Structure parameter influence of slab track for high speed railway on wheel-rail noise
-
摘要: 为了降低轮轨噪声, 利用轮轨噪声预测模型与软件STTIN (Simulation of Train/Track In-teraction and Noise), 分析了板式轨道结构参数对轮轨噪声的影响。发现以下规律: 轨下胶垫刚度大于200 MN.m-1时, 轮轨噪声水平显著上升; 当轨下胶垫阻尼值偏离100 kN.s.m-1时, 噪声将增大; 改变板下支承刚度, 轮轨噪声基本不变化; 增加轨道板质量, 轮轨噪声降低。结果表明, 轨下胶垫的刚度与阻尼是影响轮轨噪声的主要因素, 而轨道板质量次之, 轨道板下支承刚度对轮轨噪声基本无影响。Abstract: In order to decrease wheel-rail noise, wheel-rail noise predicting model and STTIN software were put forward, the structure parameter influence of slab track on wheel-rail noise was analyzed.It is pointed that wheel-rail noise rises while the stiffness of rail pad is higher than 200 MN·m-1, and the damping of rail pad drifts off the value of 100 kN·s·m-1, wheel-rail noise is almost indeclinable when modifying the stiffness of slab pad, but it decreases when increasing the mass of slab.The result shows that the stiffness and damping of rail pad are the key factors influencing wheel-rail noise, the mass of slab is the secondary factor, and the stiffness of slab pad primarily has no influence on wheel-rail noise.
-
Key words:
- railway engineering /
- high speed railway /
- slab track /
- structure parameters /
- wheel-rail noise
-
表 1 钢轨近旁等效声级
Table 1. Equal sound level near rail
dBA 板下单位长度支承刚度 车轮声级 钢轨声级 轨道板声级 总和声级 376.6 MN·m-1 100.81 107.03 96.16 108.24 5 714.4 MN·m-1 100.79 107.14 97.51 108.41 
下载: 导出CSV
表 2 桥面下方0.3 m处近旁等效声级
Table 2. Equal sound level below 0.3 m of bridge surface
dBA 板下单位长度支承刚度 车轮声级 钢轨声级 轨道板声级 总和声级 376.6 MN·m-1 75.37 84.26 76.00 85.33 5 714.4 MN·m-1 75.35 84.39 75.39 85.36
下载: 导出CSV
表 3 钢轨近旁等效声级
Table 3. Equal sound level near rail
dBA 轨道板质量 车轮声级 钢轨声级 轨道板声级 总和声级 477 kg·m-1 102.77 109.03 101.24 110.50 954 kg·m-1 102.90 108.72 94.76 109.87
下载: 导出CSV
-
[1] Remington P J. Wheel/rail rolling noise I: theoretical analysis[J]. Journal of Sound and Vibration, 1987, 81(6): 1 805-1 823. [2] Thompson D J. Wheel-rail noise generation, part I: introduction and interaction model[J]. Journal of Sound and Vibration, 1993, 161(3): 387-400. doi: 10.1006/jsvi.1993.1082 [3] 翟婉明. 铁路轮轨高频随机振动理论解析[J]. 机械工程学报, 1997, 33(2): 20-25. https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB702.003.htmZhai Wan-ming. Theoretical analysis for high frequency random vibration of wheel/rail system[J]. Chinese Journal of Mechanical Engineering, 1997, 33(2): 20-25. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-JXXB702.003.htm [4] 徐志胜. 轨道交通轮轨噪声预测与控制研究[D]. 成都: 西南交通大学, 2004. [5] 徐志胜, 翟婉明. 轨道交通轮轨噪声预测模型[J]. 交通运输工程学报, 2005, 5(3): 14-19. doi: 10.3321/j.issn:1671-1637.2005.03.004Xu Zhi-sheng, Zhai Wan-ming. Prediction model of wheel/rail noise for rail transit[J]. Journal of Traffic and Transportation Engineering, 2005, 5(3): 14-19. (in Chinese) doi: 10.3321/j.issn:1671-1637.2005.03.004 [6] 徐志胜, 翟婉明, 蔡成标, 等. 高速列车在板式轨道上运行时的滚动噪声预测[J]. 铁道学报, 2004, 26(4): 46-50. doi: 10.3321/j.issn:1001-8360.2004.04.010Xu Zhi-sheng, Zhai Wan-ming, Cai Cheng-biao, et al. Prediction of wheel/rail rolling noise when a high-speed train runs on a slab track[J]. Journal of the China Railway Society, 2004, 26(4): 46-50. (in Chinese) doi: 10.3321/j.issn:1001-8360.2004.04.010 [7] Ando K, Horiike T, Hansaka M, et al. Present status on slab track and environmental countermeasure[J]. QR of RTRI, 1996, 37(4): 204-209. [8] Ando K, Sunaga M. Development of slab tracks for hokuriku shinkansen line[J]. QR of RTRI, 2001, 42(1): 35-41. doi: 10.2219/rtriqr.42.35 [9] 徐志胜, 翟婉明, 王其昌. 轨道刚度对高速轮轨系统振动噪声的影响[J]. 噪声与振动控制, 2004, 24(4): 15-19. https://www.cnki.com.cn/Article/CJFDTOTAL-ZSZK200404005.htmXu Zhi-sheng, Zhai Wan-ming, Wang Qi-chang. Influence of track stiffness on vibration and noise of high-speed wheel/rail system[J]. Noise and Vibration Control, 2004, 24(4): 15-19. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZSZK200404005.htm -
点击查看大图
图(3) / 表(3)
计量
- 文章访问数: 246
- HTML全文浏览量: 87
- PDF下载量: 280
- 被引次数: 0
