-
摘要: 为了研究热棒在青藏公路多年冻土区的应用效果, 基于楚玛尔河试验监测场地8年的地温观测数据, 以水平温度梯度为指标, 分析了不同时期热棒的有效半径。为了提高热棒的调控效果, 拓展热棒的使用范围, 满足宽幅路基强吸热的使用要求, 依托北麓河与安多2个试验监测场地, 分析了热棒-XPS板路基与热棒-片块石路基地温监测数据。分析结果表明: 热棒工作1年后的有效半径约为2.3m, 此后, 随着热棒工作时间的增加, 热棒影响范围逐渐增大; 在热棒工作的前5年, 地温降幅明显, 周围土体地温降幅都基本维持在0.5℃以上, 之后每年降温较小, 这主要是由于外界环境温度升高, 气温与地温的温差逐渐减小, 热棒工作的动力逐渐衰减引起的; 在热棒工作的8年中, 由于热棒的持续制冷作用, 热棒路基的人为上限基本不变, 而普通路基同时期人为上限最大降低约为80cm; 热棒-XPS板路基从6月份开始, XPS板上下温差不断增大, 最大温差约为17℃, 有效阻隔了暖季大量热量向板下传递; 热棒-片块石路基通过2年的调控作用, 地温最大降幅为0.51℃。Abstract: In order to investigate the applicable effect of thermosyphon in permafrost regions along Qinghai-Tibet Highway, 8years'observational ground temperature data were collected from Chuma'er River test site, and the effective radius of thermosyphon was evaluated by taking the horizontal temperature gradient as the index. Additionally, to enhance the temperature-adjusted effect of thermosyphon, extend its application scope and meet the using demand of strong heat absorption of widened subgrade, the observational ground temperature data of the subgrade with XPS insulation board and thermosyphons and the subgrade with rock-crushed interlayer and thermosyphons at Beilu River and Anduo test sites were analyzed. Analysis result shows that the effective radius of thermosyphon after 1year's operation is about 2.3 m, and the influencing range gradually increases with the increase of operational time. Within the first 5 years of thermosyphon operation, the ground temperature obviously decreases, the ground temperature's decreasement around the thermosyphon is over 0.5 ℃, and then, the ground temperature slowlydecreases, which results from the decrease of ground-air temperature difference because of the increase of air temperature and the gradual decay of work motivation of thermosyphon. During8 years of thermosyphon operation, the artificial permafrost tables of thermosyphon subgrades are almost unchangeable because of thermosyphons'continuing refrigeration, while the maximum decrease of contemporaneous artificial permafrost table of common subgrade is about 80 cm. Since June for the subgrade with XPS insulation board and thermosyphons, the temperature difference between top and bottom of XPS insulation board gradually increases, and the maximum value is17 ℃, which effectively mitigates the downward transfer of heat in warm seasons. In 2years'adjustment of subgrade with crushed-rock interlayer and thermosyphons, the maximum decrease of ground temperature is 0.51 ℃.
-
Key words:
- subgrade engineering /
- permafrost region /
- thermosyphon subgrade /
- applicable effect
-
图 9 路基中心线地温对比
Figure 9. Comparison of ground temperatures at center lines of subgrades
图 10 直插热棒-XPS板复合路基
Figure 10. Combined subgrade with XPS insulation board and inserted thermosyphons
图 11 发卡热棒-XPS板复合路基
Figure 11. Combined subgrade with XPS insulation board and hairpin thermosyphons
图 12 一月上旬路中孔地温对比
Figure 12. Comparison of ground temperatures at mid-subgrade boreholes in early January
图 13 XPS板上下温差曲线
Figure 13. Curves of temperature difference between top and bottom of XPS insulation board
图 14 发卡热棒路基地温变化过程
Figure 14. Changing processes of ground temperatures of hairpin thermosyphon subgrade
-
[1] 汪双杰, 陈建兵, 李仙虎. 多年冻土地区公路修筑技术研究与工程实践[J]. 冰川冻土, 2009, 31(2): 384-392. https://www.cnki.com.cn/Article/CJFDTOTAL-BCDT200902028.htmWANG Shuang-jie, CHEN Jian-bing, LI Xian-hu. The highway construction technology in permafrost regions: research and engineering practice[J]. Journal of Glaciology and Geocryology, 2009, 31(2): 384-392. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-BCDT200902028.htm [2] 温智, 盛煜, 马巍, 等. 保温法保护多年冻土的长期效果分析[J]. 冰川冻土, 2006, 28(5): 760-765. doi: 10.3969/j.issn.1000-0240.2006.05.020WEN Zhi, SHENG Yu, MA Wei, et al. Long-term effect of insulation on permafrost on the Tibetan Plateau[J]. Journal of Glaciology and Geocryology, 2006, 28(5): 760-765. (in Chinese). doi: 10.3969/j.issn.1000-0240.2006.05.020 [3] 刘戈, 樊凯, 朱东鹏, 等. 多年冻土区路基调控措施的设计方法及适用性[J]. 公路交通科技, 2008, 25(9): 279-281, 290. https://www.cnki.com.cn/Article/CJFDTOTAL-GLJJ2008S1073.htmLIU Ge, FAN Kai, ZHU Dong-peng, et al. The design way and the applicability of the regulation[J]. Journal of Highway and Transportation Research and Development, 2008, 25(9): 279-281, 290. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GLJJ2008S1073.htm [4] MU Yan-hu, WANG Guo-shang, YU Qi-hao, et al. Thermal performance of a combined cooling method of thermosyphons and insulation boards for tower foundation soils along the Qinghai-Tibet Power Transmission Line[J]. Cold Regions Science and Technology, 2016, 121: 226-236. doi: 10.1016/j.coldregions.2015.06.006 [5] 李永强, 吴志坚, 王引生, 等. 青藏铁路冻土路基热棒应用效果试验研究[J]. 中国铁道科学, 2008, 29(6): 6-11. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK200806001.htmLI Yong-qiang, WU Zhi-jian, WANG Yin-sheng, et al. Test study on the application effect of the thermal pipes on the roadbed in the permafrost region along Qinghai-Tibet Railway[J]. China Railway Science, 2008, 29(6): 6-11. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZGTK200806001.htm [6] WU Di, JIN Long, PENG Jian-bing, et al. The thermal budget evaluation of the two-phase closed thermosyphon embankment of the Qinghai-Tibet Highway in permafrost regions[J]. Cold Regions Science and Technology, 2014, 103(7): 115-122. [7] WEN Zhi, SHENG Yu, MA Wei, et al. Analysis on effect of permafrost protection by two-phase closed thermosyphon and insulation jointly in permafrost regions[J]. Cold Regions Science and Technology, 2005, 43(3): 150-163. doi: 10.1016/j.coldregions.2005.04.001 [8] ZHANG Ming-yi, LAI Yuan-ming, ZHANG Jian-ming, et al. Numerical study on cooling characteristics of two-phase closed thermosyphon embankment in permafrost regions[J]. Cold Regions Science and Technology, 2011, 65(2): 203-210. doi: 10.1016/j.coldregions.2010.08.001 [9] 孙文, 吴亚平, 郭春香, 等. 热棒对多年冻土路基稳定性的影响[J]. 中国公路学报, 2009, 22(5): 15-20. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL200905002.htmSUN Wen, WU Ya-ping, GUO Chun-xiang, et al. Influences of two-phase closed thermosyphon on permafrost roadbed stability[J]. China Journal of Highway and Transport, 2009, 22(5): 15-20. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL200905002.htm [10] DONG Yuan-hong, LAI Yuan-ming, XU Xiang-tian, et al. Using perforated ventilation ducts to enhance the cooling effect of crushed-rock interlayer on embankments in permafrost regions[J]. Cold Regions Science and Technology, 2010, 62(1): 76-82. doi: 10.1016/j.coldregions.2010.03.003 [11] 潘卫东, 连逢愈, 邓宏艳, 等. 寒区工程中热棒技术的应用原理和前景[J]. 岩石力学与工程学报, 2003, 22(增2): 2673-2676. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2003S2027.htmPAN Wei-dong, LIAN Feng-yu, DENG Hong-yan, et al. Application principle and prospect of thermal-probe technique in cold regions engineering[J]. Chinese Journal of Rock Mechanics and Engineering, 2003, 22(S2): 2673-2676. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2003S2027.htm [12] ZHANG Ming-yi, LAI Yuan-ming, WU Qing-bai, et al. A full-scale field experiment to evaluate the cooling performance of a novel composite embankment in permafrost regions[J]. International Journal of Heat and Mass Transfer, 2016, 95: 1047-1056. doi: 10.1016/j.ijheatmasstransfer.2015.12.067 [13] 章金钊. 多年冻土地区公路路基设计技术研究[D]. 北京: 中国科学院研究生院, 2008.ZHANG Jin-zhao. Study on the heat conduction process of roadbed in permafrost region and new control methods[D]. Beijing: Graduate University of Chinese Academy of Sciences, 2008. (in Chinese). [14] 田亚护, 刘建坤, 沈宇鹏. 青藏铁路多年冻土区热棒路基的冷却效果三维有限元分析[J]. 岩土工程学报, 2013, 35(增2): 113-119. https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC2013S2020.htmTIAN Ya-hu, LIU Jian-kun, SHEN Yu-peng. 3-D finite element analysis of cooling effect of Qinghai-Tibet Railway embankment with thermosyphons in permafrost regions[J]. Chinese Journal of Geotechnical Engineering, 2013, 35(S2): 113-119. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC2013S2020.htm [15] MA Wei, MU Yan-hu, WU Qing-bai, et al. Characteristics and mechanisms of embankment deformation along the Qinghai-Tibet Railway in permafrost regions[J]. Cold Regions Science and Technology, 2011, 67(3): 178-186. doi: 10.1016/j.coldregions.2011.02.010 [16] 汪双杰, 黄晓明, 陈建兵, 等. 无动力热棒冷却冻土路基研究[J]. 公路交通科技, 2005, 22(3): 1-4, 20. doi: 10.3969/j.issn.1002-0268.2005.03.001WANG Shuang-jie, HUANG Xiao-ming, CHEN Jian-bing, et al. Research on frozen soil subgrade cooling by non-power heat pipe[J]. Journal of Highway and Transportation Research and Development, 2005, 22(3): 1-4, 20. (in Chinese). doi: 10.3969/j.issn.1002-0268.2005.03.001 [17] WU Jun-jie, MA Wei, SUN Zhi-zhong, et al. In-situ study on cooling effect of the two-phase closed thermosyphon and insulation combinational embankment of the Qinghai-Tibet Railway[J]. Cold Regions Science and Technology, 2010, 60(3): 234-244. doi: 10.1016/j.coldregions.2009.11.002 [18] LAI Yuan-ming, GUO Hong-xin, DONG Yuan-hong. Laboratory investigation on the cooling effect of the embankment with L-shaped thermosyphon and crushed-rock revetment in permafrost regions[J]. Cold Regions Science and Technology, 2009, 58(3): 143-150. doi: 10.1016/j.coldregions.2009.05.002 [19] SONG Yi, JIN Long, ZHANG Jin-zhao. In-situ study on cooling characteristics of two-phase closed thermosyphon embankment of Qinghai-Tibet Highway in permafrost regions[J]. Cold Regions Science and Technology, 2013, 93(9): 12-19. [20] ZHANG Ming-yi, LAI Yuan-ming, PEI Wan-sheng, et al. Effect of inclination angle on the heat transfer performance of a two-phase closed thermosyphon under low-temperature conditions[J]. Journal of Cold Regions Engineering, 2014, 28(4): 1-11. [21] JIN Long, WANG Shuang-jie, CHEN Jian-bing, et al. Study on the height effect of highway embankments in permafrost regions[J]. Cold Regions Science and Technology, 2012, 83-84: 122-130. doi: 10.1016/j.coldregions.2012.07.006 [22] 汪双杰. 高原多年冻土区公路路基稳定及预测技术研究[D]. 南京: 东南大学, 2005.WANG Shuang-jie. Study on highway subgrade stabilization and prediction technique in plateau permafrost region[D]. Nanjing: Southeast University, 2005. (in Chinese). [23] 刘戈, 汪双杰, 袁堃, 等. 尺度效应下冻土路基结构适应性及优化[J]. 中国公路学报, 2015, 28(12): 17-25. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL201512004.htmLIU Ge, WANG Shuang-jie, YUAN Kun, et al. Adaptability and optimization of permafrost embankment structure under scale effect[J]. China Journal of Highway and Transport, 2015, 28(12): 17-25. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-ZGGL201512004.htm [24] MA Wei, WEN Zhi, SHENG Yu, et al. Remedying embankment thaw settlement in a warm permafrost region with thermosyphons and crushed rock revetment[J]. Canadian Geotechnical Journal, 2012, 49(9): 1005-1014. doi: 10.1139/t2012-058 [25] 董元宏, 赖远明, 陈武. 多年冻土区宽幅公路路基降温效果研究——一种L型热管-块碎石护坡复合路基[J]. 岩土工程学报, 2012, 34(6): 1043-1049. https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201206014.htmDONG Yuan-hong, LAI Yuan-ming, CHEN Wu. Cooling effect of combined L-shaped thermosyphon, crushed-rock revetment and insulation for high-grade highways in permafrost regions[J]. Chinese Journal of Geotechnical Engineering, 2012, 34(6): 1043-1049. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201206014.htm -
下载:
点击查看大图
图(16)
计量
- 文章访问数: 852
- HTML全文浏览量: 144
- PDF下载量: 502
- 被引次数: 0
