Micro-crack propagation behavior of pavement concrete subjected to coupling effect of fatigue load and freezing-thawing cycles
-
摘要: 为了定量表征与分析在疲劳荷载和冻融循环耦合作用下路面混凝土内部裂缝的演化规律, 采用SEM与形态学图像分割法对不同疲劳荷载和冻融循环耦合阶段的混凝土微裂缝进行提取, 采用Image-Pro Plus对微裂缝进行量化, 采用灰色关联法研究了裂缝特征参数与耦合作用后路面混凝土弯拉强度损失的相关性。分析结果表明: 路面混凝土内部存在平均宽度为13μm、最大长度为144μm的原始微裂缝, 耦合作用下裂缝的演化沿长度方向为延伸和断裂交替变化, 沿宽度方向为扩张和收缩交替变化, 混凝土破坏时裂缝最大长度达到352.64μm, 裂缝平均宽度达到15.4μm; 当冻融循环150次时, 裂缝面积密度显著增大, 与原始微裂缝相比, 混凝土破坏时裂缝面积密度增大了6.7倍; 耦合作用下路面混凝土裂缝分形维数、平均宽度、最大长度与弯拉强度的相关性较高, 灰色关联度分别为0.957、0.954、0.871;通过回归分析建立了路面混凝土弯拉强度损失与裂缝结构参数之间的方程, 弯拉强度损失与裂缝分形维数、平均宽度、最大长度之间存在较好的线性相关性, 相关系数达到0.97。Abstract: In order to quantitatively characterize and analyze the evolution laws of pavement concrete internal cracks under the coupling effect of fatigue load and freezing-thawing cycles, the SEM and the morphological image segmentation method were used to extract the micro-crack patterns, the Image-Pro Plus was used to quantify the micro-crack structure, and the relationship between the crack parameters and the loss of flexural strength under the coupling effect was studied by using the grey correlation analysis method.Analysis result shows that there are original micro-cracks in pavement concrete, the average width is 13 μm, and the maximum length is 144 μm.Under the coupling effect, the evolution of pavement concrete cracks along the length direction is the alternative process of extension and fracture, while the crack evolution along thewidth direction is the alternative process of expansion and contraction.When the concrete is destroyed, the maximum length of crack reaches 352.64 μm, and the average width of crack reaches 15.4 μm.After 150 times freezing-thawing cycles, the crack area density increases significantly, and is 6.7 times larger than the density of original micro crack when concrete is destroyed.The flexural strength of pavement concrete is greatly related to the fractal dimension, average width and maximum length of the crack under the coupling effect, and the grey correlation coefficients are 0.957, 0.954 and 0.871 respectively.Based on the regression analysis, the equation between the flexural strength loss and crack structural parameters of pavement concrete is established, there is good linear correlation between the flexural strength loss and the fractal dimension, average width, maximum length of crack, and the correlation coefficients reach 0.97.
-
Key words:
- pavement material /
- cement concrete /
- crack structure /
- propagation rule /
- fatigue load /
- freezing-thawing cycle /
- coupling effect
-
图 5 位置A处分割前后SEM图像对比
Figure 5. SEM image comparison before and after segment at location A
图 6 位置B处分割前后SEM图像对比
Figure 6. SEM image comparison before and after segment at location B
图 7 位置C处分割前后SEM图像对比
Figure 7. SEM image comparison before and after segment at location C
表 4 弯拉强度与裂缝特征参数的灰相关度
Table 4. Grey relational degrees of flexural strengths and crack character parameters
下载: 导出CSV
-
[1] 申爱琴. 水泥与水泥混凝土[M]. 北京: 人民交通出版社, 2004.SHEN Ai-qin. Cement and Concrete[M]. Beijing: China Communications Press, 2004. (in Chinese). [2] 孙振平, 蒋正武, 王培铭, 等. 水泥混凝土路面裂缝成因及预防措施[J]. 公路交通科技, 2005, 22(4): 15-19. doi: 10.3969/j.issn.1002-0268.2005.04.005SUN Zhen-ping, JIANG Zheng-wu, WANG Pei-ming, et al. Reasons and avoiding methods of cracking in cement concrete pavements[J]. Journal of Highway and Transportation Research and Development, 2005, 22(4): 15-19. (in Chinese). doi: 10.3969/j.issn.1002-0268.2005.04.005 [3] BAŽANT Z P, TABBARA M R, KAZEMI M T, et al. Random particle models for fracture of aggregate or fiber composites[J]. Journal of Engineering Mechanics, 1990, 116(8): 1686-1705. doi: 10.1061/(ASCE)0733-9399(1990)116:8(1686) [4] RU Zhong-liang, ZHAO Hong-bo, ZHU Chuan-rui. Crack propagation analysis of concrete beam subjected to three-point bending using XFEM[J]. Applied Mechanics and Materials, 2011, 94-96: 1665-1658. [5] SOROUSHIAN P, ELZAFRANEY M. Damage effects on concrete performance and microstructure[J]. Cement and Concrete Composites, 2004, 26(7): 853-859. doi: 10.1016/j.cemconcomp.2003.05.001 [6] LITOROWICZ A. Identification and quantification of cracks in concrete by optical fluorescent microscopy[J]. Cement and Concrete Research, 2006, 36(8): 1508-1515. doi: 10.1016/j.cemconres.2006.05.011 [7] SHIH M H, SUNG W P. Application of digital image correlation method for analyzing crack variation of reinforced concrete beams[J]. Sadhana-Academy Proceedings in Engineering Science, 2013, 38(4): 723-741. [8] 李曙光, 陈改新, 鲁一晖. 基于微裂缝定量分析的混凝土冻融损伤评价方法[J]. 水利水电学报, 2013, 32(3): 207-212. https://www.cnki.com.cn/Article/CJFDTOTAL-SFXB201303036.htmLI Shu-guang, CHEN Gai-xin, LU Yi-hui. Evaluation method for freezing-thawing damage in concrete based on quantitative micro-crack analysis[J]. Journal of Hydroelectric Engineering, 2013, 32(3): 207-212. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-SFXB201303036.htm [9] 李曙光, 陈改新, 纪国晋, 等. 基于DIP技术的高强度混凝土初始微裂纹定量分析[J]. 混凝土, 2013(5): 6-12. doi: 10.3969/j.issn.1002-3550.2013.05.002LI Shu-guang, CHEN Gai-xin, JI Guo-jin, et al. Quantitative analysis of initial micro-creak in high strength concrete by DIP technique[J]. Concrete, 2013(5): 6-12. (in Chinese). doi: 10.3969/j.issn.1002-3550.2013.05.002 [10] LI Wen-ting, SUN Wei, JIANG Jin-yang. Damage of concrete experiencing flexural fatigue load and closed freeze/thaw cycles simultaneously[J]. Construction and Building Materials, 2011, 25(5): 2604-2610. doi: 10.1016/j.conbuildmat.2010.12.007 [11] YANG Li-ming, ZENG Xiang-chao, YU Hong-fa. Study on crack density of concrete exposed to stress corrosion[J]. Construction and Building Material, 2015, 82(1): 264-273. [12] 宋玉普, 王怀亮, 贾金青. 混凝土的多轴疲劳性能[J]. 建筑结构学报, 2008(增): 260-265. https://www.cnki.com.cn/Article/CJFDTOTAL-JZJB2008S1055.htmSONG Yu-pu, WANG Huai-liang, JIA Jin-qing. Behavior of concrete under multi-axial fatigue loading[J]. Journal of Building Structures, 2008(S): 260-265. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JZJB2008S1055.htm [13] GOEL S, SINGH S P, SINGH P. Flexural fatigue strength and failure probability of self compacting fibre reinforced concrete beams[J]. Engineering Structures, 2012, 40: 131-140. doi: 10.1016/j.engstruct.2012.02.035 [14] 杨晖, 张继武. 数学形态学在图像边缘检测中的应用研究[J]. 辽宁大学学报: 自然科学版, 2005, 32(1): 50-53. doi: 10.3969/j.issn.1000-5846.2005.01.017YANG Hui, ZHANG Ji-wu. Research on application of mathematical morphology in detection of image[J]. Journal of Liaoning University: Natural Sciences Edition, 2005, 32(1): 50-53. (in Chinese). doi: 10.3969/j.issn.1000-5846.2005.01.017 [15] BAI Xiang-zhi, ZHOU Fu-gen. Edge detection based on mathematical morphology and iterative thresholding[C]//IEEE. 2006International Conference on Computational Intelligence and Security. New York: IEEE, 2006: 1849-1852. [16] 沈阳. 基于形态学的图像边缘检测技术研究[D]. 成都: 电子科技大学, 2008.SHEN Yang. Image edge detection based on morphological technology research[D]. Chengdu: University of Electronic Science and Technology of China, 2008. (in Chinese). [17] ZHOU Sheng-bo, SHEN Ai-qin, LI Geng-fei. Concrete image segmentation based on multiscale mathematic morphology operators and Otsu method[J]. Advances in Materials Science and Engineering, 2015, 2015: 1-11. [18] 姜绍飞, 苏莹. 分形理论在土木工程领域中的应用[J]. 工程力学, 2009, 26(增1): 148-152, 162. https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX2009S1036.htmJIANG Shao-fei, SU Ying. Fractal theory and its application in civil engineering[J]. Engineering Mechanics, 2009, 26(S1): 148-152, 162. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GCLX2009S1036.htm [19] 曹茂森, 任青文, 翟爱良, 等. 混凝土结构损伤的分形特征实验分析[J]. 岩土力学, 2005, 26(10): 1570-1574. doi: 10.3969/j.issn.1000-7598.2005.10.009CAO Mao-sen, REN Qing-wen, ZHAI Ai-liang, et al. Experimental study on fractal characterization in damages of concrete structures[J]. Rock and Soil Mechanics, 2005, 26(10): 1570-1574. (in Chinese). doi: 10.3969/j.issn.1000-7598.2005.10.009 [20] BORODICH F M. Some fractal models of fracture[J]. Journal of the Mechanics and Physics of Solids, 1997, 45(2): 239-259. doi: 10.1016/S0022-5096(96)00080-4 [21] NADEEM A, MEMON S A, LO T Y. Qualitative and quantitative analysis and identification of flaws in the microstructure of fly ash and metakaolin blended high performance concrete after exposure to elevated temperatures[J]. Construction and Building Materials, 2013, 38: 731-741. doi: 10.1016/j.conbuildmat.2012.09.062 [22] 张雄, 黄廷皓, 张永娟, 等. Image-Pro Plus混凝土孔结构图像分析方法[J]. 建筑材料学报, 2015, 18(1): 177-182. https://www.cnki.com.cn/Article/CJFDTOTAL-JZCX201501033.htmZHANG Xiong, HUANG Ting-hao, ZHANG Yong-juan, et al. Image-Pro Plus analysis of pore structure of concrete[J]. Journal of Building Materials, 2015, 18(1): 177-182. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JZCX201501033.htm [23] 周胜波. 荷载、温度和湿度多场耦合作用下路面水泥混凝土细观结构动态演化研究[D]. 西安: 长安大学, 2014.ZHOU Sheng-bo. Evolutionary rule of mesoscopic damage of cement concrete pavement under loading-temperaturehumidity coupling[D]. Xi'an: Chang'an University, 2014. (in Chinese). [24] 于蕾, 张君, 张金喜, 等. 水泥混凝土宏观性能与孔结构量化关系模型[J]. 哈尔滨工程大学学报, 2015, 36(11): 1459-1464. https://www.cnki.com.cn/Article/CJFDTOTAL-HEBG201511008.htmYU Lei, ZHANG Jun, ZHANG Jin-xi, et al. Quantitative relation model between macro performance and pore structure of cement concrete[J]. Journal of Harbin Engineering University, 2015, 36(11): 1459-1464. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-HEBG201511008.htm [25] 周秀文. 灰色关联度的研究与应用[D]. 长春: 吉林大学, 2007.ZHOU Xiu-wen. The study on the grey relational degree and its application[J]. Changchun: Jilin University, 2007. (in Chinese). -
点击查看大图
图(14) / 表(4)
计量
- 文章访问数: 2359
- HTML全文浏览量: 189
- PDF下载量: 2156
- 被引次数: 0
