Volume 14 Issue 5
. 
Turn off MathJax
Article Contents
Article Navigation >  Journal of Traffic and Transportation Engineering  > 2014  >  14(5): 1-7
PENG Yu-hua, HU Jia-yin, HU Shun-feng. Influence of AC-25 particle size distribution on gradation segregation[J]. Journal of Traffic and Transportation Engineering, 2014, 14(5): 1-7.
Citation: PENG Yu-hua, HU Jia-yin, HU Shun-feng. Influence of AC-25 particle size distribution on gradation segregation[J]. Journal of Traffic and Transportation Engineering, 2014, 14(5): 1-7.
shu

Influence of AC-25 particle size distribution on gradation segregation

  • Key Laboratory for Special Area Highway Engineering of Ministry of Education, Chang'an University, Xi'an 710064, Shaanxi, China

More Information
  • Author Bio:

    PENG Yurhua(1973-), male, professor, PhD, +86-29-82334453, pyh@chd.edu.cn

  • Received Date: 2014-07-21
  • Publish Date: 2014-10-25
    Abstract
  • Seven kinds of asphalt mixtures with typical gradations were produced by adjusting the scale of hot bunker of mixing plant in AC-25 gradation range.By Bailey method, AC-25 aggregate was divided into five gradation intervals such as 0-0.3, 0.3-1.18, 1.18-4.75, 4.75-13.2 and 13.2-31.5 mm.The grey relation degree of aggregate content and gradation segregation in each interval was calculated by gray relation method.Analysis result shows that the grey relation degree reflects the influence of aggregate content on gradation segregation in AC-25 gradation range very well.The relation degrees decrease in the order of 4.75-13.2, 0.3-1.18, 0-0.3, 1.18-4.75 and 13.2-31.5 mm.The relation degree is maximal in 4.75-13.2 mm, which illustrates that the variation of aggregate content in the interval has great effect on the final gradation variability of pavement, so a good segregation resistance gradation is obtained by adjusting the aggregate content.The relation degrees are smaller in 1.18-4.75 and 13.2-31.5 mm, which shows that coarse aggregate and the coarse part of fine aggregate have less influence on gradation segregation.The quadratic regression relation coefficient of aggregate content and gradation segregation in each interval is more than 0.6, which shows that the interaction amongaggregates has great influence on final gradation segregation, the segregation characteristic of aggregate gradation possibly weakens when the influence of single passing rate on the performance of asphalt mixture is considered only, so the segregation resistance performance of asphalt mixture gradation must be analyzed from different grain sizes'combination angle.

     

    • FullText(HTML)
  • loading
    • References(23)
  • [1]
    李艳春, 孟岩, 周骊巍, 等. 沥青混合料空隙率影响因素的灰关联分析[J]. 中国公路学报, 2007, 20 (1): 30-34. doi: 10.3321/j.issn:1001-7372.2007.01.006

    LI Yan-chun, MENG Yan, ZHOU Li-wei, et al. Grey relation degree analysis of influence factors on asphalt mixtures voids[J]. China Journal of Highway and Transport, 2007, 20 (1): 30-34. (in Chinese). doi: 10.3321/j.issn:1001-7372.2007.01.006
    [2]
    董泽蛟, 李生龙, 温佳宇, 等. 基于光纤光栅测试技术的沥青路面温度场实测[J]. 交通运输工程学报, 2014, 14 (2): 1-6, 13. doi: 10.3969/j.issn.1671-1637.2014.02.002

    DONG Ze-jiao, LI Sheng-long, WEN Jia-yu, et al. Real-time temperature field measurement of asphalt pavement based on fiber bragg grating measuring technology[J]. Journal of Traffic and Transportation Engineering, 2014, 14 (2): 1-6, 13. (in Chinese). doi: 10.3969/j.issn.1671-1637.2014.02.002
    [3]
    CHANG Ting-cheng, WEN Kun-li, CHEN Hung-shi. The selection model of pavement material via grey relational grade[C]//IEEE. 2000IEEE International Conference on Systems, Man, and Cybernetics. Nashville: IEEE, 2000: 3388-3391.
    [4]
    JORET A, SUBHI AL-BATAH M, ALI A N, et al. Ashac: an alternative towards classifying the shape of aggregate[C]//IEEE. 2007International Conference on Intelligent and Advanced Systems. Kuala Lumpur: IEEE, 2007: 239-243.
    [5]
    GEDIK A, LAV A H. Sulphur utilization in asphaltic concrete pavements[C]//AL-QADI I L. Airfield and Highway Pavement2013: Sustainable and Efficient Pavements. Los Angeles: American Society of Civil Engineers, 2013: 1175-1191.
    [6]
    LORIA L, HAJJ E Y, SEBAALY P E. Assessment of reflective cracking model for asphalt pavements[C]//STEYN W J, LIU Xue-yan, MEHTA Y, et al. Road Pavement and Material Characterization, Modeling, and Maintenance. Changsha: American Society of Civil Engineers, 2011: 72-79.
    [7]
    ULLOA A, HAJJ E Y, SIDDHARTHAN R, et al. Equivalent loading frequencies for dynamic analysis of asphalt pavements[J]. Journal of Materials in Civil Engineering, 2013, 25 (9): 1162-1170. doi: 10.1061/(ASCE)MT.1943-5533.0000662
    [8]
    TAO Zhuo-hui, NI Fu-jian, YAN Jin-hai, et al. Evotherm warm mix asphalt technology applied on ultra-thin pavement in China[C]//CHEN Dar-hao, ESTAKHRI C, ZHA Xudong, et al. Material Design, Construction, Maintenance, and Testing of Pavements. Changsha: American Society of Civil Engineers, 2009: 171-176.
    [9]
    ZHOU H P, HOLIKATTI S, VACURA P. Caltrans use of scrap tires in asphalt rubber products: a comprehensive review[J]. Journal of Traffic and Transportation Engineering: English Edition, 2014, 1 (1): 39-48. doi: 10.1016/S2095-7564(15)30087-8
    [10]
    ZHENG Yuan-xun, CAI Ying-chun, ZHANG Ya-min. Study on temperature field of asphalt concrete pavement[C]//CHEN Dar-hao, CHANG Jia-ruey, ZAMAN M, et al. Emerging Technologies for Material, Design, Rehabilitation, and Inspection of Roadway Pavements. Changsha: American Society of Civil Engineers, 2011: 266-273.
    [11]
    WU Zhong. Structural performance of thin asphalt pavement under accelerated pavement testing[C]//HUANG Bao-shan, BOWERS B F, MEI Guo-xiong, et al. Pavement and Geotechnical Engineering for Transportation. Nanchang: American Society of Civil Engineers, 2013: 1-18.
    [12]
    丁银萍. HMA级配离析特性的研究[D]. 大连: 大连理工大学, 2009.

    DING Yin-ping. Research on the graded segregation characteristics of HMA[D]. Dalian: Dalian University of Technology, 2009. (in Chinese).
    [13]
    包秀宁, 张肖宁, 吴旷怀, 等. 级配对矿质颗粒体离析的影响研究及应用[J]. 中山大学学报: 自然科学版, 2009: 48 (6): 48-53. doi: 10.3321/j.issn:0529-6579.2009.06.010

    BAO Xiu-ning, ZHANG Xiao-ning, WU Kuang-huai, et al. Research and application of the gradation impact on mineral granular masses segregation[J]. Acta Scientiarum Naturalium Universitatis Sunyatseni, 2009, 48 (6): 48-53. (in Chinese). doi: 10.3321/j.issn:0529-6579.2009.06.010
    [14]
    彭余华, 沙爱民, 罗志华, 等. 沥青混合料温度离析特性[J]. 长安大学学报: 自然科学版, 2008, 28 (6): 5-10. doi: 10.3321/j.issn:1671-8879.2008.06.002

    PENG Yu-hua, SHA Ai-min, LUO Zhi-hua, et al. Characteristics of the temperature segregation in asphalt mixture[J]. Journal of Chang & amp; amp; apos; an University: Natural Science Edition, 2008, 28 (6): 5-10. (in Chinese). doi: 10.3321/j.issn:1671-8879.2008.06.002
    [15]
    彭余华, 沙爱民. 沥青路面不均匀的影响因素分析[J]. 公路交通科技, 2006, 23 (6): 9-13. doi: 10.3969/j.issn.1002-0268.2006.06.003

    PENG Yu-hua, SHA Ai-min. Analysis of influence factors on non-homogeneity of bituminous pavement[J]. Journal of Highway and Transportation Research and Development, 2006, 23 (6): 9-13. (in Chinese). doi: 10.3969/j.issn.1002-0268.2006.06.003
    [16]
    麻旭荣, 李立寒. 沥青混合料级配离析判别指标的探讨[J]. 公路交通科技, 2006, 23 (2): 48-51. doi: 10.3969/j.issn.1002-0268.2006.02.012

    MA Xu-rong, LI Li-han. Study of index evaluating gradation segregation of hot mix asphalt[J]. Journal of Highway and Transportation Research and Development, 2006, 23 (2): 48-51. (in Chinese). doi: 10.3969/j.issn.1002-0268.2006.02.012
    [17]
    彭勇, 孙立军, 董瑞琨. 沥青混合料均匀性评价新方法的探讨[J]. 同济大学学报: 自然科学版, 2005, 33 (2): 166-168, 173. https://www.cnki.com.cn/Article/CJFDTOTAL-TJDZ200502005.htm

    PENG Yong, SUN Li-jun, DONG Rui-kun. Discussion about new method for evaluating homogeneity of hot mix asphalt[J]. Journal of Tongji University: Natural Science, 2005, 33 (2): 166-168, 173. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TJDZ200502005.htm
    [18]
    陈静云, 丁银萍, 周长红. 基于料堆试验的沥青混合料离析影响因素分析[J]. 东南大学学报: 自然科学版, 2009, 39 (1): 117-120. https://www.cnki.com.cn/Article/CJFDTOTAL-DNDX200901023.htm

    CHEN Jing-yun, DING Yin-ping, ZHOU Chang-hong. Analysis on influence factors for hot mix asphalt segregation using heap test[J]. Journal of Southeast University: Natural Science Edition, 2009, 39 (1): 117-120. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-DNDX200901023.htm
    [19]
    包秀宁, 张肖宁. 路面颗粒材料离析性的评价方法[J]. 华南理工大学学报: 自然科学版, 2010, 38 (3): 31-36. https://www.cnki.com.cn/Article/CJFDTOTAL-HNLG201003006.htm

    BAO Xiu-ning, ZHANG Xiao-ning. Segregability evaluation of granular pavement materials[J]. Journal of South China University of Technology: Natural Science Edition, 2010, 38 (3): 31-36. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-HNLG201003006.htm
    [20]
    刘曙光. AC-13粗集料离析评价方法及指标研究[D]. 长沙: 长沙理工大学, 2009.

    LIU Shu-guang. Researching on evaluation method and index of segregation in AC-13coarse aggregate[D]. Changsha: Changsha University of Science and Technology, 2009. (in Chinese).
    [21]
    张久鹏, 黄晓明, 高英. 沥青混合料非线性蠕变模型及其参数确定[J]. 长安大学学报: 自然科学版, 2009, 29 (2): 24-27, 55. https://www.cnki.com.cn/Article/CJFDTOTAL-XAGL200902009.htm

    ZHANG Jiu-peng, HUANG Xiao-ming, GAO Ying. Nonlinear creep model of asphalt mixture and parameter determination[J]. Journal of Chang & amp; amp; apos; an University: Natural Science Edition, 2009, 29 (2): 24-27, 55. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-XAGL200902009.htm
    [22]
    孙玉刚. 灰色关联分析及其应用的研究[D]. 南京: 南京航空航天大学, 2007.

    SUN Yu-gang. Research on gray incidence analysis and its application[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2007. (in Chinese).
    [23]
    党耀国, 刘思峰, 刘斌, 等. 灰色斜率关联度的改进[J]. 中国工程科学, 2004, 6 (3): 41-44. https://www.cnki.com.cn/Article/CJFDTOTAL-GCKX200403007.htm

    DANG Yao-guo, LIU Si-feng, LIU Bin, et al. Improvement on degree of gray slope incidence[J]. Engineering Science, 2004, 6 (3): 41-44. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-GCKX200403007.htm
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF
    XML

    Article Metrics

    Article views (621) PDF downloads(899) Cited by()
    Proportional views
    Related

    Copyright《Journal of Traffic and Transportation Engineering》编辑部陕ICP备05001904号-1

    Address ：Editorial Department of Journal of Traffic and Transportation Engineering, Chang 'an University, Middle Section of South Second Ring Road, Xi 'an, Shaanxi（710064） Tel：029-82334388 Email：jygc@chd.edu.cn

    All visit:Today's visit:

    Supported by: Beijing Renhe Information Technology Co. Ltd    

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return