analysis of adhesion under wet conditions for three-dimensional contact considering surface roughness[J]. Wear, 2005, 258(7/8): 1209-1216.
    [12]
    杨翊仁, 张继业, 金学松. 轮轨水介质接触的完全数值分析方法[J]. 铁道学报, 1998, 20(4): 31-36. doi: 10.3321/j.issn:1001-8360.1998.04.006

    YANG Yi-ren, ZHANG Ji-ye, JIN Xue-song. Numerical analysis on the contact of wheel and rail with water medium[J]. Journal of the China Railway Society, 1998, 20(4): 31-36. (in Chinese). doi: 10.3321/j.issn:1001-8360.1998.04.006
    [13]
    杨翊仁, 张继业, 赵华. 水介质对轮轨黏着特性的影响[J]. 铁道学报, 2000, 22(2): 31-34. doi: 10.3321/j.issn:1001-8360.2000.02.007

    YANG Yi-ren, ZHANG Ji-ye, ZHAO Hua. Effects of water medium on adhesion of wheel and rail[J]. Journal of the China Railway Society, 2000, 22(2): 31-34. (in Chinese). doi: 10.3321/j.issn:1001-8360.2000.02.007
    [14]
    裴有福. 高速铁路轮轨粘着机理的研究[D]. 北京: 清华大学, 1996.

    PEI You-fu. An investigation into the mechanisms of wheel/rail adhesion[D]. Beijing: Tsinghua University, 1996. (in Chinese).
    [15]
    VENNER C H, NAPEL W E, BOSMA R. Advanced multi-level solution of the EHL line contact problem[J]. Journal of Tribology, 1990, 112(3): 426-432. doi: 10.1115/1.2920277
    [16]
    黄平, 温诗铸. 多重网格法求解线接触弹流问题[J]. 清华大学学报: 自然科学版, 1992, 32(5): 26-34. doi: 10.3321/j.issn:1000-0054.1992.05.001

    HUANG Ping, WEN Shi-zhu. Solution of the elastohydrody-namic lubrication line contact problems with multigrid method[J]. Journal of Tsinghua University: Science and Technology, 1992, 32(5): 26-34. (in Chinese). doi: 10.3321/j.issn:1000-0054.1992.05.001
    [17]
    杨沛然. 流体动力润滑数值分析[M]. 北京: 国防工业出版社, 1999.

    YANG Pei-ran. Numerical Analysis of Hydrodynamic Lubrication[M]. Beijing: National Defence Industry Press, 1999. (in Chinese).
    [18]
    陈国定. 重载、部分弹性流体动力润滑研究[D]. 西安: 西安交通大学, 1988.

    CHEN Guo-ding. Study on heavy load and partial elasto-hydrodynamic lubrication[D]. Xi'an: Xi'an Jiaotong University, 1988. (in Chinese).
    [19]
    PATIR N, CHENG H S. Application of average flow model to lubrication between rough sliding surfaces[J]. Journal of Lubrication Technology, 1979, 101(2): 220-229. doi: 10.1115/1.3453329
    [20]
    PATIR N, CHENG H S. An average flow model for deter-mining effects of three-dimensional roughness on partial hydrodynamic lubrication[J]. Journal of Lubrication Technology, 1978, 100(1): 12-17. doi: 10.1115/1.3453103
    [21]
    GREENWOOD J A, TRIPP J H. The contact of two nomi-nally flat rough surfaces[J]. Proceedings of the Institution of Mechanical Engineering, 1971, 185(1): 625-633.
    [22]
    金学松, 刘启跃. 轮轨摩擦学[M]. 北京: 中国铁道出版社, 2004.

    JIN Xue-song, LIU Qi-yue. Tribology of Wheel and Rail[M]. Beijing: China Railway Publishing House, 2004. (in Chinese).
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF
    XML

    Article Metrics

    Article views (624) PDF downloads(770) Cited by()
    Proportional views
    Related

    Copyright《Journal of Traffic and Transportation Engineering》编辑部陕ICP备05001904号-1

    Address ：Editorial Department of Journal of Traffic and Transportation Engineering, Chang 'an University, Middle Section of South Second Ring Road, Xi 'an, Shaanxi（710064） Tel：029-82334388 Email：jygc@chd.edu.cn

    All visit:Today's visit:

    Supported by: Beijing Renhe Information Technology Co. Ltd    

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return