Dewatering model test of advanced deep hole in deep-buried tunnel

ZOU Chong; LEI Sheng-you; ZHANG Wen-xin

doi:10.19818/j.cnki.1671-1637.2019.05.005

Volume 19 Issue 5

Turn off MathJax

Article Contents

Article Navigation > Journal of Traffic and Transportation Engineering > 2019 > 19(5): 42-52

Next Previous

ZOU Chong, LEI Sheng-you, ZHANG Wen-xin. Dewatering model test of advanced deep hole in deep-buried tunnel[J]. Journal of Traffic and Transportation Engineering, 2019, 19(5): 42-52. doi: 10.19818/j.cnki.1671-1637.2019.05.005

Citation:

ZOU Chong, LEI Sheng-you, ZHANG Wen-xin. Dewatering model test of advanced deep hole in deep-buried tunnel[J]. Journal of Traffic and Transportation Engineering, 2019, 19(5): 42-52. doi: 10.19818/j.cnki.1671-1637.2019.05.005

Citation:

PDF( 11025 KB)

Dewatering model test of advanced deep hole in deep-buried tunnel

doi: 10.19818/j.cnki.1671-1637.2019.05.005

ZOU Chong^{1, 2
,},
LEI Sheng-you³,
ZHANG Wen-xin^{1
,
,}

1.
China Railway Tunnel Consultants Co., Ltd., Guangzhou 511458, Guangdong, China
2.
State Key Laboratory of Shield Machine and Boring Technology, China Railway Tunnel Group Co., Ltd., Zhengzhou 450001, Henan, China
3.
School of Highway, Chang'an University, Xi'an 710064, Shaanxi, China

More Information

Author Bio:
ZOU Chong(1971-), male, professor, 531919647@qq.com

ZHANG Wen-xin(1981-), male, senior engineer, zwx1981112@163.com
Received Date: 2019-05-04
Publish Date: 2019-10-25

Abstract

Abstract

For the problem of tunnel palm surface collapsing and initial support cracking deformation caused by the sudden water surge in the weak glue-rich water powder fine sandstone, the advanced deep hole dewatering method in deep-buried tunnel was studied. A solid model for simulating the tunnel advanced dewatering was established. The water level surface changes of the model at each moment under 3 kinds of dewatering tubes and 3 kinds of pumping powers were analyzed. The three-axis test was used to analyze the failure state of powder fine sandstone with high water content. Research result shows that the water head in the middle part of dewatering test model at the same elevation measuring point on the tangent section is low, rises gradually on both sides, and is in a parabola form, reflecting the dewatering laws of advanced deep hole. The powder fine sandstone failures plastically under high and low water contents, and the axial strain at the failure is less than 5%. In the dewatering process, when the stratum water content decreases from 20% to 11%, the strength, cohesion, and internal friction angle of powder fine sandstone reach the optimal stable states, realizing the waterless state of excavation surface. The advanced dewatering parameters in the tunnel should be the vacuum dewatering pipe with the diameter of 65 mm and the vacuum pump with the pumping power of 7.5 kW. The dewatering pipe should be arranged at the side walls on both sides of tunnel and at 20 m ahead of tunnel palm surface. The advanced deep hole dewatering supplemented with grouting reinforcement in the deep-buried tunnels with rich water powder fine sandstone can achieve the stability of powder fine sandstone during the excavation. It lays the foundation for the smooth construction of tunnel, and avoids the difficulty of deep well dewatering from the surface in the deep-buried tunnels.
- tunnel engineering,
- rich water powder fine sandstone,
- advanced deep hole,
- model test,
- dewatering law

FullText(HTML)

References(30)

References

[1]	YANG Yong. Application of vacuuming ground-water lowering inside the shallow excavation tunnel in sandy watery stratum[J]. Municipal Engineering Technology, 2009, 27(4): 382-384. (in Chinese). doi: 10.3969/j.issn.1009-7767.2009.04.018
[2]	SHI Wen-jie. Dewatering technology for construction of saturated powdery sand by shallow buried excavation[J]. Tunnel Construction, 2005, 25(2): 34-35. (in Chinese). doi: 10.3969/j.issn.1672-741X.2005.02.011
[3]	WANG He-ping, MEI Sheng. Discussion on issues of vacuum point well in dewatering engineering[J]. Journal of Guangdong University of Technology, 2001, 18(3): 110-114. (in Chinese). doi: 10.3969/j.issn.1007-7162.2001.03.024
[4]	ZHUO Yue, ZHANG Min-qing. Study and application of light well point dewatering in tunnel[J]. Construction Technology, 1994(9): 39-41. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-SGJS409.016.htm
[5]	TIAN Sheng-li. Construction and application of dewatering of well point in Shapotou Water Diversion Tunnel[J]. Science and Technology Information, 2010(13): 694-695. (in Chinese). doi: 10.3969/j.issn.1001-9960.2010.13.556
[6]	WANG Li-ping. The study on test and numerical simulation about dewatering of horizontal well[D]. Jiaozuo: Henan University of Technology, 2009. (in Chinese).
[7]	ZHANG Jian-qi. Application of dewatering measures in construction of third series water rich sandstone tunnel[J]. Railway Engineering, 2013(8): 76-78. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TDJZ201308027.htm
[8]	ZHANG Xue-wen. Advanced double-drift construction technologies for Taoshuping Tunnel crossing water-rich fine silty sand strata[J]. Tunnel Construction, 2016, 36(5): 577-584. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-JSSD201605018.htm
[9]	QI Wei-hua. Construction of a railway tunnel in water-rich tertiary sandstone[J]. Moderm Tunnelling Technology, 2015, 52(1): 577-584. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD201501026.htm
[10]	XIONG Chun-geng. The key technology of the construction of the tertiary water-rich and weakly cemented sandstone tunnel[J]. Journal of Lanzhou Jiaotong University, 2017, 36(4): 60-66. (in Chinese). doi: 10.3969/j.issn.1001-4373.2017.04.010
[11]	LI Guo-liang, WANG Fei. Major technical measures of the third series argillaceous weak cementation rich water silty sand rock tunnelss[J]. Journal of Chonqing Jiaotong University(Natural Science), 2015, 34(4): 39-44. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-CQJT201504007.htm
[12]	ZHANG Min-qing, HE Zhi-jun, XIAO Guang-zhi, et al. Research on the tunnel engineering characteristics and construction technology of the tertiary water rich sand[J]. Journal of Railway Engineering Society, 2016(9): 76-81. (in Chinese). doi: 10.3969/j.issn.1006-2106.2016.09.014
[13]	LI Shi-cai, SHI Guang-rong, WU Jun. Construction techniques of advance reinforcement for immature fine sandstone stratum with rich water in Taoshuping Tunnel[J]. Modern Tunnelling Technology, 2011, 48(2): 116-119. (in Chinese). doi: 10.3969/j.issn.1009-6582.2011.02.023
[14]	ZHANG Zai-ren. Deep well water drainage technology for Taoshuping Tunnel[J]. Railway Construction Technology, 2014(7): 78-80, 100. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TDJS201407022.htm
[15]	WANG Guang-hong, LUO Li-bin. Study of tunnel dewatering technology in water-rich immature fine silty sand strata[J]. Tunnel Construction, 2018, 38(S1): 142-147. (in Chinese). doi: 10.3973/j.issn.2096-4498.2018.S1.022
[16]	ZHOU Wei. Discussion dewatering technology of the construction of shallow buried excavation in the subway tunnel[J]. China New Technologies and Products, 2011(10): 124. (in Chinese). doi: 10.3969/j.issn.1673-9957.2011.10.119
[17]	HA Ji-zhang, HUANG Wei-wang, SHAO Da-peng. Comprehensive construction techniques for a tunnel in water-soaked gravel and sand[J]. Modern Tunnelling Technology, 2011, 48(2): 128-131, 136. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD201102025.htm
[18]	YANG Bao-xu. Study on construction technology of sluicing and dewatering decompression in water-rich sandstone and mudstone tunnel[J]. Railway Construction Technology, 2017(9): 66-68, 80. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TDJS201709018.htm
[19]	PAN Xiu-ming, WANG Guo-feng, LEI Jun, et al. True air pipe well recombination water technology and its application in the ground iron engineering research[J]. Railway Stanadrd Design, 2018(12): 58-62. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TDBS200812025.htm
[20]	HUANG Jun, ZHANG Ding-li, CHEN Lai-sheng. Shallow tunnel construction technology in watery and weak straum[J]. Geotechnical Engineering Technique, 2004, 18(6): 295-298. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-YTGJ200406006.htm
[21]	ZOU Chong, ZHANG Wen-xin, LI Zhi-guo, et al. An advanced dewatering method for deep buried tunnels: China, 201210140354.7[P]. 2014-04-09. (in Chinese).
[22]	邹翀, 张文新, 李治国, 等. 一种开挖深埋隧道时洞内综合降水的施工方法: 中国, 201310240988.4[P]. 2015-08-12.
[23]	WU Li-bo, NIU Fu-jun, LIN Zhan-ju, et al. Effect of replacing-filling and dewatering-draining measures on frozen characteristics of weak subgrade in cold valley region[J]. Journal of Traffic and Transportation Engineering, 2018, 18(4): 22-33. (in Chinese). http://transport.chd.edu.cn/article/id/201804003
[24]	ZENG Ling, LIU Jie, SHI Zhen-ning. Effect of colluvial soil slope fracture's anisotropy characteristics on rainwater infiltration process[J]. Journal of Traffic and Transportation Engineering, 2018, 18(4): 34-43. (in Chinese). http://transport.chd.edu.cn/article/id/201804004
[25]	WANG Qing-lin, LIU Xiao-xiang. Analysis of the relationship of water ratio to the stability of surrounding rock in a tertiary water-rich fine sandstone stratum[J]. Modern Tunnelling Technology, 2012, 49(4): 1-5. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD201204003.htm
[26]	GAO Qin-yun. Relationship study of water content and surrounding rock stability in third series sandstone of Lanyu Railway Tunnel[J]. Railway Engineering, 2015(3): 62-64. (in Chinese). https://www.cnki.com.cn/Article/CJFDTOTAL-TDJZ201503018.htm
[27]	YAN Chang-gen, ZOU Qun, XU Yu, et al. Warer migration rule of loess subgrade with sand interlayers[J]. Journal of Traffic and Transportation Engineering, 2016, 16(6): 21-29. (in Chinese). http://transport.chd.edu.cn/article/id/201606003
[28]	HAN Long-wu, CAI Han-cheng, CHENG Jia, et al. Freezing and thawing characteristics of seasonal frozen soil along Moscow-Kazan High-Speed Railway[J]. Journal of Traffic and Transportation Engineering, 2018, 18(3): 44-55. (in Chinese). http://transport.chd.edu.cn/article/id/201803005
[29]	DUAN Wei, CAI Guo-jun, LIU Song-yu, et al. Determining method of cohesionless soil state parameter based on resistivity CPTU and liquefaction evaluation[J]. Journal of Traffic and Transportation Engineering, 2019, 19(2): 59-68. (in Chinese). http://transport.chd.edu.cn/article/id/201902006
[30]	FENG Zhong-ju, WANG Xi-qing, LI Xiao-xiong, et al. Effect of sand liquefaction on mechanical properties of pile foundation under strong earthquake[J]. Journal of Traffic and Transportation Engineering, 2019, 19(1): 71-84. (in Chinese). http://transport.chd.edu.cn/article/id/201901008

Relative Articles

Supplements(0)

Cited By

Get Citation

PDF

XML

Article Metrics

Article views (1351) PDF downloads(525)

Dewatering model test of advanced deep hole in deep-buried tunnel

doi: 10.19818/j.cnki.1671-1637.2019.05.005

Abstract

References

Catalog

Article Metrics

Related

Dewatering model test of advanced deep hole in deep-buried tunnel

doi: 10.19818/j.cnki.1671-1637.2019.05.005

Abstract

References

Catalog

Article Metrics

Related

Export File

Citation

Format

Content