-
摘要: 为了研究转向架的空气阻力特性, 建立了列车空气动力学模型。基于三维定常可压缩N-S方程和k-ε两方程湍流模型, 采用有限体积法对速度为400 km.h-1的高速列车空气动力学性能进行了数值模拟, 分析了车底结构对转向架气动力的影响。研究结果表明: 转向架区域的流场结构非常复杂, 转向架前后都会有漩涡形成; 高速列车各转向架所受气动阻力差别很大, 无侧风条件下, 头车一位端转向架阻力是第4转向架阻力的4倍以上; 转向架气动阻力占列车总阻力的20%以上, 在侧风作用下占40%以上; 不同车体底部形状使转向架阻力最大相差30%以上; 适当改进列车底部结构, 有利于减少转向架的气动阻力, 进而减小列车运行气动阻力。Abstract: To study the aerodynamic drag properties of high-speed train bogies, an aerodynamics model of train was built.Based on 3D steady compressible N-S equation and turbulent model of k-ε two equations, the aerodynamics properties of high-speed train running at 400 km·h-1 were numerically simulated by using finite volume method.The influence of train bottom shapes on bogie's aerodynamic drag was analyzed.Analysis result shows that the flow field structure of bogie region is very complex.Vortices emerge on both the forward and backward bogies.The aerodynamic drags of bogies are different.Under crosswind-free condition, the aerodynamic drag of the first bogie is more than 4 times of the fourth bogie.The aerodynamic drag of bogie takes up more than 20% of whole train aerodynamic drag, and it is more than 40% under crosswind.The maximum differences of bogie aerodynamic drags are more than 30% due to the different shapes of train bottom.The aerodynamic drags of bogies and whole train reduce due to changing train bottom shape appropriately.
-
Key words:
- high-speed train /
- bogie /
- finite volume method /
- aerodynamic drag /
- train aerodynamics /
- flow field structure
-
表 1 无侧风条件下气动力对比
Table 1. Comparison of aerodynamic forces under crosswind-free condition
N 
表 2 侧风条件下气动力对比
Table 2. Comparison of aerodynamic forces under crosswind condition
N 
-
[1] RAGHUNATHAN RS, KIM H D, SETOGUCHI T. Aerodynamics of high-speed railway train[J]. Progress in Aerospace Sciences, 2002, 38(6/7): 469-514. [2] 李雪冰, 张继业, 张卫华. 高速列车交会时气流诱发振动的仿真研究[J]. 铁道车辆, 2009, 47(12): 9-12. doi: 10.3969/j.issn.1002-7602.2009.12.003LI Xue-bing, ZHANG Ji-ye, ZHANG Wei-hua. Simulation research on vibration caused by airflow while high speed trains passing each other[J]. Rolling Stock, 2009, 47(12): 9-12. (in Chinese) doi: 10.3969/j.issn.1002-7602.2009.12.003 [3] KHIER W, BREUER M, DURST F. Flow structure around trains under side wind condition: a numerical study[J]. Computers and Fluids, 2000, 29(2): 179-195. doi: 10.1016/S0045-7930(99)00008-0 [4] 谭深根, 李雪冰, 张继业, 等. 路堤上运行的高速列车在侧风下的流场结构及气动性能[J]. 铁道车辆, 2008, 46(8): 4-8. doi: 10.3969/j.issn.1002-7602.2008.08.002TAN Shen-gen, LI Xue-bing, ZHANG Ji-ye, et al. The flow field structure and the aerodynamic performance of high speed trains running on embankment under cross wind[J]. Rolling Stock, 2008, 46(8): 4-8. (in Chinese) doi: 10.3969/j.issn.1002-7602.2008.08.002 [5] 苗秀娟, 田红旗, 高广军. 峡谷风对桥梁上列车气动性能的影响[J]. 中国铁道科学, 2010, 31(6): 63-67. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK201006012.htmMIAO Xiu-juan, TIAN Hong-qi, GAO Guang-jun. The influence of the gorge wind on the aerodynamic performance of the train on bridge[J]. China Railway Science, 2010, 31(6): 63-67. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK201006012.htm [6] 郗艳红, 毛军, 李明高, 等. 高速列车侧风效应的数值模拟[J]. 北京交通大学学报, 2010, 34(1): 14-19. doi: 10.3969/j.issn.1673-0291.2010.01.004XI Yan-hong, MAO Jun, LI Ming-gao, et al. Numerical study on the crosswind effects of high-speed train[J]. Journal of Beijing Jiaotong University, 2010, 34(1): 14-19. (in Chinese) doi: 10.3969/j.issn.1673-0291.2010.01.004 [7] 李雪冰, 杨征, 张继业, 等. 强风中高速列车空气动力学性能[J]. 交通运输工程学报, 2009, 9(2): 66-73. doi: 10.3321/j.issn:1671-1637.2009.02.012LI Xue-bing, YANG Zheng, ZHANG Ji-ye, et al. Aerodynamics properties of high-speed train in strong wind[J]. Journal of Traffic and Transportation Engineering, 2009, 9(2): 66-73. (in Chinese) doi: 10.3321/j.issn:1671-1637.2009.02.012 [8] 陈南翼, 张健. 高速列车空气阻力的研究[J]. 中国铁路, 1998(2): 43-47. https://www.cnki.com.cn/Article/CJFDTOTAL-TLZG199802014.htmCHEN Nan-yi, ZHANG Jian. The study of aerodynamic drag of high-speed train[J]. Chinese Raiways, 1998(2): 43-47. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TLZG199802014.htm [9] 田红旗, 高广军. 270 km·h-1高速列车气动性能研究[J]. 中国铁道科学, 2003, 24(2): 14-18. doi: 10.3321/j.issn:1001-4632.2003.02.003TIAN Hong-qi, GAO Guang-jun. The analysis and evaluation on the aerodynamic behavior of 270 km·h-1 high-speed train[J]. China Railway Science, 2003, 24(2): 14-18. (in Chinese) doi: 10.3321/j.issn:1001-4632.2003.02.003 [10] 杨志刚, 高喆, 陈羽, 等. 裙板安装对高速列车气动性能影响的数值分析[J]. 计算机辅助工程, 2010, 19(3): 16-21. doi: 10.3969/j.issn.1006-0871.2010.03.004YANG Zhi-gang, GAO Zhe, CHEN Yu, et al. Numerical analysis on influence on aerodynamic performance of high-speed train caused by installation of skirt plates[J]. Computer Aided Engineering, 2010, 19(3): 16-21. (in Chinese) doi: 10.3969/j.issn.1006-0871.2010.03.004 [11] SCHULTE-WERNING B. Research of European railway operators to reduce the environmental impact of high-speed trains[J]. Proceedings of the Institution of Mechanical Engineers, Part F: Journal of Rail and Rapid Transit, 2003, 217(4): 249-257. doi: 10.1243/095440903322712856 [12] 田红旗, 周丹, 许平. 列车空气动力学性能与流线型头部外形[J]. 中国铁道科学, 2006, 27(3): 47-55. doi: 10.3321/j.issn:1001-4632.2006.03.009TIAN Hong-qi, ZHOU Dan, XU Ping. Aerodynamic performance and streamlined head shape of train[J]. China Railway Science, 2006, 27(3): 47-55. (in Chinese) doi: 10.3321/j.issn:1001-4632.2006.03.009 [13] 张经强, 梁习锋. 高速列车外形的气动性能数值计算和头部外形的改进[J]. 计算力学学报, 2003, 20(5): 631-635. doi: 10.3969/j.issn.1007-4708.2003.05.024ZHANG Jing-qiang, LIANG Xi-feng. Numerical calculation of aerodynamic characteristics and improvement for head shape of high speed trains[J]. Chinese Journal of Computational Mechanics, 2003, 20(5): 631-635. (in Chinese) doi: 10.3969/j.issn.1007-4708.2003.05.024 [14] 田红旗. 风环境下的列车空气阻力特性研究[J]. 中国铁道科学, 2008, 29(5): 108-112. doi: 10.3321/j.issn:1001-4632.2008.05.020TIAN Hong-qi. Study on the characteristics of train air resistance under wind environment[J]. China Railway Science, 2008, 29(5): 108-112. (in Chinese) doi: 10.3321/j.issn:1001-4632.2008.05.020 [15] 梁习锋, 田红旗. 200 km·h-1动车组交会空气压力波试验[J]. 中南工业大学学报: 自然科学版, 2002, 33(6): 621-624. https://www.cnki.com.cn/Article/CJFDTOTAL-TYJY202201005.htmLIANG Xi-feng, TIAN Hong-qi. Test research on crossing air pressure pulse of 200 km·h-1 electric multiple unit[J]. Journal of Central South University of Technology: Natural Science, 2002, 33(6): 621-624. (in Chinese) https://www.cnki.com.cn/Article/CJFDTOTAL-TYJY202201005.htm [16] 万晓艳, 吴剑. 时速200 km动车组通过隧道时空气动力学效应现场试验与研究[J]. 现代隧道技术, 2006, 43(1): 43-48. doi: 10.3969/j.issn.1009-6582.2006.01.008WAN Xiao-yan, WU Jian. In-situ test and study on the aerodynamic effect of the rolling stock passing through tunnels with a speed of 200 km·h-1[J]. Modern Tunnelling Technology, 2006, 43(1): 43-48. (in Chinese) doi: 10.3969/j.issn.1009-6582.2006.01.008 -
下载:
点击查看大图
图(10) / 表(2)
计量
- 文章访问数: 1094
- HTML全文浏览量: 322
- PDF下载量: 634
- 被引次数: 0
